Low battery voltage: Sometimes lack of proper battery voltage may cause the golf cart to keep beeping. It also may start beeping more when the accelerator is pressed more often. Check the battery voltage using the volt meter to be absolutely sure that the batteries are in running condition.
Why is my golf cart beeping when I press the accelerator?
Check Golf Cart gears and bearings: Check if the beeping sound increases when accelerator is pressed and goes off when the foot is released from the accelerator. Try to inspect the motor to determine the source of the sound (which part of the motor is causing the noise).
What happens when the gas pedal fails on a golf cart?
When this unit has failed, the golf cart will start up and possibly take off, without hesitation. And as you travel, no matter how firmly you press on the gas pedal, the cart will not accelerate - even if it does momentarily, you won't be able to maintain that level of acceleration.
Why won’t my golf cart accelerate?
The main reason why a golf cart won’t accelerate is because of bad solenoid, weak battery or faulty speed controller.
Why club car DS won’t accelerate?
Why Club Car DS won’t accelerate? When your Club Car DS does not accelerate, it could mean that there is a problem with the spark plug. Get the spark plug removed and check it thoroughly. If it is oily or emits a foul smell, you need to clean it thoroughly or, if possible, get it replaced.
Why does my golf cart keep beeping?
Golf Cart Making Beeping Noise The beeping noise in the golf cart is because the battery is not fully charged, low battery voltage, or because the rear end fluid needs changing. The beeping noise may come during a regular drive, but most people hear it when the cart is being reversed.
What causes a golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Where is the reset button on a Club Car golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How do I reset my Club Car Precedent?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
Where is the speed sensor located on a Club Car golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do I know if my Club Car controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Do all golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
How do you know if your Club Car motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you troubleshoot an electric club car?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do I test my club car precedent controller?
To test a club car precedent controller, connect a voltmeter between the negative terminal of your cart's battery and the M terminal on the controller. Then push the pedal down and look for a clicking noise from the solenoid. Your batteries should read as full.
Where are the fuses in a Club Car golf cart?
Club Car Golf Cart Fuse Box Location The fuse box in a 1997 Club Car can be found in the black electrical component box that is near the battery. In a 2004 Club Car Precedent, the fuses are located in two black plastic fuse holders that come with a molded support hole extension.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What is a speed controller?
Speed Controller. The speed controller manages the speed of the golf cart. There are some situations when the speed controller fails, but the cart will still start and move ahead. But, as it runs for a while, it will start malfunctioning.
How does a potentiometer work?
The potentiometer works as a communicator and tells the speed controller how much voltage it has to consume. The more voltage means the more speed and vice versa (Check out our resource on golf cart speed ).
Club Car Precedent 48v Intermittent Problem Question
I have a 2012 Club Car Precedent 48v electric cart that will suddenly stop working. It has brand new batteries, and seems fine, but randomly will not move when pushing the pedal. It will lurch forward then stop again, or it may work normal after changing the f/r switch, key switch, or even the run/tow switch.
Answer
It sounds like you are dealing with what we classify an intermittent problem. So, first things first, we need to reproduce the problem. Most likely, you are dealing with a connectivity issue. Essentially, what you are describing is a power outage to the system. The clicking noise you are hearing is the solenoid disengaging due to lack of power.
How to fix a golf cart that won't accelerate?
The best way to fix a golf that won’t accelerate is to readjust the battery cable, check all connections and replace the solenoid. When your golf cart does not accelerate, the one thing you need to keep in mind is that while it is an automobile, it is not a regular vehicle like your car.
How does a speed controller work on a golf cart?
Once you do this, the brake should release and the cart will start accelerating once again. The speed controller works towards regulating the speed of the golf cart. There are instances when the speed controller fails but the vehicle will still start and move ahead.
Why is my golf cart not moving?
The golf cart will not be able to move at a steady or constant speed and that is one of the first warning signs of a problem with the speed controller of the vehicle. Here are a few things you can do to fix the issues associated with your speed controller.
What happens if oxygen sensor is damaged on Yamaha G29?
Therefore, if the oxygen sensor is damaged, the engine of the Yamaha G29 golf cart will be oblivious to any information about the air-fuel mixture. This will, invariably, cause acceleration problems.
Why is my golf cart solenoid not working?
If you encounter a problem with the solenoid of your golf cart, then you must know that it could be because of a faulty speed controller. To check the condition of your vehicle’s solenoid, you will be required to take a reading of the voltage and check if it is the same as the reading from the battery.
Why won't my golf cart work?
The golf cart will not function if the transfer of electric current is disrupted. Current gets disrupted when the solenoid gets worn out or damaged. When you press the pedal, the solenoid gets activated and compounded into a metallic contact plate.
What is the function of a golf cart solenoid?
Its main function is to enable the flow of electricity from the battery into the motor. When you press the gas pedal and hear a sound that resembles a tap, you must know that the solenoid has been activated. The golf cart will not function if the transfer of electric current is disrupted.
Why do electric golf carts fail?
These carts can start to show signs of wear and may fail just like any other vehicle over time.
What are the problems with electric golf carts?
These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts. 1. Solenoid Wear. The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. ...
What is the controller on a golf cart?
An electric golf carts' controller is known as the heart of the operation and closely resembles and operates much like the motherboard in a computer. So a problem with the controller will have rippling effects throughout the cart. A common function of the speed controller is to control the speed of the golf cart.
Why does my gas cart not work?
When you press down on the gas pedal and hear a tapping-like sound, this is the sound of the solenoid activating. When there is a disruption in the flow of the electrical current , your cart will not operate. A common reason for current disruption is solenoid wear.
What happens if your cart doesn't move?
If the cart doesn't move in either direction, both switches have failed. Diagnosing a problem with the direction switches isn't a complicated matter, but repairing the switch is more complex, especially if the switches are built into the speed controller.
Why won't my sped controller accelerate?
Problems with the sped controller occur for a variety of reasons, but most often the cause is degradation due to age or lack of use.
How does a solenoid work?
Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate. Over time, the force of this pressure creates tiny electric arcs on the plates' surface. These arcs eventually create a resistance that prevents the current from properly flowing.
Why is my golf cart not clicking?
On an electric golf cart, the most common symptom is the solenoid is not delivering electricity to the controller when the vehicle’s ignition is turned on. In normal operating conditions, the solenoid clicks on and off with the ignition switch. A failing solenoid will generally not click. Two things could be going on here.
How to check if a golf cart solenoid is silent?
On an electric golf cart, if the solenoid is silent – no clicking – use the setting voltmeter to DC volts using the 200 range. First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn’t move, then the problem is not with the solenoid.
What does it mean when a golf cart solenoid goes bad?
Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...
Why do golf carts have solenoid?
The solenoid is simply there to allow electricity to flow freely to the controller and motor which will result in a running golf cart. RELATED: 4 Signs you need to Replace your Golf Cart Batteries.
Why won't my solenoid click?
The solenoid might not be getting enough electricity to do its work – which could be caused by loose connections, a weak battery or the coil wearing out.
What does a solenoid do when you turn the ignition?
Step by step, it looks like this: When you turn the ignition key, a small amount of electricity goes to the solenoid. The solenoid uses that small amount of juice to close two heavy-duty contacts that allows a large jolt of electricity to pass through the starter. The solenoid also sends a pinion gear forward, which is the device ...