What causes a golf cart to jerk?
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
How do I know if my electric golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
Should you charge a golf cart after every use?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
What are the symptoms of a bad solenoid in a golf cart?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do you diagnose a golf cart problem?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
How do you test a club car MCOR?
To test the MCOR, look for the line item that says THROTLE. With the cart in neutral, slowly depress the gas pedal. You should verify that the throttle moves from 0% to 100% in a smooth manner. If you see it jump around (ie.
How can I make my club car go smoother?
To address each of these issues and smooth out your golf cart's ride you will need to:Replace Any Worn Out Shocks. ... Fix the Faulty Tire Pressure. ... Change Your Golf Cart's Oil & Oil Filter. ... Replace Worn Out Suspension Bushings. ... Fix Any Problems With Your Cart's Lift Kit. ... Add a Lift Kit to your Golf Cart.
Where is the micro switch on Club Car?
2:1211:27Replacing Mircoswitches on Club Car DS - YouTubeYouTubeStart of suggested clipEnd of suggested clipTop and then I'll come right off and our micro switches are underneath. That all right we got theMoreTop and then I'll come right off and our micro switches are underneath. That all right we got the cover of that fuse box removed. And we can see our micro switches right.
How often do you add water to golf cart batteries?
After charging your battery is when you want to add water. Adding water after charging prevents acid from spilling over. You'll want to add water to 1/2 inch from the top of the battery. 2) We recommend service once or twice a year.
What happens if you overfill golf cart batteries?
If you overfill golf cart batteries, the electrolyte (sulfuric acid) can leak out and cause a dangerous acid spill. If this happens, the acid can corrode metal and other materials in the surrounding area.
Can I leave my golf cart plugged in overnight?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
What happens if your golf cart clutch is bad?
If the clutch is bad, you could experience some jerking movement during the start or stopping stage of the golf cart. Consider getting the clutch checked and possibly replaced if any issues are there. This should help resolve the problem of the cart jerking when accelerating or taking off.
Why are my front tires bouncy?
If you do not use your cart much and it stays idle for weeks at a time, it could cause the tires to go out of shape due to the weight of the cart.
Why does my golf cart bounce?
One of the common issues associated with the golf cart bounce is the tire. If the tires are not aligned properly or the threading has worn out, it could cause the cart to bounce.
How to fix a cart that is wobbling at high speed?
Consider replacing the springs with harder ones . This could help solve the issue of the cart wobbling at high speed.
What is a MCOR?
Every cart has something called an MCOR (Motor Controller Output Regulator). It is part of the pedal assembly and can be found under the foot pedal. By removing the floor mat, you can access the foot pedal assembly unit.
How to get a bouncy cart back to its original shape?
You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart.
Why does my clutch jerk?
Well, the issue could be related to the clutch. The primary clutch weights could be broken, which might be causing the jerks. It would be a good idea to get your clutch checked to help resolve the problem. Another cause of this issue could be the accumulation of dirt or dust particles in the clutch.
Why is my Yamaha G1 golf cart shaking?
Yamaha G1 golf cart shaking. The Yamaha G1 golf cart is shaking due to a bad fuel pump, dirty carb, low compression, and bad clutch. To fix the Yamaha golf cart G1, you should check the fuel pump and engine oil of the golf cart G1. Check the quality of your engine and replace it if you have used this for a long time.
Why does my EZGO golf cart shake?
In most cases, the EZGO marathon golf cart shakes while starting due to tire issues, brake issues, and bad suspension. It may be due to excessive water enters into the components and loosely connected wires.
Why does my Ezgo RXV shake?
The golf cart Ezgo RXV shaking issues that occur in your golf cart may be due to worn steering parts, loose lug nuts, and loose wheel bearings. This may be due to brake drums and tires. To fix the issue, check the steerings of your golf cart. If it’s worn, then replace it with the worn steering parts.
Why does my golf cart jerk?
The golf cart may cause a jerk because of the solenoid issues. You need to check the voltage reading (normal range or not) of the solenoid. If the range is more or less than the normal range, then replace this.
How to check golf cart tires?
Check the tire’s height, and both tires need to place in the same position. Remove the tires and clean them if there are any particles stuck in them. Check the engine of your golf cart, steerings, and solenoids. Install a new tire if it needs, and then go for a test driving.
Why does my golf cart shake when starting?
If your golf cart’s clutch is in bad condition, it may be cause jerk and shake during the starting and stopping stage.
How to fix a golf cart?
To fix the issue, you have to check your golf cart’s adaptor and resistor, check all its components, and repair and replace the components that need replacement.
How many volts does an Ezgo golf cart have?
Have an ezgo electric golf cart. Have 36 volts at batteries.
Is JustAnswer responsible for posts?
Disclaimer: Information in questions, answers, and other posts on this site ("Posts") comes from individual users, not JustAnswer; JustAnswer is not responsible for Posts. Posts are for general information, are not intended to substitute for informed professional advice (medical, legal, veterinary, financial, etc.), or to establish a professional-client relationship. The site and services are provided "as is" with no warranty or representations by JustAnswer regarding the qualifications of Experts. To see what credentials have been verified by a third-party service, please click on the "Verified" symbol in some Experts' profiles. JustAnswer is not intended or designed for EMERGENCY questions which should be directed immediately by telephone or in-person to qualified professionals.
How to fix club car precedent?
You can fix a Club Car Precedent that jerks when taking off by checking and fixing the MCOR and batteries. These are the two key parts that often cause the jerking action.
Why does my club car jerk in reverse?
Your Club Car golf cart jerks in forward and reverse due to a sticky drive clutch or a high gear solenoid problem. A missing cable between the resistor and the forward/reverse selector can also cause the jerking in both directions.
How to fix jerk on 1985 club car?
If you have a 1985 Club Car, the jerk can be curbed by doing a high gear solenoid replacement. The solenoid will be in ON position when the cart moves both in forward and reverse directions. This solenoid is present on the passenger side of the golf cart.
How to fix a club car DS that jerks when taking off?
You can fix a Club Car DS that jerks when taking off by correcting the oil level. The following steps help to solve the jerking in 1988 lifted Club Car DS. Check the oil level of the golf cart and do a refill if needed. There is no need to overfill the oil. It’s enough if you fill it to just the required level.
How to fix jerky acceleration on club car?
One way to fix the jerky acceleration on a Club Car golf cart is to check if the battery charge is dropping and the battery is nearly dead under load. A load test will help you determine this. If recharging the batteries doesn’t help, getting a new battery or new batteries fitted should work.
What causes a 1994 Club Car DS to jerk?
In a 1994 gas Club Car DS, check out for a sticky drive clutch that causes the jerking in both directions. A simple rebuilding of the drive clutch will stop the jerks.
How to stop a high speed solenoid from jerking?
Look out for a stuck high-speed solenoid that sticks when it’s in the closed position. Getting this released will stop the jerking. If the solenoid has an internal connection in the ON/OFF position, it must be replaced.
