
The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch. Causes of jerky Electric golf carts: 1] Water-logging in some of the components of your electric golf cart can result in jerking.
Why does my golf cart Jerk when accelerating?
The most likely reason for an electric golf cart jerking is usually battery-related. However, while this is a common reason, there are other causes like bad tires, suspension issues, clutch problems, front-end problems, poor beads, etc…. There should be no bouncing, jerking, or wobbling in a high-quality golf cart.
How do I Stop my club car from jerking?
Feb 22, 2022 · Why Does My Golf Cart Jerk When I Accelerate? In most cases, batteries are to blame for this problem. It is possible for a cart to jerk as it accelerate if the battery isn’t in full charge or is distributing power incorrectly. MCOR clutch-cleaning and other routine processes can cause your cart to become even more jerky by messing up.
How much does an electric golf cart cost?
May 23, 2019 · May 23, 2019. #10. Remove the rotator and use a fine grit sandpaper and sand contacts on stationary board and rotator until the surfaces are clean and flat and reassemble. Might want to check the four terminals on the back of stationary board and make sure they aren't burnt and check and make sure they are tight. B.
What happens when you push the pedal on a golf cart?

Why does my electric golf cart hesitate when I accelerate?
Loose Connection Inspect the wires carefully and make sure all of them are correctly connected. Sometimes loose wiring can cause the speed controller to malfunction. You need to make sure that all the wires are plugged in tightly. Along with this, you also need to inspect the condition of the wires.May 10, 2021
How do I know if my golf cart controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
How can I make my club car go smoother?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.May 18, 2021
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.May 14, 2021
What happens when golf cart solenoid goes bad?
How Often Does A Golf Cart Solenoid Go Bad? Your solenoid is prone to overheating as a result of its regular use. As a result, you may notice irregular operation after a while — it may work one time, but not the next. Loose cables or dusty interiors could cause your cart's inability to start.
Why Does My Club Car golf cart jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
How much does an MCOR cost?
$42.99 & FREE Shipping.
How do you test for MCOR?
To test the MCOR, look for the line item that says THROTLE. With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner. If you see it jump around (ie.
How can I make my golf cart gas faster?
Increase the RPM An increase in the input shaft rpm for all differential ratios will produce a higher speed. For a gas golf cart, other than adjusting the governor, the speed may be enhanced by replacing the engine with a higher rpm output model.Apr 3, 2018
How do you make a club car gas golf cart go faster?
0:061:31Club Car Precedent Speed Increase SUPER EASY!!! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt slows it down. And if you turn it that way or clockwise it speeds things up. Very. Very simpleMoreIt slows it down. And if you turn it that way or clockwise it speeds things up. Very. Very simple loosen that bolt. Turn the pin one way or the other to make it faster or slower.
How do you remove the speed limiter on a electric golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt looks up look inside. There's 12 cable down right here this lever you want to lift up and BendMoreIt looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
What to do if golf cart has multiple limit?
If the golf cart is a speed switch/multiple limit style, check for proper engaging action of the wiper arm and contacts and take the necessary action for this to happen if they don’t.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Why won't my golf cart accelerate?
If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What is a speed controller?
Speed Controller. The speed controller manages the speed of the golf cart. There are some situations when the speed controller fails, but the cart will still start and move ahead. But, as it runs for a while, it will start malfunctioning.
How does a potentiometer work?
The potentiometer works as a communicator and tells the speed controller how much voltage it has to consume. The more voltage means the more speed and vice versa (Check out our resource on golf cart speed ).
