Generally, a golf cart not charging is a result of the loss of power from the wall outlet to your charger, an issue with the voltage of your battery pack, the charging receptacle is faulty, or occasionally, the issue is with the golf cart charger itself.
Why is my golf cart not charging?
- It would be advised to have a multi-meter to check your battery pack voltage and the individual battery voltages.
- You will have the possibility of 3 different voltage batteries: 6-volt, 8-volt, or 12-volt.
- You’ll plug your golf cart charger into the wall and the cart and leave it in there.
How far will golf cart go on full charge?
Originally Answered: How far will a golf cart go on a full charge? By comparison a gas golf cart tank usually has a 6 gallon capacity and this will enable you to travel approximately 250 miles. An electric cart will go between 25 and 40 miles depending on your battery configuration.
How long should you charge golf carts?
The following steps can help you with your golf cart battery maintenance. Charge the batteries continuously for 8 to 10 hours, preferably overnight, using a compatible charger. This ensures that the batteries have at least a 20% charge when you charge the next.
Is golf cart insurance worth it?
It may seem like yet another thing you need to pay for, but the bottom line is that golf cart insurance is something to consider if you own a golf cart. Most major insurance providers offer golf cart insurance or golf cart riders to your existing home insurance policy at a reasonable cost.
How to reset a golf cart motor?
What to do if battery terminals are dirty?
About this website
How do you reset a golf cart charger?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
How do you force a golf cart battery to charge?
Drive the golf car for an extended period of time so the batteries will discharge, plug the golf car charger in again and repeat this cycle for about 3 or 4 times. Each time will increase the battery charge and golf car run time.
How do I know if my golf cart battery charger is bad?
Bad Charger: IN GENERAL, if the charger kicks on, but doesn't charge fully or kicks off soon after, this is likely a charger issue. If the charger makes a loud clicking noise, this is likely a battery charger issue.
How do you check the voltage regulator on a gas club cart?
Testing the voltage regulator on a gas Club CarConnect the voltmeter to the battery and get the golf cart running. ... Check if the voltage rating is between 14 volts and 16 volts. ... Use a jumper and connect it from the ground of the cart to the stud of the starter generator.
What do you do if your golf cart won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
What do you do when your golf cart batteries won't charge?
3:335:42How to Charge Dead Golf Cart Batteries Manually | Golf Cart GarageYouTubeStart of suggested clipEnd of suggested clipAnd see if it begins charging for you. While this doesn't always solve charging. Issues low batteryMoreAnd see if it begins charging for you. While this doesn't always solve charging. Issues low battery power is the most common reason that chargers fail to operate.
How do you check a golf cart charging system?
1:103:54Golf Cart Charger Troubleshooting Guide | ASK DAVE | Golf Cart GarageYouTubeStart of suggested clipEnd of suggested clipTest good first off the most common issue when a charger doesn't engage is dead batteries golf cartMoreTest good first off the most common issue when a charger doesn't engage is dead batteries golf cart chargers start automatically by receiving voltage from your cart.
How do I test my golf cart charger?
Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.
How do you test a golf cart diode charger?
To adequately test a diode, you must remove the transformer wires from them, as this can skew your results. With your multi-meter set to the diode function, or just simple continuity, press one probe to the end of the diode where the wire was and the other probe to the portion near the heat sink.
How do I know if my voltage regulator is bad on my golf cart?
How to Check If the Voltage Regulator Is FaultyMajor electrical components such as the dashboard or lights will start fluctuating or dimming. ... The battery becomes drained, even though no electrical component was left on. ... The engine will start experiencing problems such as stalling or a lack of constant acceleration.More items...
Is there an alternator on an electric golf cart?
Moreover, the battery for a cart does not recharge itself as the vehicle runs like batteries in cars do (cars have alternators). Therefore, regular use will drain the battery which, in turn, may shorten its life.
What charges the battery on a gas golf cart?
Gas golf cart accessories will also rely on battery power. However, they feature a starter/generator that will charge the battery on its own while the gas pedal is depressed. This doesn't mean a gas golf cart battery is invincible – any accessories left on while the cart isn't running will eventually kill your battery.
Find A New Golf Cart Battery Charger Or Batteries
1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...
Troubleshoot An Old Golf Cart Battery Charger & Batteries
1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...
Golf Cart Charger Questions
1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...
Golf Cart Battery Questions
1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...
EZGO Golf Cart Electric will not run - DoItYourself.com
Motorcycles, Snowmobiles, Go-Carts, Motorized Bikes, ATVs, Electric Mobility Scooters and Golf Carts - EZGO Golf Cart Electric will not run - The batteries are fine, fully charged giving me a voltage of about 38v. I arced across the solenoid and the cart moved. It was working fine until it was parked. Father-in-law
SOLVED: Push Pedal nothing happens - Golf Cart - iFixit
Yesterday I pulled up to my ball and hit it and then got back into the cart and it wouldn't go anywhere when I press the pedal I have a 2000 ezgo electric golf cart.
Why is my charger clicking?
If the charger is clicking while plugging it in, and doing nothing, examine your charger and probably replace it . If the “brain” of the charger fails , then it can cause several issues, and the batteries will not charge. Purchasing a new one or repairing the component can solve the problem.
Why won't my club car golf cart turn off?
A Club Car golf cart will not shut off if the OBC is outdated or faulty. In this case, the reason depends on whether the charger is not shutting off when it is plugged into the device , or it is not plugged in but still not shutting off.
What is the OBC on a 48V club car?
In the 48V club cars, the OBC is primarily responsible for the batteries’ charge. It controls the batteries charging, which is why the 48V requires a fully functional OBC all the time. Connect the batteries to a voltmeter and check if the charger is generating enough power.
What happens if your golf cart battery is low?
If the water level of the batteries is low, then the blade inside it will be dried, and you won’t be able to recharge your battery. Charging problems of golf carts are not something new. It can be quickly resolved. All you need to do is to examine the cart thoroughly and immediately replace the faulty parts.
How to keep car batteries charged when idle?
Try to keep specific chargers, which will help your batteries to stay charged even when the car is idle. Enough power supply is critical to keep the charger working and keep the batteries charging. Check your connections, and then turn on your charger.
What does it mean when a charger is bad?
Bad charger: if the charger turns on but there is no sign of charging. If the charger is making noises like a loud click, before kicking off. If the charger keeps charging even after turning the switch off then, without any doubt, it’s time to replace the charger.
What is the problem with my 2007 golf cart?
But to bypass the OBC, you will need a smart charger. There are three wires at the back of your cart’s charger connection- a large black wire, a large red wire, and the small wire.
Why is my golf cart battery charger not working?
Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.
What wires are needed to charge a golf cart?
Only the red and black wires are needed to completely charge the golf cart. The blue wire is an optional safety wire. If hooked up to the motor controller it will not allow you drive the golf cart while charging it. Think about being at the gas pump and driving off with the pump still in the car.
What is an OBC on a club car?
When you plug the charger into your Club Car, the OBC will tell the battery charger when to start and stop charging based on the voltage levels in your batteries.
What voltage do you need for a 36V golf cart?
You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.
Why is my golf cart charging red?
Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above).
How many volts does a golf cart battery need?
An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my charger making a clicking noise?
If the charger makes a loud clicking noise, this is likely a battery charger issue.
How many volts does an EZGO 2012 hold?
Check the battery pack voltage using a multimeter. For a 48-volt cart, this should be between 46 to 50 volts based on the charge level.
What is a reed switch?
The reed switch is malfunctioning or not working at all resulting in a charger receptacle failure. This is a magnetic switch present in the receptacle that serves as the input for the solenoid activation circuit of the cart. If your cart has a triangle-shaped plug, there is no reed switch for the receptacle.
How to check if golf cart battery charger is faulty?
The charger may be faulty. Check this by plugging the charger into the golf cart and see how much it charges the battery pack using a digital voltmeter. Alternatively, you can use another charger to do the charging and see if there is a difference. Allow the charger to charge the pack fully and shut down on its own.
Why won't my Ezgo golf cart charge?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it’s free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
How many volts should a golf cart battery pack have?
Charge two batteries at a time with a 12-volt charger and then use the auto golf cart charger to resume the charging. The battery pack must have at least 28 volts for the cart charger to be able to kick in. Also, ensure that the battery plates have at least 1/4 inch of distilled water above them before charging.
Why is my Ezgo cart not charging?
It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries. A charger problem can also be associated with the charger making a loud clicking noise, failing to stop charging after the batteries have attained full charge ...
How many volts should a 48 volt battery be?
Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart. If the reading is abnormally low such as 16 volts or 24 volts, check the voltage of each battery individually by hooking on to a regular charger. Also, check the water level in each battery.
What does a red light on a battery charger mean?
Others have indicator lights to let you know. For example, a red light might mean that the battery still needs to be charged while a green light usually indicates it is fully charged.
How long does it take to charge an electric golf cart?
It can take anywhere from 3 to 10 hours to fully charge your electric golf cart. This is assuming the battery is nearly discharged. The exact time it will take depends on the age of your batteries and the type of charger you use. Generally, you can expect older batteries to take longer to charge (5+ hours).
Where is the charging plug on a golf cart?
Connect charging plug to the cart’s charging outlet – the charging outlet can be located on the exterior of the cart or underneath the seat. Leave the charger connected until the battery is fully charged – not allowing your battery to fully charge might reduce its lifespan.
How do you know if you are oxygen deficient?
Early warning signs that you’re in an oxygen-deficient environment include headaches, shortness of breath (dyspnea), dizziness, and nausea. If too much time is spent in this environment, asphyxiation can result. Second, hydrogen at high concentrations (4-7%) can be extremely explosive.
Can you overcharge a golf cart battery?
If you frequently run your cart until the battery is nearly dead, it will damage the battery and can significantly shorten its lifespan. On the other hand, it’s important not to overcharge your electric golf cart battery as repetitive over-charging can also lead to battery damage.
Can you charge a golf cart with a generator?
Most people choose to use a simple wall outlet from their home. If your golf cart is usually stored somewhere where this is not an option, you can also use a generator. ***Make sure you charge your cart in a well-ventilated area.
When is Wired2Golf 2021?
March 4, 2021. February 21, 2021 by Ivan Boychuk. Wired2golf.com is a member of Amazon Associates and other affiliate programs. As such, we earn a commission from qualifying purchases through links on this site at no extra cost to you.
What does it mean when a cart is insufficient power?
Insufficient cart power means the cart has a dead battery. The charger needs some signal from the cart to detect whether the device needs any voltage or not. When the battery goes dead, it fails to transmit the signal. As a result, the charger does not start charging the battery.
How many volts does an EZ Go golf cart have?
An EZ-GO golf cart will come either with a 36-volt or a 48-volt battery function. The cart will come with different charging receptacles, depending on the model that you have.
What happens when you plug in a charger?
When you plug in the charger, the charger will automatically decide whether the batteries require additional voltage or not. If the battery does, the charger will start charging the battery. But if something is wrong with the cart or the charger, the charging process may not start.
Why is my EZ Go charging?
Most EZ-GO golf carts charging problem tends to happen because of insufficient cart power, loose or damaged wiring, and charger malfunction or damage. An EZ-GO charger should function automatically if everything is okay with your cart. But if you face trouble while charging the battery, there must be something wrong with your golf cart or ...
What does it mean when a charger does not work?
If the charger does not operate automatically, these are the three primary issues that maybe are causing the problems-. Insufficient cart power. Insufficient cart power means problems with the dead batteries.
Why is my charger connector loose?
Securing or checking whether the cart has a loose connection or not can be another way of solving the problem. Bad weather, corrosion, rust, and debris are the most common reasons for developing a loose connection.
How long to charge two 6 volt batteries?
Charge each battery for a maximum time of five to ten minutes and then move to the next one.
How often should you charge golf cart batteries?
Golf cart batteries should be kept fully charged at all times – this means hooking them up to a charger as soon as you are finished using the cart. Regular charging will prevent damage to the battery and give it longer-lasting life.
Should golf cart batteries be charged after every use?
Yes. Charging your golf cart batteries after every use – even if you’ve only spent five minutes driving – is crucial for maximising their lifespan. Leaving batteries in a prolonged state of low charge can decrease their capacity over time and wear them out quicker.
Should you charge new golf cart batteries?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
Should your golf cart be turned on when charging?
No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you’re trying to charge it. A golf cart should only be turned on once its batteries are fully charged.
Should golf carts be plugged in all the time?
No, you should not leave your golf cart plugged in all the time. While automatic battery chargers are designed to shut-off once at full capacity, leaving a battery connected to power for long periods leaves it susceptible to damage should the electrical circuit be overloaded.
Should golf cart batteries make noise when charging?
If your golf cart uses a standard 12 volt flooded lead acid battery, then it is quite normal to hear a bubbling sound when it’s charging. However, if your cart uses a sealed battery (such as a gel or AGM battery), then a hissing or bubbling sound may indicate damage.
How long should golf cart batteries last?
If you play golf twice a week – and use your golf cart for each round – you can expect a standard, brand-new battery to last just under 10 years before needing to be replaced. If you charge your battery correctly after use, you can maximise its shelf life.
How to reset a golf cart motor?
Reset the motor. Remove a panel in the rear of the golf cart using a screwdriver. When the motor is exposed, search for a small red button. Most often, the button is located where the wires enter the motor. If the button is sticking out, push it back in.
What to do if battery terminals are dirty?
If the terminals are dirty, purchase a battery terminal cleaner spray and use it on the terminals then try to start the motor. The cleaner spray is available at auto retail shops and in most automotive sections of chain retail stores.
What happens if golf cart batteries are not charged?
If batteries are not charged over a storage period of several months, they can deteriorate and provide less capacity. When there are experienced and inexperienced owners asking the same question, you have to wonder if this question is being addressed by golf cart manufacturers and where the confusion surrounding the questions is sprouting from. ...
Why do golf cart batteries deteriorate?
The main reason would be a concern for the golf cart battery. Manufacturers recommend leaving your golf cart plugged in all of the time, but only if using an automatic battery charger. This will keep the batteries topped off and ready to go. If batteries are not charged over a storage period of several months, they can deteriorate ...
What type of batteries does a club car use?
They have produced carts with 48V lead-acid configurations and lithium ion batteries. However, the 48V lead acid carts are the most common. The Club Car guidelines for charging such a cart are as follows:
How hot should a Yamaha cart be?
The location of storage should maintain a temperature between 0 degrees celsius (32F) and 32 degrees Celsius (90F).
How cold should a golf cart battery be?
As we know, it is a pain to uninstall and reinstall golf cart batteries, my recommendation would be to make sure your golf cart is stored above 32 degrees F and keep them charged and maintained throughout winter. This will prolong their life and keep older batteries running for a long time.
Can you leave a battery charger plugged in?
The battery chargers can be left plugged in during prolonged storage, if the charger is plugged into an active electrical source. If the electrical source is not consistent, you should not leave the battery chargers plugged in , for the battery charger will automatically continue to address the battery pack.
Who makes electric golf carts?
The three major manufacturers of electric golf carts are Club Car, E-Z-GO, and Yamaha, and it seems most of the confusion surrounding the question at hand is their fault. Well, let’s not blame any of the three companies, but they are certainly responsible, for each of these three major golf cart manufacturers address the question differently.
How to reset a golf cart motor?
Reset the motor. Remove a panel in the rear of the golf cart using a screwdriver. When the motor is exposed, search for a small red button. Most often, the button is located where the wires enter the motor. If the button is sticking out, push it back in.
What to do if battery terminals are dirty?
If the terminals are dirty, purchase a battery terminal cleaner spray and use it on the terminals then try to start the motor. The cleaner spray is available at auto retail shops and in most automotive sections of chain retail stores.