Full Answer
How to drive a golf cart safely?
Here is a complete guide to golf cart safety including a few essential tips to always keep in mind. 1. Keep all arms and legs inside the vehicle. It can be tempting with open-air setups to stick extremities out. If the vehicle is driving to close to something else, it can lead to disaster.
Why is my golf cart so bumpy?
Too high a pressure makes the cart ride bumpy while too low pressure causes the cart to drag. Rotating the tires occasionally for uniform use is a good idea. To confirm if your shocks need to be changed, get on to the bumper of the cart and push it down three to four times continuously.
What are the most common problems with golf carts?
One of the common problems found in golf carts is a constant whining noise during the ride. This noise is usually found coming from the rear end and would seem to originate from one of the parts at that end.
Are your golf carts intermittent no go?
Having fixed golf carts for 35 years, the one thing that most golf cart mechanics dislike is the Noise, or Intermittent “no go”. Let’s look at how you can help to diagnose these issues. Let’s Start with Noises in Your Golf Cart.
What causes a golf cart to jerk while driving?
A Club Car golf cart jerking from the front end of the golf cart occurs due to poor quality of tires. If the tires are worn out or loose, the golf car can start jerking. The uneven height of your front tires can also cause jerking.
Why does my electric golf cart jerk when accelerating?
The most common problem here is likely an issue with the batteries. If the battery is low on power or doesn't distribute power properly, then the cart may jerk as it accelerates. Thankfully, replacing the battery should be a good enough fix to manage this problem without difficulty.
What causes a golf cart to surge?
A golf cart can be surging due to insufficient fuel levels, damaged motor brushes or a vacuum leak. The brushes in the motor are damaged or worn out. The MCOR is malfunctioning or a mismatch between the motor and controller results in torque bumps.
How do you stop a golf cart from bouncing?
You can easily take care of this problem by deflating your front tires until the sidewalls of your cart are about 1/2 the front walls. This should help get the beads seated. Now, you can inflate your tires back. The bounce should have disappeared.
Why does my electric golf cart stutter?
If your cart seems to run fine for a few feet, and then it stutters, it is most likely the batteries. If it is not the battery, then check if it is the speed controller or the resistor. If it is the controller, then you will need a replacement. Otherwise, upgrading the resistor can also solve the problem.
Why does electric golf cart sputter?
Golf carts can spit and sputter for several reasons, but mainly due to worn out spark plugs or dirty filters inside the fuel system. There might be something wrong with the fuel system of your cart. You could be having a spit and sputter problem because the filter, pump and injectors in your golf cart are very dirty.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
How do you diagnose a golf cart problem?
There are a few simple problems that you can fix yourself that will not necessitate professional maintenance.Test the wall socket where you charge your cart. ... Expose your golf cart batteries. ... Test the batteries for voltage. ... Replace dead batteries. ... Expose the motor for inspection. ... Reset the motor. ... Test the cart.
What is a golf cart MCOR?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
How do I make my golf cart run smoother?
How to Make a Golf Cart Ride SmootherCorrect Tire Pressure. ... Replace Worn Out Shocks and Struts. ... Check the Fluid and Filter. ... Replace the Clutch. ... Flat Spot in Tire. ... Tire Damaged or Out of Line. ... Worn Out Suspension Bushings. ... Check Your Lift/Tire Combo.More items...
How can I make my golf cart more stable?
Drop Spindle kits are used to replace and increase the golf cart spindle size and length. This can give your golf cart a wider stance, and increase the stability. The wider stance is perfect for those looking to fit those big off-set wheels on your cart, which in turn, can allow you to add wider and taller tires.
Why does my golf cart rides rough?
Your golf cart ride can be rough because of tire problems, suspension problems or issues with the transmission. Tire Problem: Incorrect air pressure and wrongly aligned tires are two key tire-related problems that can trigger rough golf cart rides.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
What does the MCOR do on a golf cart?
Club Cars use an MCOR throttle device. This translates your foot movement at the pedal into electric impulse that the motor controller reads. MCOR stands for "Motor Controller Output Regulator".
How do I know if my golf cart solenoid is bad?
If your golf cart fails to turn on when you turn the key on, this is the most obvious sign of solenoid failure. The solenoid clicks a little with the ignition system in regular operation; in most cases, a failing solenoid will not snap.