Replacing the old battery can solve the problem. Some loose connections in the circuit can cause loss of power, and necessary rectification can solve the power loss issue. EZGO golf cart loses power going uphill.
Full Answer
Why does my EZGO golf cart have no power?
The reason for a EZGO golf cart having no power can be due to a battery that has drained, the spark plug not working, or snapped electrical cables. The battery is draining- It is one of the most common causes of the Ezgo golf cart having no power to move.
How to troubleshoot the controller of an EZGO?
Follow these steps to troubleshoot the controller of an EZGO: When the cart is to be serviced or the controller needs troubleshooting, the maintenance switch under the seat needs to be flipped. Flip the switch and turn the tow maintenance mode on. Now, take the negative battery cable (black) and disconnect it.
What kind of speed controller does an EZ GO golf cart have?
The E-Z-GO golf cart has two kinds of speed controllers, the Precision Drive System (PDS) and the Drive Control System (models before 1994). If your cart is having problems running at a constant speed or is performing erratically, then you should troubleshoot the controller to find out what the problem is.
What happens if there is no voltage on a golf cart controller?
If there is no voltage, the controller is bad and must be replaced. It's important to remember that if you are not fully confident in the work you are trying to perform on your E-Z-GO golf cart, consult with your local E-Z-GO dealer to be sure your work gets done properly.
How do I know if my EZGO controller is bad?
Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor. If there is no voltage, the controller is bad and must be replaced.
Why does my EZGO golf cart lose power?
The main reason why a EZGO golf cart can lose power is because the battery is not charging due to loose cables or the corrosion of the connecting terminals. If they become loose or some of the electrical circuits' connecting wires snap, the battery loses power.
How do I reset my EZGO golf cart controller?
Reset the battery cable Unplug the negative battery cable (the black wire) before beginning any work on the speed controller. Once disconnected, you should remove the speed controller cover and then reconnect the negative cable.
Why does my electric golf cart cut out?
Check the batteries. Sometimes, one or both of the batteries could be dead making the cart cut off. Ensure that both the batteries are working fine and have enough water and electrolytes. If the batteries are dead, then replacing them will solve the issue.
How do I know if my golf cart controller is bad?
X Common Symptoms of Controller FailureTop Speeds Not Appropriate for Your Cart. Golf carts are designed to reach pretty specific speeds and to not go over them or beneath them. ... Sudden and Unexpected Slowing. ... Shuttering or Shaky Driving. ... Stalling Out and Refusing to Start. ... Surges in Speed When Driving.
How do I know if my golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Where is the reset button on an ezgo golf cart?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
How do you test a golf cart motor controller?
How to Test a Club Car Golf Cart Speed Controller? The simplest test to ascertain your golf cart controller's performance is to to watch whether it runs when the batteries are fully charged with a slight push of the pedal. If you hear a distinct clicking noise, then your golf cart is running correctly.
How do you test a motor controller?
How to Test an Ebike Controller at HomeStep 1: Connect your controller to the battery.Step 2: Set the multimeter reading. ... Step 3: To test for continuity, set your multimeter to continuum. ... Step 4: Test every line that comes out of the controller. ... Step 5: Set your multimeter to resistance mode to test for resistance.More items...•
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you troubleshoot an electric EZGO golf cart?
Things to Keep in Mind Before TroubleshootingEZGO golf cart batteries aren't perfect right away.Sticky accelerators are perfectly normal and can be fixed easily.Keep your cart stable.Make sure your charging wall socket isn't faulty.Keep your tire pressure stable.Troubleshooting the speed controller.
What does a potentiometer do on a golf cart?
It sends an electrical signal to the speed controller from the accelerator pedal, indicating the pedal's position. When it is working properly, the potentiometer allows your golf cart to accelerate smoothly. Find your potentiometer and inspect it for any cracks, broken parts, or disconnected wires.
Why is my gas golf cart losing power?
A faulty or broken carburetor is likely the most common triggering factor for serious issues with your cart's power problems. The carburetor helps to keep your cart cleaner in operation and manages many elements of your fuel in your cart.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why is my electric golf cart sputtering?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
Should I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
What is the controller on an EZGO golf cart?
Known as the heart of the EZGO golf cart, the controller’s core objective is to control the speed of the golf cart. It is a needed component in a AC and brushless DC motor. Without the controller, the golf cart will not work. The speed controller is not present in the DC motor vehicles, which is why they do not have varying speeds.
What is the purpose of the speed controller on an EZGO cart?
Major functions of the speed controller of the EZGO cart are: Acceleration: The controller controls the speed of the vehicle. It also regulates the speed when you apply full throttle to the cart. Battery health maintenance : The controller makes sure that the battery is working well and is not overloaded.
How to check the output of a controller?
To check the controller output, follow these steps: Press the pedal of the cart until the solenoid clicks. Keep watching the voltmeter and see if it is showing the battery voltage. Now again, keep pressing the pedal and see if the voltage is going down or not.
What is the purpose of a golf cart controller?
Golf cart controllers play an important part in which its main job is to control the speed of a golf cart. However, many times, the controller tends to act up or simply stops working. This is when it is very important to troubleshoot the problem immediately. Known as the heart of the EZGO golf cart, the controller’s core objective is to control ...
What is the 2005 Ezgo cart?
2005 EZGO TXT cart is one of the popular ones since it has some of the best features. The features include handles on the top, the plastic front bumper is not there, and the seatback is connected.
Why does EZGO have different speeds?
However, a vehicle with a speed controller will have different speeds as it will change the voltage and current input based on user input. This is why EZGO with controllers can be accelerated and decelerated and the rate ...
Why is my cart not moving forward?
If the cart is not moving forward or the speed is not getting regulated or there is a problem in controlling the speed, then the chances are that the controller is being erratic. Then, it is very important to troubleshoot the problem as soon as possible.
What happens if you charge your golf cart?
You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
Why does my golf cart keep powering off?
If the cart starts powering off after a new installation, then you will know that the issue is caused due to errors with the installation.
How to check battery water level in golf cart?
How to Check Battery Water Levels in a Golf Cart. Check if the voltages in both the batteries are at the designated levels. Also, if the water in the batteries has dried up, it could cause this issue. Check for the electrolyte and water levels in the batteries. Make sure that you are not overcharging or undercharging your batteries as these could ...
Why does my cart have a loose solenoid?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch.
Why does my golf cart cut out?
Another reason why golf carts can cut out is due to problems with the battery voltage or water levels.
Can you fix a golf cart on your own?
Under NO circumstances should you attempt to fix your golf cart on your own. Doing so is dangerous and could result in serious bodily harm. The information on this website has not been verified for accuracy and should only be used for general information purposes only. Use this information at your own risk.
Can you clean out a V glide?
You can also verify whether the wires and connections within the V-Glide assembly are not loose. Any dust or dirt that has managed to get into the assembly could also make the throttle to cut out. Cleaning out the assembly might also be a good idea.
Flip the Maintenance Switch
Both types of E-Z-GO controllers have a maintenance switch which should be flipped when servicing or troubleshooting. The switch is under the seat and should be changed to "Tow-maintenance" mode.
Reconnect the Battery Cable
Disconnect the black battery cable (negative) from the battery, open the cover to the speed controller and then reconnect the negative battery cable.
Inspect Wires and Check Voltage
Inspect all wires to ensure that they are attached and well connected, there are no breaks, corrosion or interference with the wires. Take the reading of the battery voltage by connecting the positive and negative probes to the battery. Write down the voltage reading.
Test the Solenoid
Place the positive probe on the solenoid post that is closest to the battery. The reading should be equal to battery's voltage. If not, there is a wiring issue in the solenoid. Connect the positive probe to the other post and take a reading.
Check Power Output From the Controller
Connect the negative probe to the controller's M terminal and positive probe to the B+ terminal. Press the accelerator and watch to see if the voltage increases. It should increase from a reading of 0 to the full voltage of the battery. If the motor is not turning, the problem may be in the directional switch or motor.
Next Steps
It's important to remember that if you are not fully confident in the work you are trying to perform on your E-Z-GO golf cart, consult with your local E-Z-GO dealer to be sure your work gets done properly.
About the Author
Steve Smith has published hundreds of articles on a wide range of topics, including cars, travel, lifestyle, business, golf, weddings and careers. His articles, features and news stories have appeared in newspapers, consumer magazines and on various websites, including Trails.com and eHow.com.