Fixing the battery will usually help you resolve the issue of your golf cart clutch not engaging. If you find that the issue does not lie with the battery, then you might have to remove the back cover and take a look at the system to figure out what the issue is. With the rear end jacked up, try throttling the cart.
Full Answer
Why won’t my EZGO golf cart go forward?
The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward. You can check out the steps given below to address this problem.
How do you release the rear brakes on an EZGO golf cart?
To release the locked rear wheels on an EZGO golf cart, you have to push the lower part of the brake pedal. You should jack up the rear end and then remove the rear wheels and tap the brake drums. If you don’t use the golf cart for a long time, then the pads can freeze to the shoes.
Are the EZGO RXV's locking up without the brake pedal?
The EZGO RXV golf carts use a motor braking system. Are they locking up without pushing the brake pedal? Yes I will be driving along and they suddenly lock up without touching the brake pedal.
Where is the tow switch on an EZ GO golf cart?
Lift your E-Z-Go cart’s front seat. You will see the tow/run switch; turn it to tow instead of run. Look for wires labeled 1, 2, 3, 4 and ensure that wire 1 connects to wire2 and where wire3 connects to wire 4.
Why is my golf cart locked up?
Why Do Golf Cart Brakes Lock Up? Golf cart brakes can start locking up when the brake cable gets stuck, or when the bolts on the lift kit are loose. The brake cable gets stuck because of a binding, resulting in a mechanical linkage. One or more parts of the pivot assembly have rusted.
What would cause an electric golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
How do you reset the motor on a EZ Go golf cart?
Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button. Push the button to reset the motor. Put the panel in place and secure it with the screws.
Why is my golf cart clutch not engaging?
Cleaning the clutch thoroughly might be the simplest solution to this problem. You could also try lubricating the system with a good quality lubricant. This might free up the clutch and thus prevent the squeaking noise. Another common reason could be due to the weights present inside the system hanging up.
Why does my EZGO golf cart not move?
Why EZGO gas golf cart won't go forward? The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward.
Why won't my EZGO golf cart go forward or reverse?
Electrical Issues For example, if your run/tow switch has malfunctioned, your cart won't go forward or backward. This switch is designed to change your cart's operating mode from normal operation to increased power for towing. Check the switch to make sure that it isn't “stuck” between the two modes.
Where is the reset button on a golf cart motor?
The reset button acts as a mini circuit breaker for the motor, so it will correct any minor errors. Expose the motor (you'll probably need a screwdriver to remove the cover), and look for a red button. It is usually near the main power source, where most of the wires are connected.
How do I know if my EZGO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
How do you know if your golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Why is my centrifugal clutch not engaging?
Centrifugal Clutch Won't Engage If your clutch won't engage, It usually means that the engine idle speed is different to the clutch idle speed. This can result in damage. To correct this, change the spring or change the engine speed to below the clutch idle speed.
How does ezgo clutch work?
0:463:28How a golf cart CVT slip drive clutch works - YouTubeYouTubeStart of suggested clipEnd of suggested clipMaking the revolution path smaller like dropping the chain on the back of your bike down to aMoreMaking the revolution path smaller like dropping the chain on the back of your bike down to a smaller gear causing the belt to rotate even faster.
How do you adjust the belt on a EZ Go golf cart?
There is no way to adjust a drive belt, so it's important to get the right size belt in the first place. To be sure, visit your local mechanic or call a certified technician to help you get the right drive belt for your EZGO golf cart.
How do you fix a golf cart that won't move?
When the cart won't move, you have to be sure that the batteries are sending sufficient power to the circuit. You must check the fuse. Use the voltmeter to check the voltage at the key switch. In a cart with batteries rated at 48V, it must show 48V at the key switch.
How do I reset my electric golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
How do you test an E-Z-Go Golf Cart Controller?
Depending on the E-Z-Go Golf cart you own, there are two types of controllers, the Drive control systems and the Precision Drive System. Only E-Z-Go carts made before 1994 have a Drive Control System. If you notice that your E-Z-Go golf cart is not running at a constant speed, you should troubleshoot the controller to identify the problem. Here are the steps you should use to test your E-Z-Go golf cart controller.
Why does my E-Z-Go Golf Cart feel sluggish when accelerating?
The reason why your golf cart is sluggish during acceleration or stalls depends on whether it is a gas cart or an electric one. Here are the reasons for sluggishness in both.
Why is my E-Z-Go golf cart losing power?
E-Z-Go golf carts often lose power because of corrosion or loose cables. If the connecting wires in electrical circuits break, your battery will lose power. The same will happen if you have a short circuit in the ignition system. Here are steps you can use to ensure that the system is working correctly.
Why won’t my gas golf cart charge the battery?
If you own a gas E-Z-Go golf cart, the battery may not get charged. Make sure that you have refueled your golf cart, and then check for the following issues.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my golf cart start?
If your golf cart does not start even though the starter is rotating, there could be a problem with your battery, solenoid, or starter. Check the ignition and make sure you make the necessary repairs and replacements.
What does the Ezgo manual say about golf cart batteries?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.” This means that every manufacturer retains its own unique requirements, specs, and timelines. The less you procrastinate on troubleshooting your golf cart, the easier it will be to get faulty items repaired or replaced.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
What is the recommended tire pressure for an EZGO golf cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
How to reset a golf cart motor?
This panel door is generally secured with several screws . Carefully remove them with a screwdriver. Then reset your cart’s motor; most golf cart electric motors contain a special button designed to reset the motor by behaving like a tiny circuit breaker.
Why is my golf cart foot pedal so smooth?
If you are having issues with the smoothness of your foot pedal, it may simply be due to the air quality of your surroundings and should eventually fix itself. If your golf cart is a few months or years old, the stickiness may be due to constant pressure.
Why does my cart make a noise?
If your cart is driving slower than usual or making strange noises “down there,” it could very well just be a sign of low tire pressure. Check the pressure regularly to make sure you don’t just need a good old-fashioned tire pump!
Why does my EZGO golf cart lock up?
The EZGO golf cart rear wheels can start locking up because of faulty brakes, low pressure fluid, or a bad proportional valve.
How do I release locked up wheels on a EZGO golf cart?
When the batteries of an EZGO golf cart are dead or have too much power, the wheels can lock up. The rear wheels may also lock-up because of bad proportion valve, defective breaks, and low fluid vale.
Why my golf cart wheels won’t turn?
Golf cart wheels won’t turn because of the stripped axle, issues with an input shaft, and solenoid problems.
Why EZGO RXV Rear Wheels are locked up?
The EZGO RXV rear wheels locked up because of damage to brakes, low fluid, battery dead, and all.
What happens if you don't use a golf cart?
If you don’t use the golf cart for a long time, then the pads can freeze to the shoes.
How to spin both wheels on a golf cart?
To spin both the wheel of my golf cart, I welded my spider gears simultaneously. As per my suggestion, it’s the easiest way.
Can you unlock an EZGO wheel?
With the help of a diagnostic tool, you can unlock your EZGO wheels. With this, you can check the precise fit and function of your EZGO RXV wheels.
Why is my EZGO golf cart stuck in reverse?
An EZGO golf cart gets stuck in reverse in case of a faulty Forward/Reverse switch, defective microswitches, or a shorted solenoid bracket.
Why EZGO gas golf cart will not reverse?
A EZGO gas golf cart will not go in reverse if there is a faulty transmission system, improper cable adjustment, a defective microswitch present inside the Forward/Reverse controller, or a malfunctioning neutral limit switch.
Why won’t my EZGO golf cart go forward or reverse?
A EZGO golf cart may not go forward or reverse because of a malfunctioning microswitch, solenoid, or ignition switch. Loose or corroded cable connections or a faulty controller can also cause the golf cart to not move.
Why EZGO goes in reverse but not forward?
Your EZGO may go in reverse but not forward due to a problem in the F&R contacts, faulty high amperage cables, or swapped motor wires.
Why does my golf cart make a clicking sound when I press the gas pedal?
If you don’t, this indicates a problem in the KSI circuit that causes the KSI microswitch to not make contact. Getting the KSI circuit redone correctly should get the golf cart moving in both directions.
Why is my Ezgo Marathon not in reverse?
An EZGO Marathon golf cart goes forward but has not in the reverse if the Forward/Reverse switch contacts fail to make contact in the reverse position or the KSI microswitch doesn’t make any contact when the Forward/Reverse switch is in the reverse mode. Sometimes, reverse microswitch may be defective and not engaging. You may have to do one or both of the following steps to rectify the problem.
How to fix a 2009 Ezgo RXV?
Look at all the battery connections and ensure that all of them are tight and free of corrosion. Tighten loose ones and clean or replace the corroded connections. This happens often in 2009 EZGO RXV golf carts.
Why your EZGO golf cart stops suddenly?
The main reason why a EZGO golf cart stops suddenly is because of a bad solenoid or low voltage levels causing a thermal cut.
When did the EZGO golf cart start?
EZGO golf carts starting from the year 2006 to latest models have seen the trends of the golf carts getting to sudden halts and not being mobile for long.
How to Fix EZGO RXV that stops suddenly?
Unfortunately, many users have complained that they have situations in which the EZGO RXV suddenly stops to a standstill.
Why your EZGO TXT has stopped running?
The main reasons why a EZGO TXT keeps stopping can be due to burnt wires, or low battery voltage.
Why does my golf cart stop working?
In case of any sort of loose wirings or broken wires, that may cause the golf cart to malfunction and it may come to sudden halts at frequent intervals. Check the readings from the voltmeter and ensure that both batteries are providing the requisite readings to keep the volt percentage in check.
What happens if you mismatch a golf cart battery?
If there is any sort of mismatch in voltage levels between the two batteries, the golf cart would malfunction and in the end, come to sudden halts.
How to know if a golf cart is working?
Check if the key switch or the solenoid is perfectly positioned and working fine. The key switch or the solenoid should be in perfect order to ensure the golf cart is working perfectly.
