
How to tow an EZGO golf cart?
The following steps can help you to tow an EZGO golf cart safely without any damage. Keep the Forward/Reverse switch in a neutral position. Remove the battery connections from the motor. This is done to ensure that the batteries do not get damaged during the towing process.
What kind of maintenance does an EZ GO golf car need?
Perform regular maintenance on EZ Go golf cars to keep them in prime condition. For electric models, this includes making sure the tires are properly inflated and cleaning the battery terminals often. For gas golf cars, check the oil every week and, if it’s low, fill with 10W-30 oil.
Do all EZ-GO golf carts have speed controllers?
Every EZ-GO golf cart comes equipped with one of two kinds of speed controllers, a precision drive system or a drive control system. All modern golf carts (Including any cart that is sold by Garrett’s) use the precision drive system or PDS, whereas older carts made before 1994 will use a drive control system.
What is a tow run switch on a golf cart?
This switch is common among modern golf carts and is rarely present on older models. The reason for this variance is that tow run switches are only installed on golf carts with a separately excited motor. Normally, a golf cart with this type of motor also possesses the ability for regenerative braking and roll away protection.

What does the run tow switch do on a golf cart?
TOW / RUN switches are basically kill switches designed to disable the golf cart. there are several reasons for this switch. Usually, a TOW / RUN switch is only used on electric golf carts, specifically those with a separately excited electrical system with regenerative braking.
Should I charge my golf cart in run or tow mode?
Your golf cart needs to be charged in Run. Tow should only be used in long term storage or if you are going to remove the battery.
Where is the tow run switch on an EZ Go golf cart?
The Run/Tow switch in an EZGO TXT golf cart is located below the seat on the passenger side of the cart. The toggle switch is usually protected with a black cover above it.
How do you use a golf cart tow bar?
2:053:36EZ-GO Garage "TXT Semi-permanent Tow Bar Assembly" - YouTubeYouTubeStart of suggested clipEnd of suggested clipThis is the same tow bar link from the ark seat to install it we simply slide it over the frontMoreThis is the same tow bar link from the ark seat to install it we simply slide it over the front pivot arm push. The pin in place guide the vehicle into the receiver. And that one is.
Can you charge golf cart batteries in tow mode?
The simple answer to this question is, yes, your golf cart will charge while tow mode is activated. Yes, activating tow mode will disable your cart's computer, but it does not affect your battery or its charging capabilities.
Should I leave my golf cart plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do I make my EZGO faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
How do you tow a EZ Go golf cart?
Release Motor Brake On An EZGO RXV When Batteries Are DeadPut the golf cart key in off position.Lift the front seat.Switch the golf cart tow/run switch to tow.Lift the cover around the tow/run switch.Identify wires that are labeled 1, 2, 3 & 4.1 is connected to 2 and 3 is connected to 4.More items...
What is the best way to tow a golf cart?
To tow your golf cart, you can choose from a few different options like trailers, tow bars and two dollies. An enclosed trailer is the safest and easiest way to tow your golf cart, but open trailers are more affordable.
Can you put a hitch on a golf cart?
A golf cart hitch allows you to haul a light weight trailer in and around your property. Golf Cart King has a large selection of receiver hitches for your EZGO, Club Car, Yamaha, or golf cart rear seat kit. You can also install our cooler set up by Madjax with the proper receiver hitch.
How do you tow a golf cart on a trailer?
1:278:52Transporting A Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipI pull this pin out this locking lever I lift it up. So now the trailer will tilt. And the bottomMoreI pull this pin out this locking lever I lift it up. So now the trailer will tilt. And the bottom drops on the floor. So what I do see let me back up I see. So that's what it looks like there then
How do I put the tow mode on my Yamaha golf cart?
1:042:017F Towing - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe rear wheels to free roll. For electric cars that are being towed place the tow run switchMoreThe rear wheels to free roll. For electric cars that are being towed place the tow run switch located. Under the seat into the toe position. This will allow the rear wheels to freely roll.
Do E-Z-Go Golf Carts have titles?
E-Z-Go Golf Carts, unlike vehicles, do not have a title, but they do have serial numbers. If you are buying a golf cart, it is essential to check the serial number to ensure you do not buy a stolen one. Each E-Z-Go Golf cart has a unique serial number that you can use to identify your golf cart.
Where is the E-Z-Go Cart Serial Number
As mentioned above, all E-Z-Go Golf carts have unique serial numbers. These numbers are essential when buying replacement parts for your golf cart. Textron Specialized Vehicles has been building golf carts for a long time, and the serial numbers are placed on different parts of the golf carts.
How do I push my E-Z-Go Golf Cart?
It can be frustrating when your battery is flat and your golf cart will not roll. To push it to the nearest charging or gas station, you need to release the motor brake. Follow these easy steps to do that.
Why does my E-Z-Go golf cart not move
There are several reasons why your cart refuses to move, but you should check the battery before anything else. If the battery is charged, here are some other reasons why your golf cart will not move.
Are all E-Z-Go Golf carts electric?
No, there are both electric and gas-powered E-Z-Go Golf carts available. Bear in mind that there are several models you can drive on the street, but those are all-electric. These electric models run on batteries that you have to charge at least every 24 hours, depending on how much you use them.
How to tell the Assembly year of my E-Z-Go golf cart
The placement of serial numbers is discussed above, and you will find the manufacturer’s number right next to it. The manufacturer’s number consists of one letter and 3 or 4 numbers. The last two numbers indicate the last two digits of the year of assembly.
How to service E-Z-Go Golf Cart
Like all vehicles, E-Z-Go golf carts require regular maintenance to enhance longevity and performance. You should ensure that your golf cart is serviced after every six months of use. That will ensure that you spot problems and repair them early, which will help reduce repair costs. Here are essential guidelines for E-Z-Go golf cart maintenance.
How to repair a crack in a golf car canopy?
To repair a crack in the canopy or body, use a fiberglass repair kit. Tires on EZ Go golf cars are tubeless, so you can repair them as you would a car tire. Perform regular maintenance on EZ Go golf cars to keep them in prime condition. For electric models, this includes making sure the tires are properly inflated and cleaning ...
Can you fix an EZ Go golf car?
From fixing a cracked canopy to replacing the battery, many repairs can be done on your own. However, more complex issues with the drive mechanism, accelerator assemblies and axles, should be handled by a pro.
The Tow Run Switch Explained
In general, a golf cart’s tow mode is activated via a tow run switch, which occasionally is referred to as a tow/ maintenance switch. This switch is common among modern golf carts and is rarely present on older models. The reason for this variance is that tow run switches are only installed on golf carts with a separately excited motor.
Where is the Tow Run Switch Located
Most likely, the tow run switch for your golf cart is located in the battery compartment. As you are probably aware, this compartment is almost always under a golf cart’s seat. The tow run switch should be in plain sight.
Will a Golf Cart Charge in Tow Mode?
The simple answer to this question is, yes, your golf cart will charge while tow mode is activated. Yes, activating tow mode will disable your cart’s computer, but it does not affect your battery or its charging capabilities. However, you can also charge your golf cart while it’s tow maintenance switch is toggled to ‘run’.
What does the Ezgo manual say about battery replacement?
The EZGO manual says that, “First, a battery that performs poorly and is outside of the manufacturer’s specification should be identified in order to replace it under the terms of the manufacturer’s warranty.”. This means that every manufacturer retains its own unique requirements, specs, and timelines.
What is an EZGO golf cart?
Your EZGO golf cart is probably a more integral part of your life than you realize. If you live in a residential neighborhood or gated community, chances are that you use your golf cart for a wide variety of purposes beyond simply golfing―to take a trip to the nearby grocery store, to drive a mile or two to the country club or tennis courts down the road, to act as a makeshift hunting vehicle during hunting season, or even to fetch your mail in rainy or snowy weather.
Why is it important to keep a golf cart in good shape?
Therefore, it is very important to keep your golf cart in great shape at all times, and learning how to troubleshoot can mean the difference between diagnosing and quickly fixing problems, or having your cart break down.
How many cycles does a golf cart battery take?
Your golf cart’s battery needs to mature completely before it can operate at its maximum levels. This can take as many as 100 full charge cycles, so be patient if the brand new golf cart you just purchased isn’t quite living up to its battery expectations.
What happens if the voltage is not equal to the voltage on a solenoid?
If it is not equal, then the solenoid has a wiring problem. oYou should also put the positive probe on the opposite post of the solenoid and read the voltage there. The voltage should have three or more volts below the battery’s own reading. If not, then you should get the resistor replaced as soon as possible.
How to tow a sandbox?
You should also make sure to raise the drive tires off the ground.The next step is to make sure that all your switches are in order. Flip the Tow / Run switch into “Run” when troubleshooting battery problems, or on “Tow” if you are taking a look at other issues, such as with the speed controller. Make sure that your key switch is turned ON; next, place the Forward / Reverse selector on FORWARD and place the pedal switch so that it is fully accelerating.
What is the recommended tire pressure for an EZGO cart?
The standard recommended pressure of an EZGO cart’s tires ranges from 18 to 22 PSI. Be sure to inspect your tires regularly, too, and replace them as necessary. If your cart is driving slower than usual or making strange noises “down there,” it could very well just be a sign of low tire pressure.
Why is it important to maintain a golf cart?
When you own a golf cart, it's important to keep it maintained for a smoother and trouble-free ride. Regular golf cart maintenance will keep your golf cart running for a long time without any issues.
What do you need to know about street legal golf carts?
Inspect Lights and Mirrors. Street legal golf carts are equipped with a street legal light package and side mirrors. If your cart is street legal, do not forget to check turn signals, brake lights, headlights, and mirrors. If any of your lights are not working, read out the owner's manual to find the fuse location. 9.
How to keep golf cart tires from wearing out?
Check Tires Pressure. Make sure to check the air pressure in your golf cart tires every week or so. If you inspect that air pressure is low, fill air in your tires right away. By doing this, you'll protect your golf cart tires from wearing out.
How to know if golf cart batteries are fully charged?
This way, you will always know your batteries are fully charged. 2. Check the Water Levels in Batteries. Keep a close eye on the water level in your batteries. If the water level is too low, you'll need to add water to bring them back up.
Can you replace golf cart batteries?
When you need to replace your golf cart batteries, it is best to replace all of the batteries simultaneously. If you put a new battery with an older pack of batteries, then the older batteries will reduce the new battery's life. The older batteries take a longer time to charge than the new ones, and eventually, you will destroy the new ones by overcharging.
Do golf carts need lubrication?
Like other vehicles, golf carts also require regular suspension lubrication. The steering wheel rack and pinion also need to be greased regularly. The frequency of lubricating varies by model, so be sure to read the owner's manual for the required timeframe. If you ever notice oil on the ground near or around your golf cart, get underneath your cart and inspect or just connect with a mechanic.
Tow Run
The tow run switch, also sometimes called a tow maintenance switch, is present in many brands and models of modern golf carts. This switch is only installed into golf carts with a separately excited motor which produces regenerative braking. They are not used in traditional golf carts with a series wound motor.
Separately Excited Systems
The tow run switches are used in golf carts with separately excited motor and corresponding controller. The electronic speed controllers used in this application have a bit of logic memory within, similar to your automobile’s stereo when it saves your favorite preset stations.
Roll Away Feature
There is also another use for the tow run switches used in golf carts with a sepex controllers and motors. Most carts with this type of system also have a special feature built into the programming of the controller, called the “Roll Away” feature.
What is the controller on an EZGO golf cart?
Known as the heart of the EZGO golf cart, the controller’s core objective is to control the speed of the golf cart. It is a needed component in a AC and brushless DC motor. Without the controller, the golf cart will not work. The speed controller is not present in the DC motor vehicles, which is why they do not have varying speeds.
What is the 2005 Ezgo cart?
2005 EZGO TXT cart is one of the popular ones since it has some of the best features. The features include handles on the top, the plastic front bumper is not there, and the seatback is connected.
What is the purpose of the speed controller on an EZGO cart?
Major functions of the speed controller of the EZGO cart are: Acceleration: The controller controls the speed of the vehicle. It also regulates the speed when you apply full throttle to the cart. Battery health maintenance : The controller makes sure that the battery is working well and is not overloaded.
What is the purpose of a golf cart controller?
Golf cart controllers play an important part in which its main job is to control the speed of a golf cart. However, many times, the controller tends to act up or simply stops working. This is when it is very important to troubleshoot the problem immediately. Known as the heart of the EZGO golf cart, the controller’s core objective is to control ...
Why does EZGO have different speeds?
However, a vehicle with a speed controller will have different speeds as it will change the voltage and current input based on user input. This is why EZGO with controllers can be accelerated and decelerated and the rate ...
Why is my cart not moving forward?
If the cart is not moving forward or the speed is not getting regulated or there is a problem in controlling the speed, then the chances are that the controller is being erratic. Then, it is very important to troubleshoot the problem as soon as possible.
Why is my cart controller hot?
Then the reason will simply be that the load on the engine and motor is also causing the controller to get hot. But if the cart controller gets hot even while on a short distance run or even if it is switched on, then it can be due to faulty wiring and connections.
Why is my golf cart not turning?
The two possible problems you can identify this way is either a bad speed controller, or a bad directional switch or motor. If the motor on your golf cart doesn’t turn, the problem is probably the directional switch/motor, but if there is no voltage at all on your reading, you’ll need to replace your speed controller.
What is Garrett's drive system?
All modern golf carts (Including any cart that is sold by Garrett’s) use the precision drive system or PDS, whereas older carts made before 1994 will use a drive control system. These devices control the acceleration and overall speed of the golf cart, so when they’re not working properly it’s important to know what to do.
How to test solenoid on a cart?
To test your cart’s solenoid, you’ll want to take a reading of the voltage and compare it to the reading you got off your battery. Att ach the positive probe to the solenoid post nearest the battery and get the reading. If the solenoid and battery readings are identical, there is an issue with the solenoid.
