Sometimes when you jump golf cart solenoid (hit the start), the solenoid clicks but nothing comes from it. The reason is the burned contacts or contacts not connecting. Not enough voltage is also a common reason due to a low battery; These are the major symptoms of a bad solenoid on a golf cart. How to check solenoid if you own a gas golf cart?
Full Answer
How to fix a golf cart solenoid that won’t start?
Connect the two high side large wires to the large terminals of the solenoid. Try to start the golf cart after establishing this connection. If the cart does not start, then it is a clear sign that your solenoid does not have a problem. However, if it does, this does not indicate that the solenoid is the cause of the problem.
Where is the solenoid on a gas golf cart?
Usually, solenoids are located under the seat or just above the motor. Symptoms of a Bad Solenoid on Golf Cart Different signs indicate the presence of bad solenoids in electric or gas golf carts. For a Gas Golf Cart
Why is my electric golf cart not turning on?
On an electric golf cart, the most common symptom is the solenoid is not delivering electricity to the controller when the vehicle’s ignition is turned on. In normal operating conditions, the solenoid clicks on and off with the ignition switch.
What is the purpose of the switch on a golf cart?
The switch is responsible for sending out the low power signal to the solenoid. The solenoid, in turn, forms the circuit between the starter or generator and the battery to get the cart up and running. Where is the Solenoid Found on a Golf Cart?
Why does my golf cart jerk when I accelerate?
Why does my Club car golf cart jerk when accelerating? The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch.
What causes a gas golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
What causes a golf cart to jump?
Jerking electric golf carts are probably more common than a jerking gas model. That's because most “jerking” concerns are caused by battery issues or a poor flow of electricity from the battery to the cart. Typically, you'll start to notice this problem when your cart needs to charge up.
What causes gas golf cart hesitation?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt.
Why does my gas powered golf cart backfire?
The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.
What causes RPM surge?
If an engine is not getting enough fuel (this is called “running lean”), due to fuel pressure (regulated by the fuel pump and regulator), restricted fuel injectors, a vacuum leak or really anything that throws off the fuel mixture going in to the engine, this can cause the surge.
How do you fix a bouncing golf cart?
You can try driving the cart for a few miles to warm up the tires. This will cause them to get back to their original shape and help resolve the issue of the bouncy cart. You can try turning the tires one by one after jacking up your cart.
Where is the reset button on golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
How do you fix hesitation when accelerating?
0:589:09How To Fix Engine Hesitation During Acceleration - Easy Fix! - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo let's take a look at all the different things that can cause edge. And hesitation duringMoreSo let's take a look at all the different things that can cause edge. And hesitation during acceleration. First pertains to air intake. Systems number one is a dirty air filter causing.
What causes intermittent engine hesitation?
An engine that is hesitating to accelerate is most likely dealing with a fuel/air mixture that is too lean. Engine's that are running inefficiently will begin to show signs like hesitation which will only become worse over time.
Why does my golf cart not accelerate?
The main reason why a golf cart won't accelerate is because of bad solenoid, weak battery or faulty speed controller.
Why does my golf cart have no solenoid?
Golf cart solenoids are also typically one of the first components to fail in your golf cart, because they work very hard, turning on and off every time you stop and go in your golf cart. If you have an issue with no start or no go then your solenoid should be pretty high on your list of things to check.
What is a solenoid on a golf cart?
A solenoid, for our purposes, is a type of relay. A relay is a type of switch that uses a low power circuit to operate a high power circuit. A solenoid uses a magnetic coil (the actual solenoid) on a low power circuit to push a rod that closes a high power circuit. On your golf cart, this high powered circuit is either your ignition on ...
What is a golf cart go switch?
On your golf cart, this high powered circuit is either your ignition on a gas golf cart or your electrical motor power circuit for an electric golf cart. Basically it’s your golf cart’s go switch, and it’s absolutely essential to your golf cart’s ability to do its job. Golf cart solenoids are also typically one of the first components ...
What happens if a solenoid reads infinity?
If it reads infinity or open lead, then the solenoid has an internal fault and requires replacement. Your solenoid should also have a range that it operates in, and if the resistance reads outside of that range, you should replace the solenoid even if it works to avoid damaging other components.
What is the most important part of a golf cart?
One of the most important components of your golf cart is the solenoid. It is one of the main components of your golf cart that allows it to move. Whether you have a Yamaha, E-Z-GO, or Club Car golf cart, and no matter if it is an electric or gas golf cart, you need a properly operating solenoid to get anywhere. Contents [ show]
What to do if your solenoid doesn't work?
Before you run out and get a solenoid, you’ll have to test the entire ignition system this way to find out what’s not working, and it is a bit of a pain.
What is a micro switch on a gas pedal?
This switch is what sends the low power to the solenoid. The solenoid uses this to create a circuit between the battery and the starter, thus starting your motor and getting you grooving.
What is a solenoid in a golf cart?
A golf cart solenoid is one of the major components of any golf cart. This part is essential regardless whether you own an electric or gas golf cart because both types primarily rely on a solenoid for their movement. What this means is whichever brand or model you choose for your cart, a solenoid is truly an indispensable part of the vehicle.
Why does my gas cart not turn over?
In a gas cart, a bad solenoid prevents the starter from being engaged and therefore results in the engine not turning over.
What is a solenoid wiring diagram?
A solenoid wiring diagram can be very helpful in guiding you about the various connections made to and from the solenoid. This can come in handy when you set out to troubleshoot a problem in your cart on your own. The solenoid wiring diagram is generally very simple, straightforward and self-explanatory.
How to get a golf cart going without a glitch?
To get your golf cart going without a glitch, you most definitely need the solenoid of your cart to be functioning properly. Thus, it goes without saying that you must check this component occasionally to monitor its performance so that you don’t get stranded mid-way.
What does the inductive throttle sensor do on a golf cart?
When you push down the pedal of the golf cart downwards, the inductive throttle sensor sends out the first low power signal to activate the solenoid on its low side and the speed controller. The low side is the steel rod of the solenoid.
How often do solenoids work?
Since solenoids need to work very frequently; turning on and off each time you use the cart, they are prone to wear and tear easily. This is not surprising as they can switch on and off as much as 1,500 times a day). One of the first indications that a solenoid is faulty is when your cart fails to start.
Why is my golf cart not clicking?
This may be because the safety reed switch is not working properly in the charger socket. There could be a loose connection of the MOLEX plug.
How to tell if golf cart solenoid is bad?
One of the most common and obvious signs of the bad solenoid is the golf cart's failure to start when you initiate the ignition process. Once you click the accelerator and turn on the ignition switch, it is supposed to send a signal to activate the solenoid and start the cart. If the cart does not start, there is a big possibility ...
What is a solenoid in golf carts?
Simply put, a solenoid is a device that can transform electrical energy into mechanical energy. It's a coil of wire which is used as an electromagnet. The solenoid has the capability of creating a magnetic field with the help of an electric current. Solenoids work as the “go switch”, which is a must for any golf cart.
Why is my golf cart not starting?
If the cart does not start, there is a big possibility of a damaged solenoid. Another reason for a bad solenoid is that the contacts are starting to get damaged due to overheating or high current passing through them. Note: You may not necessarily experience all of these issues to recognize bad solenoids on your golf cart.
Why won't my golf cart turn over?
For a gas golf cart, the most common symptom is the starter failing to engage, so the engine doesn't turn over. Starters have the responsibility of activating the flywheel. When the flywheel starts to work, the starter is supposed to disconnect.
How to tell if solenoid is bad on golf cart?
The common symptom of a bad solenoid is no clicks when the cart’s ignition is on and you press the accelerator.
How to test golf cart solenoid?
A diode allows current to run in one direction, but not in the other. Testing the diode is a simple procedure. Remove the diode from the circuit and check the leads with a continuity tester.
Why doesn't my golf cart solenoid click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What to do if your solenoid is not zero?
If the reading is not zero, then the solenoid is stuck and needs to be replaced. If the ohmmeter does read zero, set the cart to forward travel and turn the key switch on. Press the accelerator pedal (or have a friend do it) and you should hear a click. If you don’t hear a click, measure the resistance anyway.
How to check if a battery is low?
First, follow these steps: Step 1 – Check the battery voltage from the positive connection to the battery negative. A solenoid uses 12-18volts and low voltage will not activate the solenoid. Step 2 – If the voltage is low, check the cable ends for corrosion. Clean and charge the battery.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. Now, on to the next symptoms…. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting.
Where are the solenoids on a golf cart?
In all golf carts, new and old, the solenoids can be found under the seat or in the engine well and are easily identifiable by the wires that lead to them. Banks of heavy duty solenoids, as in the previous illustration, are mounted on the side or back panel near the electric motor.
How to Tell if a Golf Cart Solenoid is Bad
Many golf cart owners had solenoid problems and delay as a result of them. To examine and repair a golf cart, you must first know what a solenoid is.
What Happens To Your Golf Cart When The Solenoid Goes Bad?
The large contacts in a gas golf cart may refuse to release, causing the starter to run even after turning off the ignition. Furthermore, the springs that pull the gear back to its resting state may start to break down, making the starters remain disengaged all of the time. (Starters are designed to get the engine running, then disconnect.)
How Do You Test A Golf Cart Solenoid?
The following steps will tell you how you can test a golf cart solenoid.
Can You Replace The Solenoid On A Golf Cart?
Changing the solenoid on your golf cart is normally easy, but you need a few types of equipment and a basic understanding of how the system operates. The ignition circuit connects to the solenoid, in the engine bay. When turning the key, the solenoid acts as a switch, energizing the ignition coil and igniting the fuel-air mixture.
How Often Does A Golf Cart Solenoid Go Bad?
Your solenoid is prone to overheating as a result of its regular use. As a result, you may notice irregular operation after a while — it may work one time, but not the next. Loose cables or dusty interiors could cause your cart’s inability to start.
Solenoid – why do golf players use it?
Before explaining what are symptoms of a bad solenoid on a golf cart, let’s clarify its definition and purpose for golf players.
What are the symptoms of a bad solenoid on a golf cart?
There are a few signs that a golf cart has problems because of a bad solenoid. You may have even one of these signs detected to become worried. Don’t ignore the following symptoms of a bad solenoid! Ignoring these issues will only make them worse and worse. For instance, a bad solenoid may result in buying a new starter.
How to check solenoid if you own a gas golf cart?
If you suspect the symptoms of the bad solenoid on a gas golf cart, the major problem is usually related to the failure of large contacts. The starter may continue working, even with the ignition turned off. Make sure to check the spring – it shouldn’t be worn down, to pull the pinion back to the neutral position.
How to check solenoid if you own an electric golf cart?
There are certain symptoms of the bad solenoid on an electric golf cart. The lack of any clicking noise when starting the cart’s ignition. The clicks must be heard each time when you switch on and off the ignition. If you don’t hear any clicks, then the solenoid may no longer send electric power to the golf cart.
A step-by-step guide to check a golf cart for a bad solenoid
GolfProfy.com is a website where I post articles for golf players. Every review is supported not just by experience but also includes the tips and opinions of my friends who specialize in golf equipment or techniques. For instance, my friend who is a golf cart technician for a few years wrote this instruction for checking a bad solenoid:
The simplest way to bypass solenoid on a golf cart
If you don’t have a voltmeter and you don’t intend to invest in it, there is another way how to bypass solenoid on a golf cart. Just attempt connecting two large wires of terminals of the solenoid. Then attempt to operate the cart. If it doesn’t work, the solenoid is not your problem. Test the entire ignition system.
Final thoughts
Remember that solenoid is one of the cheapest parts for replacement. Though, without checking and replacing it you risk having a malfunctioning or completely broken golf cart. Make sure to consult experts on how to bypass solenoid on a golf cart before trying it on your own.