EZGO RXV Solenoid Clicking but Won’t Move You can check the red wire that runs from the solenoid to the accelerator. It may lack continuity and fixing it will make the cart run smoothly.
Full Answer
Why is my EZGO golf cart clicks but won’t move?
Why an EZGO Clicks but Won’t Move? A EZGO golf cart can click but not move due to a faulty solenoid, or damage to the wires connecting the ITS coil to the controller. EZGO golf cart owners often assume that the batteries on their carts are fine and look for other reasons when faced with issues.
Are your EZGO golf cart batteries bad?
EZGO golf cart owners often assume that the batteries on their carts are fine and look for other reasons when faced with issues. The problem of the cart’s solenoid clicking but the cart not moving is reported by many.
What to do if your EZGO RXV won’t move?
Replacing the brake will be the solution; try it. Replacing the RCM unit has produced the desired results in 2010 EZGO RXV golf carts which had the same ‘clicks but won’t move’ problem. A bad drive motor could also be causing trouble. To find this out, you have to check the battery pack voltage.
What are the different types of speed controllers on EZGO golf carts?
The EZGO golf cart retains two different types of speed controllers: the Drive Control System (generally found on older models prior to 1994) and the Precision Drive System (PDS).
Where is the reset button on a ezgo golf cart motor?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How do I know if my ezgo controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
How do I test my EZ Go golf cart Ignitor?
Take the voltmeter's black and red probe and place it on the –ve and +ve terminal of the coil. Take the readings. It should be between 3.7-5.2 ohms. If outside the range, the coil should be replaced.
What would cause an electric golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do you troubleshoot an electric EZ Go golf cart?
Things to Keep in Mind Before TroubleshootingEZGO golf cart batteries aren't perfect right away.Sticky accelerators are perfectly normal and can be fixed easily.Keep your cart stable.Make sure your charging wall socket isn't faulty.Keep your tire pressure stable.Troubleshooting the speed controller.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
What does the igniter do on an ezgo golf cart?
This part is designed to help produce the proper electrical signal to get your cart's engine running and to keep it properly moving without any issue. In essence, the ignitor works to enhance electrical signals and produce a larger flow of electricity to the coil that helps your spark plug operate.
Why is my golf cart not firing?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
What does the ignitor do on a golf cart?
The ignitor boosts the signal and sends it to the ignition coil. The coil then creates the large spark that goes to the spark plug and fires the gas mixture in the cylinder. Ignitors can be the cause of a weak spark or they may fail completely and then the coil cannot create any spark at all.
Why does my EZGO golf cart not move?
The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward.
Why won't my EZGO golf cart go forward or reverse?
For example, if your run/tow switch has malfunctioned, your cart won't go forward or backward. This switch is designed to change your cart's operating mode from normal operation to increased power for towing. Check the switch to make sure that it isn't “stuck” between the two modes.
How do I know if my electric golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Do E-Z-Go Golf Carts have titles?
E-Z-Go Golf Carts, unlike vehicles, do not have a title, but they do have serial numbers. If you are buying a golf cart, it is essential to check the serial number to ensure you do not buy a stolen one. Each E-Z-Go Golf cart has a unique serial number that you can use to identify your golf cart.
Where is the E-Z-Go Cart Serial Number
As mentioned above, all E-Z-Go Golf carts have unique serial numbers. These numbers are essential when buying replacement parts for your golf cart. Textron Specialized Vehicles has been building golf carts for a long time, and the serial numbers are placed on different parts of the golf carts.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
Why does my E-Z-Go golf cart not move
There are several reasons why your cart refuses to move, but you should check the battery before anything else. If the battery is charged, here are some other reasons why your golf cart will not move.
Are all E-Z-Go Golf carts electric?
No, there are both electric and gas-powered E-Z-Go Golf carts available. Bear in mind that there are several models you can drive on the street, but those are all-electric. These electric models run on batteries that you have to charge at least every 24 hours, depending on how much you use them.
How to tell the Assembly year of my E-Z-Go golf cart
The placement of serial numbers is discussed above, and you will find the manufacturer’s number right next to it. The manufacturer’s number consists of one letter and 3 or 4 numbers. The last two numbers indicate the last two digits of the year of assembly.
How to service E-Z-Go Golf Cart
Like all vehicles, E-Z-Go golf carts require regular maintenance to enhance longevity and performance. You should ensure that your golf cart is serviced after every six months of use. That will ensure that you spot problems and repair them early, which will help reduce repair costs. Here are essential guidelines for E-Z-Go golf cart maintenance.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
What does the Ezgo manual say about battery replacement?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.”. This means that every manufacturer retains its own unique requirements, specs, and timelines.
Why is it important to keep a golf cart in good shape?
Therefore, it is very important to keep your golf cart in great shape at all times, and learning how to troubleshoot can mean the difference between diagnosing and quickly fixing problems, or having your cart break down.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
What is the recommended tire pressure for an EZGO cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI. Be sure to inspect your tires regularly, too, and replace them as necessary. If your cart is driving slower than usual or making strange noises “down there,” it could very well just be a sign of low tire pressure.
Why is my golf cart foot pedal so smooth?
If you are having issues with the smoothness of your foot pedal, it may simply be due to the air quality of your surroundings and should eventually fix itself. If your golf cart is a few months or years old, the stickiness may be due to constant pressure.
What happens if the voltage is not equal to the voltage on a solenoid?
If it is not equal, then the solenoid has a wiring problem. oYou should also put the positive probe on the opposite post of the solenoid and read the voltage there. The voltage should have three or more volts below the battery’s own reading. If not, then you should get the resistor replaced as soon as possible.
How to check if a 1996 Ezgo golf cart has batteries?
Here’s a recap of how to check if the batteries in your 1996 EZGO RXV golf cart are in proper shape or not. Use a good quality DVM. Tape the meter to the pack mains. Check the voltage when the cart is idle.
Why is my cart left in the off position?
Some cart owners may fix a hidden switch that is left in the OFF position to prevent thefts. Check if your cart has one. Check all the connections to confirm that there are no loose wires or if some cable is hot and not functioning as it should be. Sometimes these actions are enough to solve the issue.
What to do if your RXV cart starts moving?
Try to move the cart; if it starts moving, then you should change the emergency/parking brake. The reason for this is that the RXV model is designed with this feature that if the brake fails, the cart will not run. You may be misled into thinking that the motor is faulty, but it could be wrong.
How many volts does a 6V cart battery have?
Equally critical is to check that the individual batteries of 6V show at least 6.37 volts, when fully charged. If you are satisfied that your cart batteries show these voltages, then you can move on to the other possible reasons for the cart not moving.
Can you handle a golf cart?
Many users of the latest model golf carts don’t realize that these are more computer-controlled and highly sensitive. You cannot handle them as you would the older models of carts. There are occasions when users have ended up burning out the whole system without knowing what they have done.