Golf-FAQ.com

ezgo golf cart jerks when taking off

by Prof. Meghan Cormier PhD Published 3 years ago Updated 3 years ago
image

If the clutch is bad, you could experience some jerking movement during the start or stopping stage of the golf cart. Consider getting the clutch checked and possibly replaced if any issues are there. This should help resolve the problem of the cart jerking when accelerating or taking off.

The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.

Full Answer

Does EZGO have a problem with their clutches?

 · Aug 7, 2017. #1. My 99 EZGO TXT electric golf cart jerks bad when taking off. Its like it goes and stops, but still keeps going. The cart was just refurbished with new motor, controller, solenoid and wiring harness. The golf cart ran fine for a month then this jerking started. I have replaced the solenoid, controller and checked all the wiring and connections since it …

Why does my tempo golf cart jerk?

How to fix jerky acceleration on a club car golf cart?

Why is my golf cart jerking forward and reverse?

1] Water-logging in some of the components of your electric golf cart can result in jerking. Sensors and micro switches installed near the vehicle’s floor mat can malfunction due to water interference, which causes jerks when you accelerate. 2] Sometimes, the Inductive Throttle Sensor (ITS) of your golf cart can go out of alignment.

image

Why does my electric golf cart hesitate when I accelerate?

If your cart does not start smoothly, hesitates before starting, or does not gain speed properly, these are all signs of a bad or damaged accelerator.

What causes a golf cart to jump?

Jerking electric golf carts are probably more common than a jerking gas model. That's because most “jerking” concerns are caused by battery issues or a poor flow of electricity from the battery to the cart. Typically, you'll start to notice this problem when your cart needs to charge up.

What does the MCOR do on a golf cart?

Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".

Should you charge a golf cart after every use?

Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.

How do I make my lifted golf cart go smoother?

To address each of these issues and smooth out your golf cart's ride you will need to:Replace Any Worn Out Shocks. ... Fix the Faulty Tire Pressure. ... Change Your Golf Cart's Oil & Oil Filter. ... Replace Worn Out Suspension Bushings. ... Fix Any Problems With Your Cart's Lift Kit. ... Add a Lift Kit to your Golf Cart.

How do I know if my golf cart solenoid is bad?

If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.

How do you test for MCOR?

To test the MCOR, look for the line item that says THROTLE. With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner.

How do you test a potentiometer on a golf cart?

Use an ohmmeter to test across those two wires, either at the controller or at the potentiometer. If you have a 0-5K ohms golf cart potentiometer, you would expect for the reading to be at zero and slowly progress to 5,000 ohms at pedal down position.

Where is the speed sensor on a Club Car golf cart?

Typically, the speed sensor can be found on the backside of the motor. When removing the speed sensor, unplug all the cables that are on the backside of the motor. To do this, use a socket to take off the connector pigtail. Then, remove its plastic housing over the sensor.

How often do you add water to golf cart batteries?

After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. You'll want to add water to 1/2 inch from the top of the battery. 2) We recommend service once or twice a year.

Can I leave my golf cart plugged in overnight?

Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.

What happens if you overfill golf cart batteries?

If you overfill golf cart batteries, the electrolyte (sulfuric acid) can leak out and cause a dangerous acid spill. If this happens, the acid can corrode metal and other materials in the surrounding area.

How to fix a club car DS that jerks when taking off?

You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.

How to stop a club car from jerking?

Inspect the Club Car for a faulty clutch. One indication for this is that the engine revs up when it has a certain RPM. Getting the clutch overhauled or replaced will stop the jerking.

How to fix club car precedent?

You can fix a Club Car Precedent that jerks when taking off by checking and fixing the MCOR and batteries. These are the two key parts that often cause the jerking action.

Why does my club car jerk in reverse?

Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem. A missing cable between the resistor and the forward/reverse selector can also cause the jerking in both directions.

How to fix jerk on 1985 club car?

If you have a 1985 Club Car, the jerk can be curbed by doing a high gear solenoid replacement. The solenoid will be in ON position when the cart moves both in forward and reverse directions. This solenoid is present on the passenger side of the golf cart.

How to fix jerky acceleration on club car?

One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn’t help, getting a new battery or new batteries fitted should work.

What causes a 1994 Club Car DS to jerk?

In a 1994 gas Club Car DS, check out for a sticky drive clutch that causes the jerking in both directions. A simple rebuilding of the drive clutch will stop the jerks.

Why does my golf cart jerk when starting?

There are a sensor and a micro-switch under the driver’s side floor mat. If water enters these components , especially the switch , it could cause the cart to jerk while starting.

Why does my golf cart bounce?

One of the common issues associated with the golf cart bounce is the tire. If the tires are not aligned properly or the threading has worn out, it could cause the cart to bounce.

What happens if your golf cart clutch is bad?

If the clutch is bad, you could experience some jerking movement during the start or stopping stage of the golf cart. Consider getting the clutch checked and possibly replaced if any issues are there. This should help resolve the problem of the cart jerking when accelerating or taking off.

How to fix a cart that is wobbling at high speed?

Consider replacing the springs with harder ones . This could help solve the issue of the cart wobbling at high speed.

How to get a bouncy cart back to its original shape?

You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart.

Why does my clutch jerk?

Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.

Can electric carts cause problems?

Electric carts can also cause trouble. One of the common problems is the vehicle jerks while starting.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9