How to tell if a Yamaha golf cart battery pack is failing?
If the spin occurs doing the same test with a big jumper and on the larger posts on the solenoid, then the solenoid is not functioning. The absence of a spin in this test could mean your Yamaha golf cart’s battery pack is failing.
What are the most common problems with a Yamaha G1 golf cart?
A clear sign that their is a fault with your golf cart is when it only runs with the choke. Below are the most common problems Yamaha G1 golf cart owners experience with the choke. Check for air leakage starting from the filter box to the head. It’s also worthwhile checking the compression.
Why is there oil in the airbox of my Yamaha golf cart?
If that’s the case then you need to rebuild your engine to replace the rings and fix the problem. Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine.
Why is my Yamaha gas golf cart losing power?
Why does my Yamaha golf cart have no power? Your Yamaha golf cart may have no power due to a problematic fuel filter, a cracked rubber boot, dirt/debris accumulation, or improper combustion. If you have an electric golf cart, faulty batteries or wrong battery connections may also cause the problem.
How can I make my Yamaha gas golf cart go faster?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
How do I start my gas golf cart in the cold?
0:364:20How to Cold Start A Club Car Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipThis is your forward and forward neutral in reverse you want to pull this piece out right here. AndMoreThis is your forward and forward neutral in reverse you want to pull this piece out right here. And turn it until it locks back in we should be in service mode.
How does a Yamaha golf cart fuel pump work?
The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.
How do you adjust the governor on a gas golf cart?
0:545:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut.MoreIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut. The more you tighten the larger nut the faster your cart will.
How fast will a Yamaha gas golf cart go?
19 mphAlthough, new gasoline and electric golf cart versions of Yamaha all have the same top speed. The top speed of both versions of Yamaha golf carts is 19 mph (31 kph).
How do you winterize a Yamaha gas golf cart?
Winter Storage Tips for Your Golf CartClean the vehicle. Before storing, it is imperative that you clean your golf cart, inside and out. ... Drain the fuel. Drain the gas from your cart. ... Perform a full check up. ... Prepare the battery. ... Inflate the tires. ... Ensure the cart won't move. ... Park the vehicle in the proper position.
Can you run a golf cart in winter?
Although driving a golf cart in the snow is possible, golf is not a Winter sport, so you rather store your cart for the cold period. However, do not wait for the snow to fall but prepare your electric golf cart for long-term storage when the leaves start falling and temperatures drop significantly.
How do you start a Yamaha gas golf cart?
1:412:58Yamaha Golf Car- Consumer - Operating Basics - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition during the key switch to the on. Position slowly press the accelerator pedal to disengageMorePosition during the key switch to the on. Position slowly press the accelerator pedal to disengage the farc brake and gently apply pressure to the accelerator pedal to increase the speed.
How do you know if fuel pump is bad on golf cart?
Fuel Pump Problems The simple answer is the engine doesn't run as well as it should. More specifically, you may have trouble with your engine at low speeds, or it may lose power at high speeds. If your clog is especially bad, the engine sputters to a halt or may not even start.
Should fuel filter be full on golf cart?
Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, facing a glitch.
How does Mikuni fuel pump work?
0:120:59Identify your Mikuni style fuel pump ports. Input, output, and pulse.YouTubeStart of suggested clipEnd of suggested clipAnd there's little arrows pointing in that direction. And little arrows right there pointing in thisMoreAnd there's little arrows pointing in that direction. And little arrows right there pointing in this direction so the p is for the pulse that's what drives the pump that goes to your engine.
When to use a golf cart choke?
A golf cart choke is often used when a cold engine is started. It controls the airflow when fuel is moved to the engine. The choke is released when the mixture is stabilized and the engine can operate by itself without any restriction of air.
Why do golf carts get fouled up?
The spark plugs and valves of the cart may get fouled up due to the richness of the engine. They will have to be removed and cleaned using a brake or carburetor cleaner followed by their reinstallation. The speed of the golf cart tends to reduce considerably if it has been driven with the choke on for a long time.
Why does my car have air leaks?
There may be air leaks because of cracks in the adapter plate housing the carburetor, carburetor, spacer, gaskets or air hose from the fuel pump to the engine. A missing plug in the bottom of the air box also causes the problem.
Why does my gas cart show poor gas economy?
The cart shows signs of poor gas economy because the choke opens only partly. The engine of the cart tends to lose power or run rough due to incorrect choke adjustment. The cart shows poor performance when running at low speed because the choke is on or pulled out. The spark plugs of the cart get damaged due to choke seizure when ...
How to fix a carburetor?
To fix it, Check the cable of the carburetor to see if it’s in good condition. Press the accelerator and check if the engine begins turning over before the carburetor gets opened up by the cable. If this is not happening, the accelerator cable that is present inside the electrical component box must be adjusted.
Why does my carburetor heat up?
The carburetor needs cleaning or is missing a component. Check for dirt accumulation in the carburetor and clean it up immediately. The dirt build-up can cause the carburetor to heat up. Inspect the carburetor closely to see if all components are present. The absence of parts like fuel filters can trigger this problem.
Why does my car run rich?
The engine tends to run rich, which will, in turn, increase fuel consumption and decrease the mileage. Depending on the condition of the engine, its performance can get affected because of the inability to draw the same amount of air as in high-speed situations.
Why is there oil in my Yamaha golf cart?
Why is there oil in the airbox of your Yamaha golf cart? There’s oil in your airbox because there’s too much oil in your engine. If there’s too much oil, it’s probably because of a mismarked dipstick in your engine. To fix this, drain out all the oil in your engine then fill in exactly one quart of oil.
Why does my Yamaha golf cart smoke?
A Yamaha golf cart may be smoking because the exhaust is plugged with burnt oil that causes back pressure. If it’s blowing the oil fill cap off, then oil is clogged up and causing pressure in the crankcase.
Why does my Yamaha G16 burn oil?
Your Yamaha G16 is burning oil because it has fuel in the oil. The first thing you should try to fix the burning oil problem is replace the old oil in your cart with exactly one quart of high quality oil. Hopefully this immediately fixes your problem. If your oil is overfull then your G16 will burn oil.
Why is my G16 oil overfilled?
Your oil being overfull might be because you lifted your cart which causes your oil dipstick reading to be off (the full mark is incorrect). This causes you to overfill your oil. If your oil smells like gas and is too overfull then gas will get dumped into the crankcase of your G16 and cause smoking.
How to fix a G16 engine?
To fix this, take out your airbox and clean it, clean your carburetor, drain your oil and fill in exactly one quart of oil.
Why is my Yamaha G9 smoking?
Your Yamaha G9 might be smoking because your oil rings are stuck on a piston due to engine sludge buildup. If this is the case, your engine needs to be rebuilt to fix it. Your G9 might be smoking because of oil in the muffler. Run your cart hard for 30 minutes to an hour or cook your muffler in a bonfire to fix this.
How to fix a G16 airbox?
Fix this by draining your G16’s oil and then filling in exactly one quart. Clean out the excess oil in your airbox as well.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
How to tell if a battery is leaking?
It can begin with the batteries taking longer and longer to charge, and the charge they take, they don’t keep very long. Physical signs can include bulging sides, cracks or, in extreme cases, leaking battery acid. If the engine or motor turns over slowly, get out a multimeter and make this quick test.