It looks like the service manual says that you need to check for a shorted wire in the kill circuit. Seeing that your golf cart runs fine until the engine is hot I think your problem is either the new coil or the RPM limiter. Both can cause the engine to lose spark and stop running when hot.
Why won’t my golf cart start?
The first time I tried to use my golf cart and it wouldn’t start, I was lost trying to figure out what to do next. I learned that there are symptoms to watch for and what to do to fix the problem. Your golf cart won’t start if there is a problem with the fuel, airflow, or electrical system.
How to troubleshoot a gasoline golf cart?
How Do You Troubleshoot a Gasoline Golf Cart? Spark Plugs. Let’s start with the spark plug. ... Is it all oily, fouled, or the gap bridged in any way? If this all... Fuel. Okay, the electrical system checks out and the engine still won’t start. Before screwing the spark plug back into... Air. Check ...
Why does my EZGO gas golf cart click but not start?
EZGO Gas Golf Cart Clicks but Won’t Start The reason why a Gas Golf Cart Clicks but won’t start is because the connector to and from the solenoid is either loose or corroded. Check the wiring for any damage or corrosion. If you find any then you’ll need to replace it.
Why does my Yamaha G22 golf cart not start but turn over?
There are many reasons why your Yamaha G22 golf cart doesn’t start but turns over. In order to diagnose the problem, follow these steps: Make sure you start with a good inspection of the fuel filter, the solenoids, fuel plug and key switches very well.
How do you start a golf cart hot?
InstructionsEnsure that power to the cart is turned on.Locate the two wires connected to the cart's ignition. ... Cut the wires and strip the ends.Touch the ends of the wires together to force the engine to turn over without turning the ignition.Secure the wires together with electrical tape.
What would make a gas golf cart not start?
First, try this: turn the key switch on, hit the accelerator, and check for a clicking noise. If you don't hear clicking, it's time to take a look at your cart's batteries. Make sure the battery is fully charged and the terminals are cleaned and secure. Next, see how the water level in the battery is holding up.
Is there a reset button on a gas golf cart?
The Simple Motor Reset Process Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state.
Why is my gas golf cart stalling?
The most common reason why your golf cart is stalling is due to a bad solenoid or a faulty speed controller. What is this? The solenoid wears out every time the gas pedal is pressed down. The solenoid gets pressed down to a thin plate.
Can a gas golf cart overheat?
A lot of slow moving around while playing a round of golf can overheat your cart engine. In this case, the motor as well as the controller are highly likely to get very hot.
Can you flood a gas golf cart?
Dirt accumulation in the fuel has been seen to be one of the most frequent causes of flooding in the golf cart. This is because the valve seat may not have sealed correctly in order to shut off the fuel. Dirt inside your EZGO fuel can cause the the valve to malfunction, resulting in flooding.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my golf cart solenoid is bad?
Press on the accelerator while the key is turned on and the cart is in forward.The solenoid needs to be replaced IF the voltmeter shows a full battery voltage without a click.If your voltmeter stays at 0, the problem stems from somewhere else in your cart.
Why do golf carts overheat?
One of the most common reasons for the overheating is the dirty fins. The obstruction in the fins leads to excessive heat. The best solution, in this case, would be to first try to clean them, if that does not work, get them replaced. Another common reason for overheating can be the dragging breaks.
Why does my golf cart go then stop?
In some cases, this happens because the coil of the battery is worn out or is too old. It can also be a sign of a faulty battery or even loose connections within the solenoid. Additionally, you could be dealing with overheated contacts. This is an issue you need to take seriously.
What causes a golf cart to just stop running?
When a Golf Car is shutting off without warning, it's because of low battery voltage, dead batteries, or because the solenoid coil is overheating. Low battery voltage: Sometimes a dip in the minimum voltages of both batteries causes the Golf Cart to turn off randomly.
How do you check the voltage regulator on a gas club cart?
Testing the voltage regulator on a gas Club CarConnect the voltmeter to the battery and get the golf cart running. ... Check if the voltage rating is between 14 volts and 16 volts. ... Use a jumper and connect it from the ground of the cart to the stud of the starter generator.
Why won't my EZGO golf cart start?
EZGO golf carts may not start due to a transmission problem, corroded battery terminals or a faulty wiring coming from the ignition. Transmission Problem For safety reasons, many EZGO golf carts won’t start if its transmission is not in the Park position. Check and make sure the gear is in the Park position.
Why is my golf cart ignitor failing?
The most common reason for a failed ignitor is a bad voltage regulator. Therefore, when you replace or fix the ignitor on your golf cart, make sure you also check the voltage regulator and see if it needs to be replaced. There have also been cases where the battery has switch polarity for some reason.
What to do if replacing ignition wire doesn't work?
To check the continuity of the ignition wire you’ll need to use an ohmmeter or a continuity tester. To do this, set the switch to off and set your ohmmeter to X1.
Why does my golf cart make a clicking noise?
When you press your golf cart pedal you should hear a clicking noise, if you don’t hear a clicking noise there might be a problem with the solenoid. To make sure your solenoid is functioning properly check it with a voltmeter. If you hear a click then you need to check its power with the voltmeter.
How to check if golf cart battery is corroded?
Also, make sure the golf cart is turned off. Start checking the battery by twisting the battery connector back and forth and then try and start the golf cart. If the golf cart almost starts or starts successfully then it’s highly likely that the battery terminals are corroded.
Why won't my EZGO RXV move?
Brake Problems: Many times the reason your RXV won’t move is because of brake problems. The RXV is designed to be disabled when there is a problem with the break. Many times, the wiring that connects the brakes to the controller gets loose or is damaged. This can disable your EZGO RXV.
Why won't my golf cart start?
Faulty brakes: Very often, faulty brakes are the reason why a golf cart won’t start. You should be able to adjust the breaks at home. However for more complicated repairs, it is better to pay a visit to your nearest professional mechanic.
Why does my golf cart keep turning but not starting?
Solenoid problems: A solenoid can wear out after using your golf cart regularly. A faulty solenoid can cause your golf cart to turnover but not start. Your golf cart solenoid is a coil of wire cylindrical in shape, but in reality it functions as magnet carrying electricity.
What happens when a spark plug is taken out on a Yamaha golf cart?
You can check the oil for a possible contamination of gas.
Why won't my Club Car Precedent Golf Cart start?
Club Car Precedent golf cart turns over but won’t start. A faulty spark plug, bad battery or low compression levels are the main reasons why a Club Car Precedent golf cart will turn over but not start. Lack of spark in the coil: in this case, you have to replace the coil if it doesn’t spark. Spark plug: Also look whether ...
Why is my golf cart starting with a key switch?
Key switch problems: Keyswitch issues is a common cause of golf cart starting problems as the key switch will wear out over time. You have to check the keyswitch area for any loose or broken piece of wiring. Be very careful while doing this since you might get a nasty shock.
What to do if golf cart doesn't start?
If you find any moisture, you have to replace the plug. If the golf cart doesn’t start, you will want to clean the carburetor with some cleaning fluid. You can also take a look at the fuel bowl to check if it’s empty. If not, open and drain it.
Can a Yamaha G2 golf cart start?
Yamaha G2 golf cart turning over but not starting. A good spark, air and gas is usually sufficient to get a Yamaha G2 golf cart started. But if it’s not, then check out for a crack in the spacer of the carburetor. Next check if the ignition coils are connected to the two wires that are there. Then check for spark.
Why is my golf cart starting with a bad starter generator?
You might even find yourself stranded once it fails to turn over the motor and start your golf cart. The starter generator generates current for the cart to operate on. It relies on the electromotive force supplied by the battery.
Why won't my golf cart turn over?
A golf cart starter generator will not turn over due to low battery voltage, misaligned rotation or mechanical damage to the pulley and brushes. Although you may not be able to identify the exact reason, failure to turn the motor over could be due to any of the three reasons mentioned here. Low Battery Voltage.
How does a starter generator work?
The starter generator generates current for the cart to operate on. It relies on the electromotive force supplied by the battery. It consists of a coil of wire, which when moved produces a current in the coil. The coil is connected to the main axle of the cart for the necessary movement of wires. The starter generator doesn’t just generate current ...
How to tell if a golf cart starter is bad?
The following are four common symptoms that of a bad golf cart starter generator. Turning the Key Doesn’t Turn the Cart On. This can happen if either your cart’s battery or starter generator is out of order. Check if the lights on your cart are working. If yes, then it’s a bad starter generator.
What does it mean when your cart lights are not working?
Check if the lights on your cart are working. If yes, then it’s a bad starter generator. If no, then something is wrong with your cart’s battery. If your cart is taking longer than expected to start cranking, then you probably have a bad starter generator. This might happen due to a battery issue as well.
Why is a starter generator important?
It’s critical in charging the battery, starting the car, powering carts’ lights and also serve as a limited power source when needed. Identifying whether your cart’s starter generator has gone out of order or your cart’s battery is not working, is often a tough task.
