How do I place the EZ GO PDS golf cart in diagnostic mode?
To place the E-Z-GO PDS Golf Cart in diagnostic mode, with the key in the 'OFF' position, move the 'Run Tow Maintenance' switch to the 'RUN' position, move the Forward and Reverse switch from 'Neutral to Reverse' five times...
Why is my E-Z-GO golf cart not running at a constant speed?
If you notice that your E-Z-Go golf cart is not running at a constant speed, you should troubleshoot the controller to identify the problem. Here are the steps you should use to test your E-Z-Go golf cart controller. Turn the maintenance switch under the switch to Tow-maintenance mode.
Do EZ GO golf carts have titles?
E-Z-Go Golf Carts, unlike vehicles, do not have a title, but they do have serial numbers. If you are buying a golf cart, it is essential to check the serial number to ensure you do not buy a stolen one. Each E-Z-Go Golf cart has a unique serial number that you can use to identify your golf cart.
Why does my EZ Go Cart keep backfiring?
If you notice that your E-Z-Go cart keeps backfiring, it could be due to a loose muffler and improperly adjusted accelerator limit switch. It could also be due to your carburetor throttle, not closing, or a damaged carburetor valve spring.
What is a motor temperature sensor fault on an EZGO golf cart?
What is the best tool to diagnose an EZGO golf cart?
What does EZGO DC bus timeout error code 12576 mean?
What is the EZGO TXT high pedal fault?
What is a EZGO RXV drive fault?
What is EZGO TXT?
What is the Ezgo handheld tool?
See more

Where is the reset button on an EZGO golf cart?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How do you troubleshoot an EZGO golf cart?
Things to Keep in Mind Before TroubleshootingEZGO golf cart batteries aren't perfect right away.Sticky accelerators are perfectly normal and can be fixed easily.Keep your cart stable.Make sure your charging wall socket isn't faulty.Keep your tire pressure stable.Troubleshooting the speed controller.
How do I know if my EZGO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
Why won't My EZGO start?
Check Ignition Wire If it has, reseat the wire into the solenoid. If the wire appears corroded, wear your work gloves and wipe down the wire and attempt restarting the golf cart. If the cart will not start, then you will need to replace the ignition wire.
Is there a fuse on an EZGO golf cart?
Most EZ-GO carts will the fuse located in the charging receptacle.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
How do I test my golf cart controller?
The simplest test to ascertain your golf cart controller's performance is to to watch whether it runs when the batteries are fully charged with a slight push of the pedal. If you hear a distinct clicking noise, then your golf cart is running correctly.
What would cause a golf cart not to start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Why is my golf cart not firing?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Why did my golf cart stop working?
When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
What would cause a golf cart not to move?
Solenoid Wear When there is a disruption in the flow of the electrical current, your cart will not operate. A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate.
Do all golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
Why does my ezgo golf cart not move?
The main reason why a EZGO gas golf cart will not go forward is because of a locked up brake, or a faulty solenoid and accelerator. A defective Run/Tow or Forward/Reverse switch can also cause a EZGO to not move forward.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
EZGO RXV Common Problems | Cartaholics Golf Cart Forum
Welcome to the forum... I've seen several that needed the solenoid replaced. It's my understanding this was a problem with the early EZGO RXV. I've heard of problems with the engine braking system, state of charge meter and the factory installed batteries not lasting very long.
EZGO RXV Problems & Troubleshooting Guide 2022
Top 6 EZGo RXV Problems. This article is a great resource for getting to know the EZGo RXV problems. It is designed to help you troubleshoot most of the common problems you may experience and help you figure out what’s going on with your cart.
EZGO TXT. WILL NOT MOVE (TEST WITH NO HANDHELD) DONT RUN OR INT ...
how to troubleshoot a ezgo txt 48v. these are the common problems. that we see at our shop... always remember safety first. always jack cart up from the ...
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
How do you test an E-Z-Go Golf Cart Controller?
Depending on the E-Z-Go Golf cart you own, there are two types of controllers, the Drive control systems and the Precision Drive System. Only E-Z-Go carts made before 1994 have a Drive Control System. If you notice that your E-Z-Go golf cart is not running at a constant speed, you should troubleshoot the controller to identify the problem. Here are the steps you should use to test your E-Z-Go golf cart controller.
Why does my E-Z-Go Golf Cart feel sluggish when accelerating?
The reason why your golf cart is sluggish during acceleration or stalls depends on whether it is a gas cart or an electric one. Here are the reasons for sluggishness in both.
Why is my E-Z-Go golf cart losing power?
E-Z-Go golf carts often lose power because of corrosion or loose cables. If the connecting wires in electrical circuits break, your battery will lose power. The same will happen if you have a short circuit in the ignition system. Here are steps you can use to ensure that the system is working correctly.
Why won’t my gas golf cart charge the battery?
If you own a gas E-Z-Go golf cart, the battery may not get charged. Make sure that you have refueled your golf cart, and then check for the following issues.
Why does my golf cart stop moving?
This Golf cart is very temperamental, and even things like over-tightening a stud can make it stop moving. Check the F/R switch stud for overtightening. If it is over-tightened, the contact will not connect with the switch. Adjust this, and your golf cart will start working.
Why won't my golf cart start?
If your golf cart does not start even though the starter is rotating, there could be a problem with your battery, solenoid, or starter. Check the ignition and make sure you make the necessary repairs and replacements.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
What does the Ezgo manual say about golf cart batteries?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.” This means that every manufacturer retains its own unique requirements, specs, and timelines. The less you procrastinate on troubleshooting your golf cart, the easier it will be to get faulty items repaired or replaced.
What is the recommended tire pressure for an EZGO golf cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
How to reset a golf cart motor?
This panel door is generally secured with several screws . Carefully remove them with a screwdriver. Then reset your cart’s motor; most golf cart electric motors contain a special button designed to reset the motor by behaving like a tiny circuit breaker.
Why is my golf cart foot pedal so smooth?
If you are having issues with the smoothness of your foot pedal, it may simply be due to the air quality of your surroundings and should eventually fix itself. If your golf cart is a few months or years old, the stickiness may be due to constant pressure.
What to do if your charger is not reading voltage?
You can try resetting the circuit breaker or replacing the socket or charger entirely.
Why Won’t My EZGO Golf Cart Start?
EZGO golf carts may not start due to a transmission problem, corroded battery terminals or a faulty wiring coming from the ignition.
What direction should a golf cart be in?
Make sure the golf cart is either in forward, reverse or neutral and not anything in between as this will interrupt the electrical flow and give you the wrong readings.
Why won't my EZGO RXV move?
Brake Problems: Many times the reason your RXV won’t move is because of brake problems. The RXV is designed to be disabled when there is a problem with the break. Many times, the wiring that connects the brakes to the controller gets loose or is damaged. This can disable your EZGO RXV.
How to unclog a golf cart muffler?
To unclog it, simply make a fire and remove your muffler and put it there.
What to do if replacing ignition wire doesn't work?
To check the continuity of the ignition wire you’ll need to use an ohmmeter or a continuity tester. To do this, set the switch to off and set your ohmmeter to X1.
Why does my golf cart make a clicking noise?
When you press your golf cart pedal you should hear a clicking noise, if you don’t hear a clicking noise there might be a problem with the solenoid. To make sure your solenoid is functioning properly check it with a voltmeter. If you hear a click then you need to check its power with the voltmeter.
Why is my golf cart ignitor failing?
The most common reason for a failed ignitor is a bad voltage regulator. Therefore, when you replace or fix the ignitor on your golf cart, make sure you also check the voltage regulator and see if it needs to be replaced. There have also been cases where the battery has switch polarity for some reason.
Why your EZGO golf cart stops suddenly?
The main reason why a EZGO golf cart stops suddenly is because of a bad solenoid or low voltage levels causing a thermal cut.
When did the EZGO golf cart start?
EZGO golf carts starting from the year 2006 to latest models have seen the trends of the golf carts getting to sudden halts and not being mobile for long.
How to Fix EZGO RXV that stops suddenly?
Unfortunately, many users have complained that they have situations in which the EZGO RXV suddenly stops to a standstill.
Why your EZGO TXT has stopped running?
The main reasons why a EZGO TXT keeps stopping can be due to burnt wires, or low battery voltage.
Why does my golf cart stop working?
In case of any sort of loose wirings or broken wires, that may cause the golf cart to malfunction and it may come to sudden halts at frequent intervals. Check the readings from the voltmeter and ensure that both batteries are providing the requisite readings to keep the volt percentage in check.
What happens if you mismatch a golf cart battery?
If there is any sort of mismatch in voltage levels between the two batteries, the golf cart would malfunction and in the end, come to sudden halts.
How to know if a golf cart is working?
Check if the key switch or the solenoid is perfectly positioned and working fine. The key switch or the solenoid should be in perfect order to ensure the golf cart is working perfectly.
What is the green light on an EZGO golf cart?
You may notice two types of flashing of the green light on the EZGO golf cart charger. One is a flash of short duration while the other is a long flash.
Why does my Ezgo golf cart have two red flashes?
If the charger on your EZGO golf cart is Powerwise QE or Delta Q, the two red flashes mean that there is either a fault with the connector or there is a battery voltage issue. As mentioned briefly in the table above, the red flash may follow a pattern, like 2 flashes, a pause, followed by another 2 flashes.
Why is My Golf Cart Charger Flashing Red?
The battery charger on your golf cart will start flashing red due to a fault code. 2 red flashes can mean that the voltage is too low.
What voltage does a golf cart battery have?
If the golf cart’s battery bank is showing a voltage level below 36.0 volts or if the voltage exceeds 67.2 volts, then 2 red flashes of the indicator can be observed. If that is not the case then there could be a connector issue. Connector issues can only be resolved at the service center.
What happens when a golf cart battery is fully charged?
When the battery bank in your golf cart is fully charged, the flashing will stop and you will notice one solid green light. You should note that the LED indicators on the battery chargers for golf carts are different for the different brands and models. Each charger may have its unique set of colored LED indicators.
Why does my EZGO RXV battery light flash red?
If the red light flashes twice, it indicates that the battery voltage could be too low and the charger is not able to charge the battery bank.
What does a green light on a golf cart mean?
A green light flashing on the battery charger of your golf cart usually indicates the charge level of the battery. Short green flashes mean the charge level is below 80%, where long flashes mean the charge level is above 80%. If it is one solid green light it indicates the golf cart’s battery is fully charged to 100%.
What is a motor temperature sensor fault on an EZGO golf cart?
The motor temperature sensor fault in an EZGO RXV golf cart is not associated with any specific code. This is indicated as a warning by the golf cart when this sensor is disconnected or shorted.
What is the best tool to diagnose an EZGO golf cart?
The Curtis Programmer is another good option for diagnosing your EZGO RXV golf cart. This too comes in four variants namely, OEM, Dealer, Service and User. The OEM version is a handheld tool and is priced at around USD 350.
What does EZGO DC bus timeout error code 12576 mean?
The EZGODC bus timeout error code 12576 means the DC bus voltage reading is not 24 volts within ten seconds of setting the key switch to start position.
What is the EZGO TXT high pedal fault?
The EZGO TXT high pedal fault is associated with a 1-4 error code. The pedal gets disabled and the golf cart will not move.
What is a EZGO RXV drive fault?
The EZGO RXV drive fault indicates a fault in the motor, controller or electrical system of the golf cart.
What is EZGO TXT?
The EZGO TXT golf cart is associated with multiple fault codes to help you with the diagnosis or troubleshooting of your cart. The table below highlights the key fault codes pertaining to the cart along with their interpretation.
What is the Ezgo handheld tool?
The EZGO handheld diagnostic tool is quite handy in monitoring the various critical system functions of the golf cart as well as its battery life. The user-friendly tool is compatible with any Curtis controller and is recommended for EZGO 48V RXV and TXT model golf carts. This handheld tool is pricey and costs around USD 1,200.
