Low water levels are caused by several things, the most common being overworking your cart. Overworking the battery causes overheating which results in evaporation, therefore lowering the water level of the battery. Batteries also lose water simply from the summer heat causing condensation and evaporation.
Full Answer
Why does my golf cart lose power after driving?
You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
Why do my golf cart batteries feel warm?
It’s quite normal for golf cart batteries to feel a little warm while in use or during charging. This comes as no surprise as a large amount of energy is being transferred when using your golf cart.
Does your golf cart cut out at high speeds?
Have you been experiencing any of the above issues with your golf cart? Some people have experienced these issues where the golf cart works properly at normal speeds, but cuts out when driven at high speeds. If your golf cart cuts out at high speeds, then you might have to take a look at the internal mechanism to figure out what the issue is.
What happens when a golf cart speed controller goes bad?
So a problem with the controller will have rippling effects throughout the cart. A common function of the speed controller is to control the speed of the golf cart. When this unit has failed, the golf cart will start up and possibly take off, without hesitation.
Why does my golf cart keep losing power?
For example, you must make sure that your batteries are fully connected to ensure that they are able to send power. If their connections are loose, the power flow may not be properly connected and may cause your cart to sputter and drive poorly as it rides, losing power and stopping sporadically during each trip.
Why is my gas golf cart losing power?
A faulty or broken carburetor is likely the most common triggering factor for serious issues with your cart's power problems. The carburetor helps to keep your cart cleaner in operation and manages many elements of your fuel in your cart.
Why does my electric golf cart hesitate when I accelerate?
In most cases, the hesitation problem occurs due to bad batteries. If you have bought new batteries for your EZGO RXV, make sure to fully charge them before the first use. Batteries should then be charged after every use. To keep the batteries in check, get a Digital MultiMeter to measure the individual voltage.
Why is my golf cart losing power up hills?
The Reason Your Electric Golf Cart Goes Slow Uphill? Your electric golf cart can struggle on inclines for a variety of reasons. Weak batteries, incorrect tires, and wear and tear to the motor and wiring are all potential causes of your cart's slow speed.
Why does my gas golf cart go slow up hills?
Tire Size – The size of your cart tires is another factor that may be impacting your speed uphill. The larger your tires are, the more work your carts needs to do to get uphill. Golf Cart Batteries – When it comes to challenges with your cart's speed, they are more often than not caused by an unruly battery.
How do you check the voltage regulator on a gas club cart?
Testing the voltage regulator on a gas Club CarConnect the voltmeter to the battery and get the golf cart running. ... Check if the voltage rating is between 14 volts and 16 volts. ... Use a jumper and connect it from the ground of the cart to the stud of the starter generator.
How do you fix hesitation when accelerating?
0:169:09How To Fix Engine Hesitation During Acceleration - Easy Fix! - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you do not have a diagnostic scanner. Then take the vehicle to an auto parts store which willMoreIf you do not have a diagnostic scanner. Then take the vehicle to an auto parts store which will normally perform this service for free engine hesitation is due to something that's become faulty.
What causes slow throttle response?
The dirtier a fuel filter gets, the harder it is for fuel to pass through. This causes a delay in acceleration and throttle response. This issue is so common that many auto technicians check the fuel filter first when they want to find out why a vehicle has a slow throttle response.
What causes poor acceleration?
What Causes Acceleration Problems? Hiccups in air and fuel delivery and sensor issues are the main causes of poor acceleration. However, mechanical issues can also be the cause of low power.
How do you remove the speed limiter on a electric golf cart?
0:000:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this leverMoreYou open up this box lap. Here. It looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
Where is the speed sensor on a golf cart?
The speed sensor in a Club Car Precedent golf cart is located on the back of the motor. To remove the sensor, unplug the cables behind the motor. You can use a 5/16-inch socket to remove the pigtail connector and pop off the plastic housing that encases the speed sensor.
How do I know if my golf cart motor is bad?
You have enough going on in your life without your golf car refusing to start when you turn the key in the ignition. If your golf car won't start, is slower than it used to be, or is experiencing other technical problems, you could have a bad motor on your hands.
Why does my golf cart keep powering off?
If the cart starts powering off after a new installation, then you will know that the issue is caused due to errors with the installation.
What happens if you charge your golf cart?
You would have charged up your cart fully but after driving it around for an hour or two, the power would have got drained off completely. If this is a frequent occurrence with your cart, then you will need to take a look at the batteries.
What does the first beep sound on a cart mean?
The manual will have the list of beeps and their respective fault codes. The first beep sound will indicate the performance factor.
How to check battery water level in golf cart?
How to Check Battery Water Levels in a Golf Cart. Check if the voltages in both the batteries are at the designated levels. Also, if the water in the batteries has dried up, it could cause this issue. Check for the electrolyte and water levels in the batteries. Make sure that you are not overcharging or undercharging your batteries as these could ...
Why does my cart have a loose solenoid?
If the connections from the solenoid have become loose or if there is some other loose contact, the cart might behave in this manner. It can also be caused by a faulty motor or a faulty key switch.
What causes a cart engine to die?
If your cart engine dies suddenly, it may be the carburetor causing the issue. Read the following steps to fix it:
Why does my golf cart cut out?
Another reason why golf carts can cut out is due to problems with the battery voltage or water levels.
Can a bad battery affect a cart?
Your batteries may have the proper voltage and may not hold a charge under load. Even one bad battery can affect the performance of your cart. You should also check the voltage drop while driving uphill. Get some alligator clip test leads and connect those between positive and negative connection your cart and your meter ...
Can a golf cart go uphill?
When golf cart gets just slightly below a full charge it will not go uphill. It will go on flat land. Battery voltage was a little low but batteries still tested good.
Why do electric golf carts fail?
These carts can start to show signs of wear and may fail just like any other vehicle over time.
What are the problems with electric golf carts?
These carts can start to show signs of wear and may fail just like any other vehicle over time. Learn about some of the more common issues associated with electric golf carts. 1. Solenoid Wear. The solenoid is the primary electrical switch in your golf cart and is designed to ensure the current from the battery flows into the motor. ...
What is the controller on a golf cart?
An electric golf carts' controller is known as the heart of the operation and closely resembles and operates much like the motherboard in a computer. So a problem with the controller will have rippling effects throughout the cart. A common function of the speed controller is to control the speed of the golf cart.
Why does my gas cart not work?
When you press down on the gas pedal and hear a tapping-like sound, this is the sound of the solenoid activating. When there is a disruption in the flow of the electrical current , your cart will not operate. A common reason for current disruption is solenoid wear.
Why does my gas pedal have a current disruption?
A common reason for current disruption is solenoid wear. Each time the solenoid activates as you press down on the gas pedal, the solenoid compounds down onto a thin metal contact plate. Over time, the force of this pressure creates tiny electric arcs on the plates' surface. These arcs eventually create a resistance that prevents the current from properly flowing.
What happens if your cart doesn't move?
If the cart doesn't move in either direction, both switches have failed. Diagnosing a problem with the direction switches isn't a complicated matter, but repairing the switch is more complex, especially if the switches are built into the speed controller.
Why won't my sped controller accelerate?
Problems with the sped controller occur for a variety of reasons, but most often the cause is degradation due to age or lack of use.