Full Answer
How many volts is a golf cart battery?
48 Volt Golf Cart Example (12V Batteries): 6 holes X 2 volts = 12 volt battery. 12 volt battery X 4 total batteries = 48 volt system. If you have additional questions about your batteries or charger, check out our Battery Charger Frequently Asked Questions page.
Is it bad for a golf cart battery to go dead?
As letting the batteries go completely dead is very bad for the batteries and will definitely cut the life expectancy short. In the golf cart business we use a golf cart battery recovery unit like BatteryPete’s Super Charger to jump start the golf cart in seconds or minutes to get the customers golf cart battery charger to kick on…
What state should a golf battery be in at the end?
The state of charge or discharge golf batteries are in at the end of the day depends upon the type of play and the number of holes the golf cart was used for. The battery charger is designed to bring a normally discharged battery back to full or nearly full charge in a given time.
How much should you discharge a golf cart battery?
Use your golf cart and batteries often…avoid long periods of storage. 50% (or less) discharges are recommended. 80% discharge is the maximum safe discharge. Do not fully discharge lead-acid batteries (80% or more). This will damage (or kill) the battery.
How many volts should a golf cart battery have?
Healthy batteries will indicate about 50 to 52 volts on the voltmeter. Most battery packs hold around 48 volts. Keep in mind that the high number doesn't mean that the batteries are instantly good.
What voltage is considered a dead battery?
11.9 voltsA battery is only charged by one quarter at just 12 volts. Once it drops to 11.9 volts, your battery is considered dead. Keep in mind that most modern vehicles demand more power than ever because of all the power needed to operate electronics. To charge your battery using a battery charger, follow the directions below.
At what point is a 12v battery dead?
12.0 volts12.0 volts or below - At 12.0 volts your battery is considered to be fully discharged or 'flat' and should be recharged as soon as possible. The lifespan of your battery will be severely affected if it remains within this voltage range for extended periods of time.
How do you know when golf cart batteries are dying?
8 Signs You Need to Replace Your Golf Cart BatteriesCharge Times Are Out of Hand. Just like any rechargeable battery, the repeated cycles of draining and charging your battery can take a toll on it. ... No “Get Up and Go” ... You See Visual Signs. ... Driving Until They Die. ... People Are Always Running The Radio.
Is 11.9 volts enough to start a car?
For a car with a 12V engine, the normal value before starting is between 12.2V and 12.8V, and it should not exceed 14.8V after starting.
Is 12.2 volts enough to start a car?
When the battery voltage lowers to 12.2 volts without the engine running, it is considered a bad battery that may start your engine but is no longer capable of holding a charge.
Is 12.4 volts enough to start a car?
The modern standard worldwide is 12V, but this parameter is changeable: The normal voltage needed to start the car begins from 12.6 volts. At the time of exploitation, this parameter is between 13.7 to 14.7 volts.
Is 12.3 volts enough to start a car?
When the probes touch the terminals while the car is off and the battery is resting, the multimeter display should show a reading of 12.2 to 12.6 volts (full charge). This voltage range means the battery is in good condition for starting the vehicle.
Is 12.3 volts a good battery?
A fully charged battery will typically display a voltmeter reading of about 12.6 to 12.8 volts. If your voltmeter is showing a voltage anywhere between 12.4 and 12.8, that means your battery is in good shape. Any voltage above 12.9 volts is a good indicator that your battery has excessive voltage.
How many volts is a full charge on a 48 volt golf cart?
55.2 to 56.6 voltsThe peak charging voltage for Gel batteries is 2.3 to 2.36 volts per cell, and for a 48 volt charger this works out to 55.2 to 56.6 volts, which is lower than a wet or AGM type battery needs for a full charge.
How many volts should a fully charged 36 volt golf cart have?
The target voltage for a 36 volt charger for AGM or some flooded batteries is 2.4 to 2.45 volts per cell, which is 43.2 to 44.1 volts.
How do I test my golf cart batteries with a battery?
1:186:18How to Test Golf Cart Batteries - Troubleshooting Batteries - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd we're gonna watch these battery voltage hold as we pull the amps off of the battery. On a loadMoreAnd we're gonna watch these battery voltage hold as we pull the amps off of the battery. On a load test I'm gonna rate the load about half of the CCA's. That the battery has brand-new which is 650.
What is a voltage drop of 0.30 volts?
Conduct a voltage drop test. Voltage drop under load should be almost 0-volts. A voltage drop above 0.30-volts is a sign of excessive resistance. In that case, replace the fuse box.
What happens if the fuse bracket is too high?
If the fuse bracket shows signs of corrosion, heat distortion or insulation melting, that heat can also burn the fuse terminals.
What happens if the fuse block corrodes?
When the fuse block corrodes, it prevent field power to the alternator and that will test out as a bad alternator if you just rely on a voltage test at the battery. If you fall for that, you’ll replace the alternator and it still won’t charge properly.
How many volts does a golf cart have?
There is a major difference between 36 volt up to 48 volt systems, impacting both performance and potential upkeep and maintenance costs. Hint: some batteries are much more expensive ...
What is the amperage of a golf cart?
Golf Cart Battery Amps. Amperage can be considered akin to the fuel in a gas-powered engine. Similar to a tank of gas, the amount of amperage will dictate how far you can drive your cart on a single electric charge.
What does the owner manual on a golf cart tell you?
If uncertain, referring to your golf cart’s owner manual will provide guidance as to the type of battery your make and model was made to handle. As always, if you have questions or need further assistance, our talented and highly trained staff is standing by to assist and make sure you get just what you need to enjoy the trails or links worry-free.
What does voltage mean in a battery pack?
Voltage represents how much power your system will be delivered, resulting in increased ability to tow, carry more weight, and accelerate faster.
Does a golf cart battery need to be recharged?
In this regard, a higher voltage (although more powerful) often comes at a cost. That cost is that it can burn through more amps faster, draining the golf cart battery quicker, and requiring you to recharge more frequently.
What does it mean when your golf battery drains?
When the battery drains when parked, the odds are that it’s the battery itself. If your Golf’s battery light came on while you were driving, but before you parked, it could be the alternator. If you didn’t see a battery light, and now the vehicle is dead when you go to start it, the first thing that you need to look at is the battery.
Why is my Volkswagen Golf battery draining?
If it is draining while your Golf is off, it’s usually caused by something that is drawing current that shouldn’t be. If the battery is draining while you’re driving, that is probably going to be the alternator or battery.
Why is my alternator not charging?
It is possible that the alternator wasn’t charging the battery enough when the vehicle was running and has left the battery drained. Most parts stores can test an alternator for you. They usually don’t charge anything for this service, they just want to sell you an alternator if you need it.
What to look for when your golf is drawing power?
Something is drawing power when it shouldn’t be. If this is the case, the first thing that you are going to want to look at is all of the lights. If your Golf is equipped with a glove compartment light, check and see if it is turning off. Maybe one of the map lights is on? How about all of the accessory plugs? Is something plugged into one of them and drawing power? Any aftermarket accessories? If not, it may be that there is an electrical problem.
Can a bad battery cause a whining noise?
It could be a bad battery, or more likely a bad battery cable too. But it’s not very likely. If you hear a whining noise accompanied by the battery light, it’s almost guaranteed that it’s the alternator that is at fault.
How many volts does a golf cart battery need?
Others require a little less. So for example a 36 volt battery charger would require approx. 25-30 volts to activate, whereas a 48 volt charger would require 30-35 or even 40 volts present to activate.
What does it mean when a golf cart battery is bad?
So being if the golf cart battery cable lug connector or connection between two batteries is bad the cart will usually not work, drive or charge. So check all the connections and cables for signs of corrosion or wear or completely broken off battery.
How does a 12 volt battery charger work?
So being in a pinch a 12 volt battery charger will work to get some energy back into your dead golf cart batteries and revive them. The sole purpose here is to just get some energy back into the batteries so the golf cart battery charger itself can do the brunt of the charging and charge the batteries properly.
What type of battery is used in a golf cart?
Systems comprised of 6x 6 volt batteries… Usually found in older golf carts ( Pre-1990’s) across the board Club Car, Ezgo and Yamaha Brands but also Columbia, Harley Davidson ( Yep – Harley used to make a golf cart as they also made boats under AMF) other carts include Fairplay, Par Car or Western. For this system you will need either a 6 volt battery charger to charge individually by placing the charger connections on the positive and negative terminals of each individual battery. Or you can use a 12 volt battery charger and place the charger connections on the positive terminal of the first battery and then the negative connection on that of the second battery. This will cut charge time down as you have less connections to make and depending on the charger output could decrease charge times. See Illustrations and images above.
Why does my golf cart beep?
If you can get enough voltage and energy back into the batteries to make the golf cart move, beep or lights to work usually means there is enough voltage present at this point for the original golf cart battery charger to be plugged in and it will turn on to charge the batteries completely.
How to charge a 12 volt golf cart battery?
For these systems you can just use a 12 volt battery charger to charge each battery individually by placing the charger connections on the positive and negative terminals of each individual battery. You can again speed up the process if you happen to have that heavy duty battery charger with a 12v/24v adjustable output feature. ( Usually common on car lots and dealerships back in the day) Then you can charge up the bank even faster ( limited by charger output) place the charger connections on the positive terminal of the first battery and then the negative connection on that of the second battery that make up 24 volts. This will cut charge time down as you have less connections to make and depending on the charger output could decrease charge times. See Illustrations and images above.
Why does my golf cart charger not know if it's plugged in?
So basically if the batteries in your golf cart are dead then the charger does not know it is plugged into a golf cart because it does not sense any voltage.
How to tell if your golf cart battery is bad?
Symptoms of a failing battery or batteries could include the following: 1 You may notice the range decreasing over time. The range should be about 2 rounds of golf. 2 A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the controller not engaging when the voltage falls below a preset value. 4 It takes twice as long to charge your batteries as it did when you first had them installed. As the batteries age, they will not hold a charge as well as they used to. The charger has no way to know this and will continue to charge the batteries trying to get to a full charge – meaning it will take longer to charge the batteries than normal.
When do golf cart batteries discharge?
The state of charge or discharge golf batteries are in at the end of the day depends upon the type of play and the number of holes the golf cart was used for. The battery charger is designed to bring a normally discharged battery back to full or nearly full charge in a given time. When charging, allow enough time for a complete charge cycle.
How Much Does It Cost To Replace The Batteries In A Golf Cart?
The cost of replacing the battery pack typically runs from $800 to $1500 depending on the number of batteries needed and the brand you go with.
What Is The Best Golf Cart Battery?
Trojan T-105 batteries are the best-known premium battery and have nearly 100 years of manufacturing experience. Trojan Battery Company was founded in 1925 and developed the golf cart battery for the Autoette in 1952. The distinctive maroon color of the T-105 makes it easy to distinguish from its competitors.
Why would my battery go bad?
As mentioned earlier, the electrolyte level must be kept at optimum levels or damage can be done to the plates inside. Incorrectly watering is the major cause of problems in batteries.
How many amps does a golf cart battery take to recharge?
To recharge, the batteries will require 90 ampere-hours + 20% to make up for any charge deficiency.
How to tell if your golf cart is low voltage?
You may notice the range decreasing over time. The range should be about 2 rounds of golf. A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage.
