Take note of the way that the drive belt is wrapped around the primary drive clutch. Slide the new drive clutch onto the primary drive clutch in the same way the old one was placed. Then, pull the drive belt around the secondary drive clutch as much as you can and roll the secondary drive clutch in order to secure the belt in place.
Full Answer
How to change the oil in an EZGO golf cart?
How to change the oil in EZGO TXT golf cart. In every EZGO golf cart; there is an oil filter present presumably at the bottom of the vehicle. The oil filter needs to be removed so that you can successfully drain out all the oil from your vehicle. Pour in some diesel into the system and spin the motor for a couple of minutes.
Should I buy an EZGO or RXV golf cart?
As a result, an EZGO would be eroded over time, and its effectiveness might also be reduced. Thus, to fit your needs and also maintain the quality of your vehicle, you are recommended to try out the EZGO RXV golf cart.
How many hours can you drive an EZGO golf cart?
The limit of 125 hours is a direct implication on the fact that an EZGO vehicle must be used or operated for around 125 hours before its engine oil needs to be replenished. Purchasing an EZGO golf cart is considered to a one-time investment which can last for years.
Why is my EZGO golf cart losing top speed?
A loose drive belt can result in your EZGO Golf Cart to lose top speed and underperform. If the drive belt is the right model but it seems to be too loose then it could be because there is something stuck in the clutch or there is some damage in the clutch. In this case you’ll need to call a certified technician to inspect your golf cart.
How do you change a belt on a EZGO golf cart?
1:195:57Changing the Drive Belt and Starter Generator Belt 2008 EZGO TXTYouTubeStart of suggested clipEnd of suggested clipDrive belt to remove it all you got to do is kind of work it over the edge and then roll. Back.MoreDrive belt to remove it all you got to do is kind of work it over the edge and then roll. Back. Until it pops off that rear driven clutch and then take it right out.
How do you check golf cart belts?
0:152:00How to Check the Belts in your Gas Golf Cart | Golf Cars UnlimitedYouTubeStart of suggested clipEnd of suggested clipDown below and you don't want to press the moderate pressure on that belt you're gonna want to seeMoreDown below and you don't want to press the moderate pressure on that belt you're gonna want to see about 3/16 to 1/4 inch of deflection. There no more than that that'll be your proper.
How Loose Should a golf cart drive belt be?
The reason for a Club Car drive belt being too tight can be because the drive belt is too small for the golf cart. The way to check if the belt is fitted correctly is to push the belt down with one finger at the center between the clutches. It should not deflect more than 1.5inches.
How do you tighten the belt on a Club Car golf cart?
Slide the old drive belt off the front drive clutch pulley, and then the rear clutch pulley. Slip the new belt around the golf cart's clutch pulley, and then stretch it out over the front pulley. Pull the front pulley forward slightly to increase the belt tension, and then tighten the tension bolt with the wrench.
How tight should an EZGO drive belt be?
How Tight Should a Golf Cart Drive Belt Be? The drive belt should not be too tight. If it's too tight it can risk wearing off faster and it's also harder to shift gears.
How do you know if your engine belt is bad?
Symptoms of a Bad or Failing Timing BeltYou Hear A Ticking Noise Coming From The Engine. ... Your Car's Engine Won't Turn Over. ... You Notice An Oil Leak Near The Motor. ... You Experience Exhaust Issues. ... Your Revs Start Acting Up.
How do I know if my EZGO clutch is bad?
A sudden inability to maintain even slow speeds when heading uphill or changing elevation. Slowing down to a crawl, then speeding up, then slowing again, seemingly without reason. Jolting during startup. A 'cranking' sound when starting up the golf cart.
What are the symptoms of a loose serpentine belt?
Common signs include a squealing noise from the front of the vehicle, power steering and AC not working, engine overheating, and cracks on the belt.
Can I drive with a loose belt?
A loose drive belt can compromise your vehicle's ability to power accessories like power steering, air conditioning or your alternator, or could possibly even cause internal damage to the motor.
Why is my golf cart steering so loose?
The cause of loose steering on a Club Car golf cart is worn out tie rods, worn out bushes or loose kingpins.
How do you tighten up the steering on a golf cart?
Move the rack to one side by turning the wheel slightly in one direction. With the help of a large wrench, loosen the bottom adjustment nut on the golf cart. Tighten the middle adjustment nut with a flat screwdriver or an Allen wrench. On some carts, this could also be a screw or bolt.
How do I remove my EZGO TXT steering wheel?
2:425:38Golf cart steering wheel removal June 16, 2021 - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo so that puts pressure on it and i'm going to take a a hammer like this and normally when you tapMoreSo so that puts pressure on it and i'm going to take a a hammer like this and normally when you tap it a couple times enjoy it as you're putting pressure it'll pop off.
Why is my Ezgo golf cart belt so loose?
The reason your EZGO drive belt is too loose could be because it’s worn out, or you’re simply using the wrong size drive belt. In this case, need to find a replacement immediately. A loose drive belt can result in your EZGO Golf Cart to lose top speed and underperform.
Why is my EZGO drive belt so tight?
The reason your EZGO drive belt is too tight can be because you’re not using the right size drive belt. Check and make sure if you’re using the right one. A quick search online will give you the right information. It can also be too tight because the drive/driven clutch is misplaced or broken.
How to tell if golf cart drive belt is too tight?
To check if your drive belt is set just right make sure your golf cart is turned off then check the drive belt by pressing it down between the two clutches with your finger. If it deflects less than 1.5” it’s too tight.
How to stop a EZYGO drive belt from slipping?
How to stop a EZYGO drive belt slipping: Make sure that you have the right drive belt. Sometimes the wrong drive belt will not be as wide as the clutch you are putting it on. This gives it an unwanted room to move back and forth when you are using the golf cart.
Can you tighten an EZGO drive belt?
You cannot tighten an EZGO drive belt. If loose, you will need to replace the drive belt. There have been various people online who’ve tried to store it in cold room temperatures hoping it would contract and become smaller but this is not recommended. Putting your drive belt at extreme temperatures can damage it.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Can you adjust a drive belt on an EZGO golf cart?
There is no way to adjust a drive belt, so it’s important to get the right size belt in the first place. To be sure, visit your local mechanic or call a certified technician to help you get the right drive belt for your EZGO golf cart.
How to remove clutch on EZGO golf cart?
How to remove a secondary clutch on an EZGO golf cart. First of all, make sure that the golf cart is turned off, and the brake is in place. Make sure to put pressure on the gas pedal. Use a clutch puller to remove the drive belt. Loosen the central bolt using an air gun.
What to do if you have a problem with your G16 golf cart?
If there is any problem with the secondary clutch, it is best to replace it or the drive belt connected to it. If you are unsure about removing the drive belt or the clutch, then you can adjust it.
How to remove secondary clutch on Yamaha golf cart?
Just carefully follow the given steps: First of all, identify the right clutch puller according to the VIN number of the golf cart you are operating.
Why does my golf cart clutch slip?
There can be a problem with the drive belt, which can cause the clutch to slip. Sometimes the installed belt drive may not match the clutch in the golf cart, causing problems. Just replace it, and you are good to go. Check if the belt drive is misaligned. This is also a common problem with the clutch.
What is wrong with my golf cart clutch?
If there is any problem in how your golf cart runs, you can check for the following problems: There might be a problem with the belt. Check if the belt is too tight or loose.
How to find primary clutch on golf cart?
There are two clutches in the golf cart. To locate the primary clutch, it is generally the lower one. Consult the cart’s manual to make sure. First, observe exactly how the drive belts have been adjusted to the clutches. After you have noted that.
Can a golf cart slow down?
The golf cart may slow down and speed up on its own without any reason whatsoever. This is a very common problem, so do not take it lightly. The golf cart may face some problems while maintaining slow and even speeds while traveling uphill or on an incline.
What oil does an EZGO golf cart use?
The engine of a EZGO golf cart uses 10W-30 grade engine oil. This oil which can be directly poured in-car effectively at lower rates. The primary variants of EZGO golf carts run on electricity; however, there are a few variants that run on gas as well. The EZGO golf cart is primarily used in the community nowadays.
How long does an EZGO golf cart last?
The limit of 125 hours is a direct implication on the fact that an EZGO vehicle must be used or operated for around 125 hours before its engine oil needs to be replenished. Purchasing an EZGO golf cart is considered to a one-time investment which can last for years.
Does the Ezgo golf cart have an oil filter?
In every EZGO golf cart; there is an oil filter present presumably at the bottom of the vehicle. The oil filter needs to be removed so that you can successfully drain out all the oil from your vehicle. Pour in some diesel into the system and spin the motor for a couple of minutes.
Is the Ezgo Marathon fast?
The EZGO Marathon golf cart is usually very slow and is not capable of running faster, thus the name. However, these golf carts do have the reputation of being quite sturdy and sticking around for years without causing any problems to the owner or any technical issue in general.
