The OBC shuts down the cart functions while the charger is connected to the receptical to prevent driving off with the charger attached. You can also try resetting the OBC, which normally involves removing the negative battery cable, putting the cart in reverse and holding the accelerator until the reverse buzzer goes out.
Why is my golf cart accelerating sluggish?
A faulty or failing solenoid could be the cause of your golf cart’s sluggish acceleration. It handles getting battery power to your starter, the golf cart’s generator, and the traction motor. Solenoids can fail more frequently on an electric cart than a gas powered one. A speed controller controls the golf cart’s speed and acceleration.
How do you turn the wheels on a golf cart?
Jack up the rear of the cart and turn the key switch on. With the car in the forward gear, depress the accelerator so the tires and wheels are spinning greater than half speed. Then, slightly depress the brake.
How to fix a golf cart that won’t start?
To fix the issue, you have to check your golf cart’s adaptor and resistor, check all its components, and repair and replace the components that need replacement. You should also check the clutch of your golf cart. If the clutch is in terrible condition, then you should replace it before it causes severe damage to your golf cart.
Why is my Yamaha golf cart shuddering?
The Yamaha golf cart shuddering issue occurs due to bad cable connection, low battery pack, and damaged solenoid. The CV joints are placed at the end part. If the CV joints are loosely connected and damaged, then it may cause shuddering. If you recently install a new tire in your golf cart, then check whether it’s aligned correctly or not.
Why does my golf cart jerk when I accelerate?
Why does my Club car golf cart jerk when accelerating? The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch.
Why does my electric golf cart hesitate when I accelerate?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
Why is my gas golf cart sputtering?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
What causes a golf cart to sway?
When you lift your golf cart, the tire size also increases, which is why lots of inconveniences can occur, including over-swaying. It happens because after lifting, generally, the weight of the backside becomes higher than the front side.
What are the symptoms of a bad solenoid in a golf cart?
The most common side effect on a gas golf cart is the starter failing to connect, resulting in the engine not turning over and a succession of useless tapping sounds. If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure.
Why does my electric golf cart surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
What causes sputtering on acceleration?
One of the most common causes of a sputtering engine is an issue with the vehicle's fuel system—the filter, pump, and injectors. These three critical components work together to ensure fuel flows smoothly from the fuel tank to your engine's fuel injectors, and then pumps into the engine evenly.
How do you fix an engine sputter?
A sputtering engine may just mean you need to have your fuel filter replaced. All vehicles have a series of vacuum hoses that create the fuel pressure. If one of them leaks or is damaged in any way, you will lose significant fuel pressure. The vehicle's exhaust system can greatly impact the engine's performance.
What causes sputtering and backfiring?
If your engine is getting more fuel than it needs, a rich fuel to air ratio is the result. When your car has leftover fuel in the exhaust and the cylinders, that fuel explosively burns and creates a loud popping sound. Specifically, here we mean delayed timing, which causes the backfire.
How do you adjust tie rods on a golf cart?
Loosen the tie rod on the driver's side wheel and adjust the toe in by twisting the rod left or right depending on the direction you need to adjust the tire. If you need to adjust the tire inwards (towards the front of the cart) then turn the rod towards the rear of the cart, which will turn the tire in.
How can I improve my golf cart suspension?
How To Make A Golf Cart Ride Smoother (10 Ways)Correct Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
How do I align my EZ Go golf cart?
3:003:54EZGO RXV Toe-In Check - YouTubeYouTubeStart of suggested clipEnd of suggested clipWell as that we had another successful day here at the garage checking toe it on our rhv. Don'tMoreWell as that we had another successful day here at the garage checking toe it on our rhv. Don't forget to Like and subscribe and also for our your parks accessories DIY golf cart calm.
Why does my electric golf cart go slow uphill?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why is my golf cart running slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
Why does my golf cart not accelerate?
Bad Solenoid If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my ezgo golf cart going so slow?
A EZGO RXV and TXT golf cart can run slow because of a faulty speed sensor, low battery charge and insufficient levels of water in the battery. A problem with the speed sensor. A faulty speed magnet. One or more batteries could are weak and don't have sufficient charge or the water level could be low.
What happens if your golf cart doesn't accelerate?
Bad Solenoid. If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why is my golf cart not accelerating?
When your electric golf cart does not accelerate, the first thing you need to keep in mind is that it is not a regular vehicle like your car . That's why the methods and solutions you use to get your car to start are not the same as the solutions you can apply to your cart.
Why is my golf cart speed controller not working?
There are many reasons behind a speed controller malfunction. The most common problem that happens in the controller has aged due to infrequent use. These are just some of the issues that could be affecting your vehicle's acceleration. If you have trouble finding the issue of your golf cart accelerator, don't be afraid to take it to the mechanic.
How does a golf cart solenoid work?
The golf cart speed controller and solenoid are both controlled by the accelerator. The pedal is connected to the potentiometer. That means when you are pressing the pedal for acceleration, you are actually going through the potentiometer by pushing a rod. The potentiometer works as a communicator and tells the speed controller how much voltage it ...
What is a speed controller?
Speed Controller. The speed controller manages the speed of the golf cart. There are some situations when the speed controller fails, but the cart will still start and move ahead. But, as it runs for a while, it will start malfunctioning.
Safety Notice
Before attempting any maintenance or repairs on your golf car it is imperative that you consult the owner’s manual and follow all the safety guidelines. The following are a few safety tips, but may not be all inclusive.
Check Battery Terminal connections
The most common reason for your golf cart jerking is often the battery terminal connections are loose and/or corroded. A poor connection prevents the correct amount of current from flowing through the set of batteries to your speed controller (or resistor coil), and ultimately to your electric motor.
Check Battery Voltage
Once you’ve cleared all the battery terminals of corrosion, you’ll next need to check that your batteries are providing the correct amount of voltage. This can be accomplished using a simple voltmeter.
Check Resistor Coil (For Older 36V Golf Carts)
If you have an older 36V golf car that doesn’t use a speed controller, and you’ve completed all the steps above and your golf car is still jerking in set to forward, but works fine when the direction is changed to reverse you may have a bad resister coil.
Why do my wheels shudder when I drive?
Since wheels produce heat when they rotate, the wheel bearings keep the heat under control. But if you have loose wheel bearings, there will be heat and instability in the wheels. This instability will cause car shuddering as you drive.
Why does my car shake when I accelerate?
5 Causes of Car Shudders when Accelerating. Under normal driving conditions, your car does not shudder or shake when accelerating. You have a suspension system which keeps the shaking and vibrations to a minimum. This system allows there to be a smooth driving experience for both you and your passengers. That is why any kind of shakiness that ...
Can your car's axles get bent?
But there are situations where your axles may get bent. If you normally drive your car over rough roads and bumps, the axles could suffer some damage as a result. Eventually, there will be a lot of shuddering whenever you accelerate the vehicle if the axles get too bent.
Why do lug nuts come off when driving?
The vibrations of your driving will cause them to slowly work their way down. If all of your lug nuts are loose, or even just a couple of them, the situation could become dangerous and the tire could actually come right off your car while you're driving.
What happens if your car drives smoothly?
If the car drives smoothly after that, then it's very likely you had a leak somewhere in the line. That also means you may not have fixed the problem, since you could still very well have a leak and the fluid will continue to drain out, but at least you know where to look now.
Why does one part of my tire wear out faster than the other?
One part of the tread will wear out much faster than the other meaning that your tires are not evenly hitting the road at all times . It's possible a quick visual inspection could let you know this is an issue if you're noticing that the tread on one part of your tire looks much thicker than the tread on another part.