Why won’t my club car golf cart move?
A Club Car golf cart will not move if power from the battery pack is not reaching the motor. Faulty parts such as the solenoid, OBC and wiring can also cause a golf cart to not move. There are several reasons why your club car won’t move: Batteries; in a pack of 3 or 4 batteries even if one fails, the required power won’t reach the motor
How does a club car controller work?
It monitors the state of the motor and generates a signal to match the alternating currents. The Club Car controller is also known as a speed controller, and the best thing about the controller is that it works as a brain and speed control system for the golf cart.
Which speed controller is best for my club car?
This Club Car controller is best suited for two passenger carts. This speed controller can be paired with a small 2 HP or 5 HP motor. You will most likely find this Club Car controller in the 36 Volt carts. This controller is preferable for Club Cars with rear seats and a cargo bed, and the Club Cars that are used for rides that have steep hills.
What size club car controller do I Need?
200-300 Amp controllers are perfect if you intend to use a Club Car for regular trips around the neighborhood. This Club Car controller is best suited for two passenger carts. This speed controller can be paired with a small 2 HP or 5 HP motor.
What does the orange light on a golf cart mean?
This light notifies you when your golf cart battery or batteries are low on charge....Club Car Battery Charger Light Codes.Indicator SymbolMeaningAn orange bar with a numeral value insideA charge alert is detected for the car.6 more rows
Where is the reset button on an electric Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
What would cause an electric golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How do I reset my electric club car?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Why is my golf cart not firing?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Do electric golf carts have fuses?
Yes, golf carts contain fuses just like those found in a car or truck.
How do you test a 48 volt Club Car controller?
To test a club car precedent controller, connect a voltmeter between the negative terminal of your cart's battery and the M terminal on the controller. Then push the pedal down and look for a clicking noise from the solenoid. Your batteries should read as full.
How do you test a club car 48v motor?
13:2337:53Club Car 48 Volt Powerdrive Testing 1995-2013 - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition place the red positive probe on the speed controller M minus terminal place the blackMorePosition place the red positive probe on the speed controller M minus terminal place the black negative probe on the s2 motor terminal your vom should display continuity.
How do you test an electric golf cart controller?
0:002:11How to bench check curtis controller and golf cart motor - YouTubeYouTubeStart of suggested clipEnd of suggested clipOkay guys i'm going to show you right quick how to easily bench check your club. Car actually anyMoreOkay guys i'm going to show you right quick how to easily bench check your club. Car actually any golf cart. That's got one of these curtis controllers in it you just simply want to take that
How do you reset the motor on a Club Car DS?
Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected. Once you've pressed the button to reset the motor, reassemble the cart, charge up the batteries, and give it a test run.
Where is the fuse box on a club cart?
Locate the service panel of the golf cart. This is usually found behind the battery on the driver's side on the rear fender. Make a note of the current ratings supported for each fuse at the highest voltage.
Why will my Club Car golf cart not charge?
The cause of a Club Car golf not charging is either a dead battery, a damaged power cable, or a faulty charger.
How do you reset a golf cart battery meter?
Battery Meter Always Shows Full Reset the battery meter. Unhook power to the battery meter for 10 minutes. This will reset the battery meter.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
What is a speed controller?
Speed Controller. The speed controller manages the speed of the golf cart. There are some situations when the speed controller fails, but the cart will still start and move ahead. But, as it runs for a while, it will start malfunctioning.
How does a potentiometer work?
The potentiometer works as a communicator and tells the speed controller how much voltage it has to consume. The more voltage means the more speed and vice versa (Check out our resource on golf cart speed ).
Club Car Precedent 48v Intermittent Problem Question
I have a 2012 Club Car Precedent 48v electric cart that will suddenly stop working. It has brand new batteries, and seems fine, but randomly will not move when pushing the pedal. It will lurch forward then stop again, or it may work normal after changing the f/r switch, key switch, or even the run/tow switch.
Answer
It sounds like you are dealing with what we classify an intermittent problem. So, first things first, we need to reproduce the problem. Most likely, you are dealing with a connectivity issue. Essentially, what you are describing is a power outage to the system. The clicking noise you are hearing is the solenoid disengaging due to lack of power.
Where is the Delphi fuse holder on a 2010 Club Car?
For this, the first place you must check is the main fuse. In the 2010 Club Car Precedent, the Delphi fuse holder is located near the solenoid. There are standard operating procedures to be followed while working on your golf cart. The Run/Tow switch must be on Tow and preferably you should disconnect the batteries.
How many batteries are in a golf cart?
Batteries: Some golf cart batteries are designed and structured in such a way that in a pack containing six batteries, #1, #2 and #3 will service the forward movement of the cart and #4, #5, #6 take over when the cart is reversed. So, if one of the batteries were to fail then the movement in that direction will be curtailed.
How to know if a cart won't move?
When the cart won’t move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How to check if a controller is corroded?
To check the controller, these are the steps: You will need a digital voltmeter (DVM) to check the 16-pin connector at the controller. Lift one wheel of the cart on a jack. The black probe from the DVM should be on the pack negative post.
Why won't my golf cart move?
A Club Car golf cart will not move if power from the battery pack is not reaching the motor. Faulty parts such as the solenoid, OBC and wiring can also cause a golf cart to not move.
What to do if you don't get readings on golf cart?
If you are not getting these readings, change your batteries. You must keep in mind that there are differences between the various models of golf carts. Each model may have a different component and you have to be careful while handling them. Wrong handling can cause problems and the golf cart can get damaged.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
What is a club car controller?
The Club Car controller is also known as a speed controller, and the best thing about the controller is that it works as a brain and speed control system for the golf cart.
Why is a golf cart controller important?
From being able to change your golf cart's speed to manage all the electrical components perfectly, the controller is an important element of your cart. You could say the controller is the heart of your cart. A properly selected and maintained controller will allow the vehicle to operate smoothly and safely. Learn more about your Club Car speed ...
Why won't my golf cart run?
If your controller is damaged, your cart won't run. However, a few other reasons could lead your vehicle to stop running. Since the speed controller is the heart of your electric golf cart, you need to make sure that the problem is not something else first. Following is a list of things to check before you troubleshoot the speed controller.
What to do if your golf cart doesn't start?
If the cart doesn't start, check the solenoid. If the solenoid is working fine and allowing power to flow, then you can begin inspecting the controller. Learn more about symptoms of a bad golf cart solenoid. If all the components are working well, the next step is to check the speed controller.
How to start a golf cart when it's dead?
Start with batteries and make sure they are working properly. If your batteries are dead, your golf cart will not start. Charge your batteries completely, and then try to drive the cart.
What is the function of a speed controller on a golf cart?
Following are some of the primary functions of the speed controller: Limiting Motor Current – Protects the motor and controller from damage in case of stalling and overloading. Limiting Battery Current – Managing current drawn from the battery ...
What is a programmable controller?
Programmable Controller. The programmable controller can easily be configured for the needs of your cart. This controller's most significant and important advantage is that programmable controllers produce 60% less heat than other controllers.