Golf-FAQ.com

does yamaha golf cart battery charge tell when batteries are charged

by Dorothea Simonis III Published 2 years ago Updated 2 years ago

Jot down or remember whatever number you get. 36 volt golf carts when fully charge will reflect 37-38 volts… and 48 volt systems will reflect roughly 49-51 volts. All batteries hold slightly more voltage than advertised on case when fully charged so when combined the numbers are always slightly higher. So no need to be alarmed.

Full Answer

Can You charge a golf cart battery with a car charger?

Even if you are able to drive your golf cart and even if you just got brand new batteries, we'd suggest getting a 6V OR 12V CAR BATTERY CHARGER AND MANUALLY CHARGING UP THE GOLF CART BATTERIES FOR A COUPLE MINUTES EACH. This process should give the batteries enough voltage so that your golf cart battery charger can then take over.

Why is my Yamaha golf cart not charging?

The most likely reasons why a Yamaha golf cart is not charging are: The battery charger is damaged

What voltage do I need to charge my Yamaha golf cart?

A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully.

How do I know if my golf cart battery charger is bad?

This is usually the first step we perform in the shop to determine possible golf cart battery charger issues. With a basic digital volt meter we check system voltage first. Whatever the operating voltage is of your golf cart you should check current voltage levels to know if the cart is in fact fully charged, partially charged or completed dead.

How do you know when golf cart batteries are fully charged?

1:574:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipMost will flash or blink during charging and present a solid green light when finished.MoreMost will flash or blink during charging and present a solid green light when finished.

Should you be able to hear golf cart batteries charging?

The bubbling or gurgling sound is entirely normal during the charging process, especially when the battery is new because it is essential for the golf cart batteries to solidify the new lead within the batteries, commonly called curing the lead.

What does the red light mean on a Yamaha golf cart?

The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart.

What do the lights on a golf cart battery charger mean?

• The light begins flashing when the battery state of charge falls below 10%. Charging Confirmation. • The light will flash three times and the reverse buzzer simultaneously will sound three times to. indicate a battery charging session has begun.

How do I make sure my golf cart is charging?

6:037:14How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo charge each individual battery for a half-hour. And then plug. In your old charger your regularMoreSo charge each individual battery for a half-hour. And then plug. In your old charger your regular golf car charger. And if it clicks on and starts to register voltage.

Should a battery make noise when charging?

This is a vibration noise which occurs when electric current flows through a transformer or a winding wire inside a component part. However, the charger may still be used without any concern as there is no need to worry from a safety point of view.

Do batteries sizzle when charging?

When charging amperage exceeds the level of the natural absorption rate, the battery may overheat, causing the electrolyte solution to bubble creating flammable hydrogen gas. Hydrogen gas, when combined with oxygen from the air, is highly explosive and can easily be ignited by a spark. Yes.

Why is my golf cart battery charger blinking red?

Two Red Flashes = Battery Voltage Fault. This results from too much voltage or not enough. If the golf cart's battery bank is less than 36.0 volts or more than 67.2 volts you may get this fault.

How do I know if my battery charger is working?

Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...

What does a blue light mean when charging?

Blue light means its charged and can charge your devices.

What does a green light mean on a battery charger?

When the charger is plugged into the vehicle and into the wall the red light indicates that the battery pack is charging, and the green light indicates that the charger is plugged into the wall.

How do you charge a Yamaha golf cart battery?

1:382:05Yamaha Golf Car- Consumer - Charging Batteries - YouTubeYouTubeStart of suggested clipEnd of suggested clipPosition lift the seat and move the toe run switch to the toe. Position with the charger properlyMorePosition lift the seat and move the toe run switch to the toe. Position with the charger properly connected and grounded insert the charger plug into the golf car receptacle.

Can you overcharge golf cart batteries?

Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Some older models lack this important feature. If you must use a manual charger, don't forget to turn it off.

How long does it take a golf cart to charge?

Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.

Find A New Golf Cart Battery Charger Or Batteries

1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...

Troubleshoot An Old Golf Cart Battery Charger & Batteries

1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...

Golf Cart Charger Questions

1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...

Golf Cart Battery Questions

1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...

Why is my golf cart battery charger not working?

Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.

How many volts does a golf cart battery need?

An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.

What is an OBC on a club car?

When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.

What voltage do you need for a 36V golf cart?

You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.

Why is my golf cart charging red?

Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).

Why is my charger making a clicking noise?

If the charger makes a loud clicking noise, this is likely a battery charger issue.

How to keep a charger from getting hot?

But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight.

How many volts does a Yamaha golf cart need to charge?

A minimum of 25-30 volts is required to wake up the charger and for it to begin charging your Yamaha Golf Cart. A failure in the “brain” of the charger can also cause the charger to take very long to start charging or to recharge fully. This can be solved by an easy replacement and doesn’t even require many bucks.

Why won't my golf cart charge?

Another reason your golf cart won’t charge could be because nothing would happen even after you plug in the charger. The most likely cause behind this problem is the connection problem with batteries. You can confirm and test this problem using a voltmeter.

What does the red light on my charger mean?

The error lights are the second and third light indicators. If the error light is flashing red, try reconnecting the charger and then charging the battery again. The first light indicates power. It will turn on when the charger gets plugged into the AC power. Check the voltage of your batteries.

How to remove corrosion from battery terminals?

These are the steps that you can follow to remove corrosion from the battery terminals: Disconnect the cables. Corrosion is easy to detect. A peeled, dried, brownish terminal end means that there is corrosion on the battery.

Why does my battery not charge after turning on?

At times, even after turning on the charger, nothing happens. This happens if the battery is not recharged for a long time. That’s because the charge that is currently present in the battery is too low for the charger to detect. A minimum of 25 volts must be provided to the charger to start charging.

Why is my Yamaha G1 not charging?

Yamaha g1 Golf Cart not charging. Often, the G1 golf cart doesn’t charge because of a bad receptacle. Make sure that the receptacles fit tightly and are clean. If not, then you can get the receptacles cleaned and tightened. Check the plastic coverings on the prongs. A broken cover can also build problems.

Can you fix a golf cart on your own?

Under NO circumstances should you attempt to fix your golf cart on your own. Doing so is dangerous and could result in serious bodily harm. The information on this website has not been verified for accuracy and should only be used for general information purposes only. Use this information at your own risk.

How to choose a golf cart battery charger?

How to Choose the Best golf Cart Battery Charger. You must choose a battery charger according to the voltage of your cart to prevent the possibility of damage to your batteries. Check the charging receptacle of your golf cart and select your charger accordingly.

How to charge a deep cycle golf cart battery?

The following tips give an insight into the effective charging of a deep-cycle battery. Charge the deep-cycle battery fully between two consecutive uses of the golf cart. The battery must complete at least one full cycle before use. Check the water level periodically.

How many volts should a wet cell battery be charged to?

A typical wet-cell lead-acid battery should be charged to about 14+ volts. Some manufacturers allow their batteries to support a maximum charging voltage of 14.3 volts. A sealed battery like a gel battery must generally not be charged beyond 14.1 volts. You may want to check whether the manufacturer offers a variation.

How many volts does a golf cart charger have?

There are about 8 different types of charger plugs that you can find across various golf cart models. While some of plugs are exclusively for either 36 volts or 48 volts carts, others will work with both voltages.

What is the power of a golf cart generator?

The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart. The 48 volts system in a golf cart usually features an onboard computer (OBC) that controls the battery pack charging process and restricts the charging when the cart is moving.

Why does my golf cart go into tow mode?

Your golf cart usually runs in tow mode when it does not have enough power to get moving on its own. One reason may be that the batteries are old and do not have the same power as new ones. If this happens with new batteries, the most likely reason is that they don’t have enough charge.

How long does it take for a 5 year old battery to charge?

On the other hand, a 5 year old battery may take up to 10 hours to fully charge. With a good charger, you should be able to get your cart on the move with a few hours of charging. The charging time depends on various factors and following the right steps can help you get the best out of your battery.

How does a Lester golf cart battery charger work?

The Lester Electric Golf Cart Battery Charger you purchased is a transformer style charger that is designed to apply amperage and voltage for a length of time that replaces the energy used from last discharge. This is fairly old technology but very effective to charge your golf cart batteries. Depending on the battery chargers output (Amperage), the batteries size (Capacity), and DOD (depth of discharge), all this will determine the amount of time required to fully charge the battery bank in question. In the process as they reach maximum capacity the more electricity that is forced into the batteries the more it excites the electrolyte and gets electrons moving in the battery itself… (That is the boiling sound you hear)

Why are AGM batteries so picky?

AGM and Gel style batteries are even more picky than traditional lead acid batteries because they like more voltage and amperage to complete the same process. Hopefully this was helpful and insightful to ease your worries about your golf cart batteries and the golf cart battery charger.

Why do lead acid batteries make noise?

Make no mistake lead acid batteries will always make noise in the charge process and finishing phase because of the specific chemistry and design that make a lead acid battery. It is also an important part to insure good battery health as well.

How often should you charge golf cart batteries?

Golf cart batteries should be kept fully charged at all times – this means hooking them up to a charger as soon as you are finished using the cart. Regular charging will prevent damage to the battery and give it longer-lasting life.

Should golf cart batteries be charged after every use?

Yes. Charging your golf cart batteries after every use – even if you’ve only spent five minutes driving – is crucial for maximising their lifespan. Leaving batteries in a prolonged state of low charge can decrease their capacity over time and wear them out quicker.

Should you charge new golf cart batteries?

Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.

Should your golf cart be turned on when charging?

No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you’re trying to charge it. A golf cart should only be turned on once its batteries are fully charged.

Should golf carts be plugged in all the time?

No, you should not leave your golf cart plugged in all the time. While automatic battery chargers are designed to shut-off once at full capacity, leaving a battery connected to power for long periods leaves it susceptible to damage should the electrical circuit be overloaded.

Should golf cart batteries make noise when charging?

If your golf cart uses a standard 12 volt flooded lead acid battery, then it is quite normal to hear a bubbling sound when it’s charging. However, if your cart uses a sealed battery (such as a gel or AGM battery), then a hissing or bubbling sound may indicate damage.

How long should golf cart batteries last?

If you play golf twice a week – and use your golf cart for each round – you can expect a standard, brand-new battery to last just under 10 years before needing to be replaced. If you charge your battery correctly after use, you can maximise its shelf life.

What voltage do golf cart batteries work on?

All golf cart battery chargers usually operate on 110VAC but some have the ability to operate on multiple voltages for other power grids like in Europe vs US. 110/230VAC would reflect this feature on charger. Good DC side connection. This is the wire or cord with a connector that you would plug into the golf cart.

What happens if my golf cart is not charging?

If you do not have any voltage in the batteries you will need to get some back into the battery bank before the golf cart charger will charge again .

What is the third pin on a golf cart?

Then the third pin is usually a low voltage signal for a lock-out feature on these newer style golf carts. This is so the user cannot drive off with a golf cart “If the charger is still plugged in”.

Where to find battery in golf cart?

You will usually find the batteries to your golf cart under the front seat which opens or folds out towards the golf cart steering wheel on most Club Cars, Ezgo and Yamaha golf carts. Look for the two terminals with the most wires going to them. Usually this is the positive and negative most terminals in the battery bank.

Do golf cart batteries work the same?

Wiring batteries in a series style circuit is quite simple and always the same. No mater how many golf cart batteries you have it will always work the same.

How to tell 12 volt golf cart battery?

A 12 volt battery can be identified by seeing batteries with 6 cell caps on top of the battery indicating 2 volts per cell. A single 12 volt golf cart battery will have the least amperage capacity and is commonly used in 72 volt battery systems which are not terribly common among golf carts. EZGO golf cart batteries are known to be use 4-12 volt battery systems in some of their golf cart models.

How to tell if a golf cart battery is 6 volts?

A 6 volt golf cart battery can be identified by seeing batteries with 3 cell caps on top of the battery indicating 2 volts per cell. Generally speaking, a single 6 volt battery will have the highest amperage capacity and will allow for the greatest range in an 8-6 volt battery system.

How does amperage affect golf carts?

It will determine how far you can travel on a single charge in an electric golf cart. The more amperage in a battery pack, the further you can drive before having to charge.

What to do when buying an electric golf cart?

If you are in the market to purchase an electric golf cart, then the simplest thing to do first and foremost is considering the age of your golf cart batteries. This is important due to many consumers being misled as to the age of the batteries in the cart they are purchasing. At times, a consumer will be told by a private party or dealer ...

How many cycles does a lithium battery last?

Also, some lithium batteries carry a lifetime warranty and can deliver up to 5000 cycles versus the typical 100-500 cycles for a lead acid battery. Even with a 500-cycle lead acid battery cart, that means replacing the power source 10 times more than the lithium-ion model.

What kind of batteries are used in golf carts?

While the aim of this article is to discuss primarily deep cycle batteries used in golf carts, some people are interested about learning the other types of batteries being used in Golf Cars. We have an article for you that discusses differing battery types in detail specifically for you.

How much does a lithium battery weigh?

A lead acid battery can weigh as much as 130 pounds and averages around 65 pounds. A lithium-ion battery averages 28 pounds. Less weight means your cart will be able to haul more weight at a greater speed. And, they are capable of holding a single full charge for a year instead of losing a charge slowly over time.

A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9