There are some reasons why your golf cart fuse tends to keep blowing: There is a naked wire or a grounded wire. Check all connections to see if any of them have come off and connect them once again. There is a dead-short connection after the start switch.
Full Answer
Can you change a blown fuse in a golf cart?
Golf carts serve a greater need than just driving on the golf course. As more drivers select golf carts as their preferred method for quick transportation, understanding how to make simple repairs, like changing a blown fuse, becomes necessary. Many hardware stores carry fuses that are compatible with those in a golf cart.
Where is the fuse box on a CC DS Golf cart?
The fuses in a 1986 CC DS gas engine golf cart is located behind the dash. The fuse box in a 1997 Club Car can be found in the black electrical component box that is near the battery. In a 2004 Club Car Precedent, the fuses are located in two black plastic fuse holders that come with a molded support hole extension.
How do you check the fuse on a golf cart battery?
Find the service panel on the rear fender on the driver side of the golf cart behind the battery. Read the inside panel to determine the level of current the fuses are set to take at a maximum voltage.
Where is the 400 Amp Fuse on a golf cart?
The 400-amp fuse will be located as close as possible to the power source or batteries. It can be placed on either the positive terminal or negative terminal of the battery. This makes it easy to check the fuse than when it’s under the golf cart. Golf carts with an Alltrax controller usually feature a 400-amp fuse fitted on the controller.
Why does my golf cart keep blowing fuses?
A golf cart fuse can blow for many reasons such as a faulty relay switch, loose connections or a naked wire.
Do electric golf carts have fuses?
Yes, golf carts contain fuses just like those found in a car or truck.
Is there a fuse for the lights on a Yamaha golf cart?
Yamaha typically places the fuses on its golf carts in the same location for each model. This choice is designed to create a uniform style between each of these models that makes it easier to work on them without running into any complications.
How do you check a fuse on a golf cart?
0:000:52Changing the Fuse - YouTubeYouTubeStart of suggested clipEnd of suggested clipSimply by pulling it out of the socket. Looking at the fuse itself the fuse should not be discoloredMoreSimply by pulling it out of the socket. Looking at the fuse itself the fuse should not be discolored. And this small area in the middle. Should not be broken.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Do all golf carts have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
Where is the reset button on Yamaha electric golf cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
Why are my lights not working on my golf cart?
A blown-out headlight fuse is the main reason that your EZGO RXV golf cart lights are not working. An incorrect circuit connection to the headlight fuse can also cause the lights to stop working. There are times when the circuit wires are torn or worn out.
How do you reset an electric golf cart?
Believe it or not, it may be as simple as pressing a reset button. Use a screwdriver to expose the motor. Look for a small red button located near the main power supply. Press the button and put your cart back together before hooking it up to charge.
What would cause a fuse to keep blowing?
Overloaded Circuit The most common cause of a blown fuse is when something draws too much power from the circuit. This is most often caused by either too many lights or from using too many plug-in appliances at once. The biggest culprit for this kind of issue is a multiple outlet adapter plugged into a socket.
How can you tell if a relay fuse is blown?
Using a multimeter to test a relay fuse is pretty simple. Set the multimeter to Ohms and touch the leads on the electromagnet coil pins to measure resistance. It should be between 50 to 120. If it's out of that range or says it's open, you have a bad electromagnet coil.
How do you find a short in a car blown fuse?
1:2410:24Steps to Finding an Electrical Short that Keeps Blowing Fuses - YouTubeYouTubeStart of suggested clipEnd of suggested clipUsing a pair of pliers this is a custom set of pliers that I make here in my shop. Now I'm justMoreUsing a pair of pliers this is a custom set of pliers that I make here in my shop. Now I'm just gonna roll this in very carefully. Look at that it immediately blew with a loud snapping.
What does a blown fuse mean on a golf cart?
Many hardware stores carry fuses that are compatible with those in a golf cart. A blown fuse can also mean there is an electrical problem. A blown fuse requires a thorough examination of the circuit system to locate the problem.
Why does my golf cart have a fuse that is not pushed?
A fuse not pushed in all the way causes a weak connection and the possibility of the fuse blowing again. Routine maintenance can prevent a small issue like a blown fuse from becoming a major electrical problem. If the fuse continues to blow, there is a serious problem with the electrical system of the golf cart.
What happens if a golf cart won't start?
If the golf cart won't start, then on the inside of the service panel read to see where the electrical start fuse is and pull it out.
What are some examples of fuse levels?
Most fuses have white numbers stamped on the face of the fuse to tell you the type of fuse. Examples of level of current stamps on a fuse are 5A, 10A and 15A.
Do golf carts need fuses?
Golf carts serve a greater need than just driving on the golf course. As more drivers select golf carts as their preferred method for quick transportation, understanding how to make simple repairs, like changing a blown fuse, becomes necessary. Many hardware stores carry fuses that are compatible with those in a golf cart.
2008 Yamaha golf cart. What would cause a grinding noise when accelerator pedal is released?
The electronic brake and the grommet are not working anymore would both need to be replaced for your golf cart.
I have a 1983 g1 yamaha gas golf cart that won't start from the accelerator. .I've already cleaned all on the connections on the battery starter and solenoids. .it will start if I press down on the..
Follow the wires with a volt meter from battery to gas pedal switch to solenoid. Sounds like a bad micro switch , wire, or bad solenoid.
What type of oil does the yamaha golf buggy use ?
Mike, Yamalube 4-cycle oil or quality SAE 10w-30 motor oil, is the oil for use in your cart. Check the attached links,instruction and guides, Good luck
I have a 1992 yamaha gas golf cart i changed the reulator because it wasnt charging then it started blowing the fuse , so i changed the generator and it is still blowing the ten amp fuse
If it blew the fuse after you changed the regulator, then it is likely that you haven't installed it back correctly. Check all your wiring carefully, and if it still does it, then you need to buy a service manual and compare what you have done to what the manual says. If you cannot solve it, then you will need to take it to an auto electrician.
I have an ezgo electric golf cart and I have now replaced the 60 amp link fuse that connects to the battery and black wire. When driving the golf cart just quits and when checking the fuse is blow. Th
This is not a car question, but generally speaking a fuse blows when the current in the circuit exceeds the limit of the fuse.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
Why does my golf cart blow out?
How to Fix Golf Cart Blowing Out (White Smoke) White smoke usually means your engine is running hotter than normal. If there’s a bit of smoke when you’re just starting the cart, it might just be the cart warming up. Excessive amounts of white smoke might mean there’s a problem with your cooling system.
Why does my golf cart spit?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
Why does my carburetor spit gas?
Problems with the timing chain in your cart might also be making your carburetor spit gas. If you have a timing belt that jumps, it’s probably causing your gas spitting problems. Jumping belts are more common when you have plastic camshaft timing gears rather than metal timing gears. Lastly, bad reeds can lead to gas spitting.
How to fix gas spitting from valve cover?
Here’s what you can do to fix gas spitting from the valve cover. Replace the needle in the carburetor or replace the whole carburetor. The other thing that’s likely to cause gas to spit from the valve cover of your cart is your carburetor float being stuck open. This is simple enough to fix.
Why is my cart blue?
It might be a leaking valve which could lead to fires in your engine. Blue smoke might be caused by damaged rings in your engine. Check if the rings in your cart engine are busted and if they are, do a ring job and replace them.
What to do if your golf cart is spitting gas?
Lastly, if your golf cart is spitting gas, you may need to replace your air box. A relatively common problem is getting replacements that aren’t the stock air box for your cart. Something that most people don’t know or forget about is that if you’re using aftermarket filters, you absolutely must reset your carburetor.
How to fix smoke in a cart?
Fill your engine with the correct amount of oil. If your carts muffler has oil in it, it will blow out smoke. If you’ve got this problem, run your cart hard on a long run to the oil out of the muffler. You can also just switch out your muffler with a new one to solve this problem.