An EZGO RXV golf cart won't charge because of a dead battery, low battery pack voltage, a non-charging charger or a faulty battery cable. Measure the positive and negative voltages of the battery pack using a multimeter. Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart.
Full Answer
Why is my EZGO golf cart not charging?
Why is my EZGO golf cart not charging? Your EZGO golf cart may not be charging due to problems with batteries or the charger. It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries.
How do you reset an E-Z-GO golf cart?
To reset your E-Z-Go cart, press the red button. Ensure that you recharge the cart before switching it on again. How do you test an E-Z-Go Golf Cart Controller? Depending on the E-Z-Go Golf cart you own, there are two types of controllers, the Drive control systems and the Precision Drive System.
What is the forward/reverse switch on an EZGO golf cart?
The Forward/Reverse switch carries the brunt of transmitting power from the battery to the motor. Over time it can become worn out and its contacts can burn. If this is the case you’ll need to have a certified technician to replace it with a new one that is made specifically for the EZGO TXT Golf Cart.
Do EZ GO golf carts have titles?
E-Z-Go Golf Carts, unlike vehicles, do not have a title, but they do have serial numbers. If you are buying a golf cart, it is essential to check the serial number to ensure you do not buy a stolen one. Each E-Z-Go Golf cart has a unique serial number that you can use to identify your golf cart.
Why is my ezgo charger not working?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it's free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
When I plug in my golf cart charger nothing happens?
Check Your Connections Make sure you check each battery terminal for corrosion; any buildup will impede the flow of electricity, and could likewise cause problems. Generally, if you plug in your charger, and nothing happens, this is most likely a problem with your batteries or connections.
How do you tell if EZ GO charger is bad?
Use your voltmeter to test the positive end of the charger handle. Press the other end to the negative line coming in (near the fuse). This is just one last check to be sure, since often the handle of the E-Z-Go Powerwise Charger is where people tend to have issues.
How do you troubleshoot a golf cart charger?
1:103:54Golf Cart Charger Troubleshooting Guide | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipTest good first off the most common issue when a charger doesn't engage is dead batteries golf cartMoreTest good first off the most common issue when a charger doesn't engage is dead batteries golf cart chargers start automatically by receiving voltage from your cart.
How do you reset a golf cart charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do you check if a battery charger is working?
Running a test on your battery charger is an easy process.Plug in your charger to an electrical outlet. ... Turn on your voltmeter unit. ... Take a battery or battery pack that's compatible to your battery charger. ... Check the readout on the voltmeter and see where the pointer is indicating to.More items...
How do I know if my golf cart battery charger is working?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do you troubleshoot a battery charger?
5 Troubleshooting Tips for Your Car Battery ChargerCheck the outlets. There are three ways to determine if the outlets are causing problems to your jump starter. ... See if your battery is in good shape. ... Inspect the charger for signs of damage. ... Check for corrosion or rust. ... Clean your charger.
Is there a fuse in an electric golf cart?
Yes, golf carts contain fuses just like those found in a car or truck.
How does EZ GO battery charger work?
In the case of an E-Z-GO Powerwise charger, the logic board is actually powered by the DC voltage from the golf car. If there is no voltage in the batteries, the logic board does not even activate. In a normal situation, the logic board gets its current from the cart through the small red wire in the DC power cord.
Will a golf cart charger work if batteries are dead?
0:335:42How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipMysteries. No matter how the batteries ran low if your cart does not have enough power to driveMoreMysteries. No matter how the batteries ran low if your cart does not have enough power to drive forward it probably doesn't have enough voltage to activate a charger.
How do I know if my golf cart battery charger is working?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do you charge a completely dead golf cart?
3:335:42How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe recommend starting by charging each battery for 5 to 10 minutes at a time and then moving on toMoreWe recommend starting by charging each battery for 5 to 10 minutes at a time and then moving on to the next. One.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Where on the golf cart do I install a Lester on-board battery charger?
Some find that they can fit the on-board charger under the seat. This will really depend on the cart's specific battery configuration (x4 12V's, x6 6V's, x6 8V's or x8 6V's). Others will put the onboard charger on the little cubby area below the rear seat (if they have one). The Lester Summit onboard chargers that we sell have the following dimensions: L 10.95" x W 7.3" x H 4.75" and are pre-drilled mounting holes on the sides. Here are links to each: 48V Onboard Charger and 36V Onboard Charger.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
Should I charge the golf cart after each use?
Yes. It is healthy for the batteries to be fully charged at all times. So, you should charge your golf cart every night. Automatic golf cart chargers will shut off once the batteries are fully charged, so there isn't a concern that they will be over charged.
What is an EZ Go golf cart?
EZ-GO electric golf carts are among the most popular types of carts found on courses today. Their dependability and their virtual quiet, thanks to an electric motor, makes them friendly for those taking to the links. Because they are electric, one of the more common areas you may encounter problems is with the charging system. When the cart doesn't perform as specified, there are steps you can take to troubleshoot the charger.
Why is my cart not charging?
Because they are electric, one of the more common areas you may encounter problems is with the charging system. When the cart doesn't perform as specified, there are steps you can take to troubleshoot the charger. Plug the charger into a DC power source.
How to check if a charger is working?
Plug the charger into a DC power source. You should hear a clicking sound if the charger is working appropriately . If you don't hear a clicking sound, you'll need to check the fuses, which is explained in Step 3.
How to open a charger case?
Start with the handle screws and then do the front and back of the case. You can open the charger case by lifting up on the back of it and pulling it forward to release it. Use a voltage meter to check the fuses of the DC cord and make sure there is continuity in the circuit.
What to do if your charger doesn't click?
Disconnect the charger from both the AC and DC power sources if the charger doesn't click when plugged into the DC power source.
When to wear safety goggle on a cart?
Always wear safety goggle when performing maintenance on any part of the carts electrical system.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
Why is my E-Z-Go golf cart losing power?
E-Z-Go golf carts often lose power because of corrosion or loose cables. If the connecting wires in electrical circuits break, your battery will lose power. The same will happen if you have a short circuit in the ignition system. Here are steps you can use to ensure that the system is working correctly.
How do you test an E-Z-Go Golf Cart Controller?
Depending on the E-Z-Go Golf cart you own, there are two types of controllers, the Drive control systems and the Precision Drive System. Only E-Z-Go carts made before 1994 have a Drive Control System. If you notice that your E-Z-Go golf cart is not running at a constant speed, you should troubleshoot the controller to identify the problem. Here are the steps you should use to test your E-Z-Go golf cart controller.
Why does my E-Z-Go Golf Cart feel sluggish when accelerating?
The reason why your golf cart is sluggish during acceleration or stalls depends on whether it is a gas cart or an electric one. Here are the reasons for sluggishness in both.
Why won’t my gas golf cart charge the battery?
If you own a gas E-Z-Go golf cart, the battery may not get charged. Make sure that you have refueled your golf cart, and then check for the following issues.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my golf cart start?
If your golf cart does not start even though the starter is rotating, there could be a problem with your battery, solenoid, or starter. Check the ignition and make sure you make the necessary repairs and replacements.
Why Won’t My EZGO Golf Cart Start?
EZGO golf carts may not start due to a transmission problem, corroded battery terminals or a faulty wiring coming from the ignition.
Why won't my EZGO RXV move?
Brake Problems: Many times the reason your RXV won’t move is because of brake problems. The RXV is designed to be disabled when there is a problem with the break. Many times, the wiring that connects the brakes to the controller gets loose or is damaged. This can disable your EZGO RXV.
How to unclog a golf cart muffler?
To unclog it, simply make a fire and remove your muffler and put it there.
What to do if replacing ignition wire doesn't work?
To check the continuity of the ignition wire you’ll need to use an ohmmeter or a continuity tester. To do this, set the switch to off and set your ohmmeter to X1.
Why does my golf cart make a clicking noise?
When you press your golf cart pedal you should hear a clicking noise, if you don’t hear a clicking noise there might be a problem with the solenoid. To make sure your solenoid is functioning properly check it with a voltmeter. If you hear a click then you need to check its power with the voltmeter.
Why is my golf cart ignitor failing?
The most common reason for a failed ignitor is a bad voltage regulator. Therefore, when you replace or fix the ignitor on your golf cart, make sure you also check the voltage regulator and see if it needs to be replaced. There have also been cases where the battery has switch polarity for some reason.
What do you need to troubleshoot a golf cart?
While both types of golf cart are different, there are two things you need to troubleshoot whether you have a gasoline or an electric golf cart; the fuse and ignition.