Why is my golf cart sputtering and sputtering?
The golf cart’s filter, pump, and fuel injector may be filthy, thus causing the sputtering. Other than that, a dirty mass airflow sensor can cause your golf cart to sputter. Water mixed with your cart’s gas can also cause it to sputter and spit, as this reduces the gas’s volatility.
What are the symptoms of an electric golf cart not starting?
On a gas golf cart, the most common symptom is the starter failing to engage – so the engine doesn’t turn over – while all you hear a series of very futile clicking sounds. On an electric golf cart, the most common symptom is the solenoid is not delivering electricity to the controller when the vehicle’s ignition is turned on.
How to start a golf cart with a bad ignition?
Find the ignition wire on your golf cart. This runs from your ignition switch to the starter solenoid. Check this over for corrosion on either end and make sure you’ve got a tight connection. If the connections use a spade lug, pull the connection loose, wipe off the terminal, and plug it back in again. Try to start the cart now.
What should I do if my car sputters when I start it?
Before screwing the spark plug back into the engine, put a couple of drops of gasoline down the hole first, or use some engine starter fluid. After the spark plug has been replaced, turn the engine over and see if it even tries to kick off. If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor.
Why does my electric golf cart jerk?
Jerking electric golf carts are probably more common than a jerking gas model. That's because most “jerking” concerns are caused by battery issues or a poor flow of electricity from the battery to the cart. Typically, you'll start to notice this problem when your cart needs to charge up.
Why is my golf cart backfiring through the carburetor?
The golf cart backfires through the carburetor because of an open throttle plate. The accelerator cable at the scale is out of adjustment and, in turn, stops the vessel from closing when the microswitch makes contact with the ignition.
What causes a golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
Why is my 2 stroke golf cart backfiring?
In almost all cases, whether it is a 2 cycle or 4 cycle engine, golf cart backfiring is caused by the accelerator cable being out of adjustment at the throttle plate of the carburetor. This problem has a relatively simple cure.
How do you adjust the carburetor on a EZ Go golf cart?
2 Cycle engine: The adjustment screw is on the side of the carburetor and is parallel to the ground. You can identify it by the lock nut at the base of the screw. Loosen this and turn the screw all the way into a soft seat, then back it out one and a half (1-1/2) turns.
How do you adjust the carburetor on a Club Car golf cart?
Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.
Why do golf carts shake?
The common cause of golf cart vibrates when accelerating due to damaged inner CV joints, broken motor mounts, unbalanced tires or a bent driveshaft. To fix this issue, you should check the CV joints of your golf cart.
How do you stop a Yamaha golf cart from backfiring?
One simple way to stop the golf cart from backfiring is to use good quality fuel. Once this is done, ensure that the throttle plate is closed by adjusting the accelerator cable at the plate.
How do you clean a golf cart muffler?
How to clean golf cart muffler:First spray the inside of the muffler using the chamber cleaner.After a few minutes, scrub inside the golf cart muffler with the help of a brush.Place a container under the muffler to keep the carbon particles that come out from the golf cart muffler.More items...
How do you adjust the throttle on a golf cart?
Pull the spring that is present around the plastic piece located behind the shifter. Spin it until it falls back. Loosen the throttle cable present in the cable box to adjust the extent to which you can take it out of the housing. Press the accelerator so that the golf cart starts up and begins to idle.
How to tell if a golf cart won't start?
The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops ...
How to tell if a golf cart is bad?
Symptoms Of A Bad Solenoid 1 The first and most obvious symptom is the golf cart won’t start. If it is a gas-powered cart, the engine doesn’t turn over, and if it is an electric cart, the cart doesn’t move. 2 The engine on the gas-powered cart starts, but the starter doesn’t disengage after starting. When the contacts weld together, the power to the starter never stops and will result in destroying the starter, the wiring, or the flywheel. 3 The relay clicks and works sometimes, and sometimes it doesn’t. This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. 4 The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid. 5 The golf cart solenoid clicks, but nothing happens. This will sometimes be the result of burned contacts or contacts no longer coming in contact with each other as shown in the illustration at the bottom of this page. This can also be the result of not enough voltage amps reaching the solenoid control connection due to a low battery.
Why does my golf cart not click?
This can be a faulty wire connection, but can also mean the solenoid is beginning to fail. The golf cart solenoid doesn’t click when the accelerator is pressed. This again can be faulty wiring or a failed solenoid.
What causes a car to start when the spark plug is replaced?
If it sputters and tries to start, then the likely culprit is the fuel pump followed by the carburetor. The fuel pump on most gasoline powered carts usually has three hoses going to it.
How to check if a gas cart battery is charged?
First, you turn the key, press the pedal, and listen for a click. If nothing happens, it’s most likely an electrical issue. On gasoline carts, check the battery that turns the engine over to make sure it is charged. On Electric carts, the battery pack should be checked for a full charge.
What to do if a gas cart key switch fails?
There should be a reading or continuity between any combination. If this is a gasoline cart, set the switch to “ON” and take a reading between the terminals. There should be continuity. If the key switch fails any of these tests, it’s worn out and should be replaced.
How to adjust a golf cart?
Adjustment is made by loosening the nut or screw, pressing the throttle closed, and then retightening the nut. Some golf carts may not have accelerator cables but instead will have a series of rods between the gas pedal and the carburetor.
What is the ignition system on a golf cart?
Older golf carts used a set of points and a condenser to produce the spark needed to run the engine, but the more modern carts have a solid-state ignition system . The solid-state system utilizes an internal magnetic pickup device inside the engine that sends an electrical signal down the line to the igniter.
What happens when the throttle cable is out of adjustment?
When the throttle cable is out of adjustment, the throttle plate never completely closes, allowing unburned gasoline to accumulate in the exhaust system before the spark plug fires. Here are a few tips for adjusting your golf cart engine to keep it from backfiring.
Why is my throttle plate not closing?
If none of these accelerator cable adjustments solve the problem, then the throttle plate may not be closing all the way due to an obstruction or internal mechanism being bent. Unfortunately, the only way to find out if this is true is to remove the carburetor and inspect it.
Why does my golf cart backfire?
Golf Cart Backfires Because Fuel Mixture Is Too Rich. Always check the air and fuel ratio to make sure your engine is not receiving too rich of a fuel mixture. The following adjustments are an example of most carburetors, but you should look up the proper number of screw turns your model requires.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... Continue Reading.
How long does it take for a muffler to burn off?
It sounds crazy, but the common method of un-coking a muffler is to remove it from the cart and barbecue it over a fire for about half an hour. This will burn off all of the debris inside the muffler and turn it to ash.
Why Is My Car Sputtering When I Start It?
There are many possible reasons why your car is sputtering. To know each of them, we have listed them below for your enlightenment. Keep reading.
Car Sputters When Starting Then Dies: What To Do?
If you are experiencing that your car is sputtering and then starts to die, you should immediately check for your engine. But, first, you need to rectify the problem at hand so that there will be no significant damages to your vehicle. Here are the things you can do if your car is sputtering and starting to die.
Car Sputters When Starting And Idling: What To Do?
You have to check for your spark plugs. Inspect if they are in good condition and if they are working correctly. There can be problems with your spark plugs, and you might be burning the fuel, or some fuel injectors are leaking.
Summary
In summary, you will experience when your car is sputtering. If your car is sputtering when you turn them on and then dies, there can be some possible reasons. You have to check immediately what the issue is.
Resources
My name is Hank, and I've been in the automotive industry for 27 years. I've been working in my own auto repair shop for the last 13 years, and now I want to help you here, on my blog. Let me know if you have any questions. Read more
Why does my club car shudder in reverse?
Answer: The “shuddering in forward but seems to run fine in reverse” is a very common issue with the 36-volt resistor coil for Club Cars. The reason for this is this system uses all the batteries for forward and only four for reverse. First, you will need to check for any loose or bad battery cable connections.
How to check if a battery is bad?
First, you will need to check for any loose or bad battery cable connections. Second, conduct a load test on the batteries one at a time . This will determine if a bad battery is an issue. To perform this test: Jack up the rear of the cart and turn the key switch on.
