gas golf cart stops when it gets hot

by Cleo Roob Published 3 years ago Updated 2 years ago

It looks like the service manual says that you need to check for a shorted wire in the kill circuit. Seeing that your golf cart runs fine until the engine is hot I think your problem is either the new coil or the RPM limiter. Both can cause the engine to lose spark and stop running when hot.

Full Answer

Why is my electric golf cart not turning on?

Nov 06, 2019 · Oct 31, 2019. #4. It looks like the service manual says that you need to check for a shorted wire in the kill circuit. Seeing that your golf cart runs fine until the engine is hot I think your problem is either the new coil or the RPM limiter. Both can cause the engine to lose spark and stop running when hot. V.

What to do if your golf cart keeps cutting out?

Why does my golf cart stall when I accelerate forward?

Why EZGO TXT/RXV golf cart hesitates when accelerating?

Assessing the Batteries. Checking the batteries first before checking out the MCOR or the V-Glide can sometimes save you a lot of trouble and time if the problem is indeed with the battery. Check the batteries. Sometimes, one or both of the batteries could be dead making the cart cut off.

Why does my golf cart go then stop?

In some cases, this happens because the coil of the battery is worn out or is too old. It can also be a sign of a faulty battery or even loose connections within the solenoid. Additionally, you could be dealing with overheated contacts. This is an issue you need to take seriously.Oct 29, 2018

Why did my gas golf cart stop working?

First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.Feb 24, 2016

How do you keep a gas golf cart running?

Push the throttle cable toward the throttle valve body on the engine from the gas pedal position. Screw the throttle cable back in place on both the gas pedal and the throttle valve body on the engine. The golf cart will idle rather than shut off.

Do gas golf carts get hot?

Golf cart wires will get hot when you are driving them. This is caused by the resistance in the wires. They should not be too hot to touch for a period of time. If they are, then you may need to check your terminals to make sure they are clean and not causing excessive heat.Nov 6, 2020

How do I know if my golf cart solenoid is bad?

If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.

How do you test a fuel pump on a golf cart?

A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.Jun 20, 2013

How do you adjust the governor on a Club Car gas golf cart?

Part of a video titled How to remove governor on a Club Car golf cart - YouTube

0:04

0:46

You open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.

How do you adjust the carburetor on a Club Car golf cart?

Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.

How do you adjust the carburetor on a EZ Go golf cart?

2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.Feb 25, 2021

What happens if a golf cart overheats?

motor burnt-out

Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you're trying to drive a race car.Feb 12, 2018

Why is my cart overheating?

Carts get hot because electricity travels through the coil, turning your oil into vapor. The coil can reach temperatures of 300 °C / 570 °F or higher. While the outside of the tank won't get this hot, the heat is fairly concentrated and can make your device feel warm.Apr 16, 2021

How do you cool a golf cart engine?

Re: Golf Cart Motor overheating

The guys that race (very high speed) electric and also 2 stoke Radio Control boats use water to cool the motors / engines. Try some small diameter copper tube around the outside of the motor, one end is under water facing forward, the other exits behind.Mar 26, 2011

Why does my golf cart keep powering off?

If the cart starts powering off after a new installation, then you will know that the issue is caused due to errors with the installation.

What happens if you charge your golf cart?

You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.

What does the first beep sound on a cart mean?

The manual will have the list of beeps and their respective fault codes. The first beep sound will indicate the performance factor.

How to check battery water level in golf cart?

How to Check Battery Water Levels in a Golf Cart. Check if the voltages in both the batteries are at the designated levels. Also, if the water in the batteries has dried up, it could cause this issue. Check for the electrolyte and water levels in the batteries. Make sure that you are not overcharging or undercharging your batteries as these could ...

Why does my cart have a loose solenoid?

If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch.

What causes a cart engine to die?

If your cart engine dies suddenly, it may be the carburetor causing the issue. Read the following steps to fix it:

Why does my golf cart cut out?

Another reason why golf carts can cut out is due to problems with the battery voltage or water levels.

Why does my EZGO golf cart hesitate?

The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt. In case it has worn out too much, you can replace the carburetor.

Why does my golf cart stall?

The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. Batteries have lost charge. Faulty ignition. Problem with the direction switch. Faulty speed controller. Bad solenoid. The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.

How to check for leaks in golf cart?

You can check for any leaks by following these steps: Crank up the golf cart and check every seal for leakage. You can also spray wd40 at the clutch to find leaks. When the cart becomes hot, the voltage also drops. So, make sure you provide enough voltage to the batteries so the cart can run.

How to check if a cart is stalling?

You can easily check that. Run your cart for a few feet and feel the temperature. The same loose ends can also cause the cart to stall. Check every connection inside the battery for proper connection.

Why does my cart stutter?

If you change the battery, change the charger as well; otherwise, the battery will keep running down. If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor.

Why does my golf cart stall when running forward?

If a golf cart runs in reverse, but stalls when running forward and accelerating, this indicates a faulty f/r switch.

Why does my golf cart spin out?

The brake bub will spin out when there is too much load to prevent any damage to the rear axles, causing the golf cart to stall on hills. Remove the covers from the rear wheel. Notice the castle nuts that are holding the hub to the axles. Apply the brakes.

Why is my starter not turning?

Is the motor turning? Only one fuse and the starter will not turn if it is bad. If the motor is not turning, make sure the belt is not slipping. If it is not slipping, make sure the engine will turn by hand. MAKE SURE KEY IS OFF BEFORE YOU PUT YOUR HANDS IN. If it seems free, you either have a weak battery or the brushes in the starter have worn out. I change at least 20 sets of brushes a year on Club Cars.

Is a golf cart considered an electric car?

There is a custom Golf Cart that looks like a Jeep and is considered an electric club car. If you get a chance there is a show called Barter Kings and one of the shows actually shows one. They are not cheap.

Golf Cart

Support for gas-powered and electric golf carts, sometimes referred to as golf cars or club cars after the Club Car Golf Cart brand.

3 Answers

The information in this link may be of some help in finding your problem. I realize that you have replaced the fuel pump but this link describes other factors which may be relevant

What does it mean when a golf cart solenoid goes bad?

Technically, in fact, a solenoid is a shape – a shape in which the length of something coiled is longer than the diameter of the coils. In engine starters, this refers to the smaller motor ...

Why do golf carts have solenoid?

The solenoid is simply there to allow electricity to flow freely to the controller and motor which will result in a running golf cart. RELATED: 4 Signs you need to Replace your Golf Cart Batteries.

How to check if a golf cart solenoid is silent?

On an electric golf cart, if the solenoid is silent – no clicking – use the setting voltmeter to DC volts using the 200 range. First, turn on the ignition while looking for a reading on the smaller terminals. If nothing is appearing, then press on the accelerator. If the needle doesn’t move, then the problem is not with the solenoid.

Why does my golf cart make clicking sounds?

On a gas golf cart, the most common symptom is the starter failing to engage – so the engine doesn’t turn over – while all you hear a series of very futile clicking sounds.

Why does my solenoid wear out?

Like any switch that relies on wiring, the solenoid could also just wear out due to overheating. This might cause it to fail to retrieve the pinion gear.

What happens when a starter turns over?

And it acts as a mechanical device that puts the starter pinion gear into position, so when the starter turns over it will be engaged with the flywheel just long enough for the engine to catch.

Why won't my solenoid click?

The solenoid might not be getting enough electricity to do its work – which could be caused by loose connections, a weak battery or the coil wearing out.