Club Car DS Turn the engine of the golf cart on and remove the gas cap. Keep a rag around the filler hole. Blow hard into the gas tank. You may have to do this a few times until the engine starts purring and the fuel filter has fuel in it.
Full Answer
Why does the fuel filter of the golf cart not stay full?
The fuel filter of the golf cart may not stay full because of a fault vacuum tube. Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full.
How do I identify my club car golf cart?
How do identify my Club Car Golf Cart? Pre-1981: Serial numbers on Club Car golf carts manufactured before 1981 will be located by raising the seat and locating the aluminum I-Beam frame section closest to the batteries on the driver's side of the cart *.
How to choose the right fuel for your golf cart?
Opt to buy fuel from stores that sell pure gasoline without traces of Ethanol. This is slightly expensive but a cheaper deal compared to when you have to replace damaged parts because of the rust deposits that occur in the fuel supply. Get a fuel stabilizer fitted for the smooth running of the golf cart engine.
How to clean the carburetor of a golf cart with fuel breakdown?
Fuel breakdown due to long-term storage 1 Unhook the gas lines from the golf cart. 2 Drain the fuel inside the fuel pump into an approved gasoline storage container. 3 Empty the contents of the carburetor. You can use this chance to clean the carburetor inlet.
Should fuel filter be full on golf cart?
Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, facing a glitch.
How do I know if my golf cart fuel pump is bad?
Fuel Pump Problems The simple answer is the engine doesn't run as well as it should. More specifically, you may have trouble with your engine at low speeds, or it may lose power at high speeds. If your clog is especially bad, the engine sputters to a halt or may not even start.
Where is the fuel filter on a golf cart?
0:464:11Yamaha Fuel Filter Replacement on Golf Cart | How to Install - YouTubeYouTubeStart of suggested clipEnd of suggested clipThanks right here on the seat passengers on running front of the fuel tank.MoreThanks right here on the seat passengers on running front of the fuel tank.
What causes gas golf cart hesitation?
The main reason why an EZGO Gas golf cart hesitates while accelerating, is because of a dirty carburetor. A dirty carburetor causes this hesitation. Regular cleaning can prevent this problem. Check the rubber boot and clean if you spot any dirt.
What are the signs you need a new fuel pump?
It's important to familiarize yourself with the warning signs of a faulty fuel pump—that way you can address any problems before it's too late.Engine Sputters at High Speeds. ... Rising Temperature. ... Fuel Pressure Gauge. ... Loss of Power When the Vehicle Is Under Stress. ... Surging. ... Decreased Gas Mileage. ... Engine Will Not Start.
What are symptoms of a bad fuel pump?
Is My Fuel Pump Going Bad? Here Are 8 Signs It Is!Fuel Tank Noise. A damaged fuel pump might make a loud, whining sound that you'll hear from your gas tank. ... Difficult Starts. ... Sputtering Engine. ... The Actual Stall. ... Power Loss. ... Surging Power. ... Lower Fuel Efficiency. ... Dead Engine.
How do you change a fuel filter on a golf cart?
0:100:48How to Change the Fuel Filter in your Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt points towards the carburetor. You're gonna do first we're going to loosen our clamps here on theMoreIt points towards the carburetor. You're gonna do first we're going to loosen our clamps here on the hose. We're gonna slide the hose off and then simply install the new filter.
How does a fuel pump work on a Club Car golf cart?
The fuel pump has several nozzles on it to accept the vacuum line, and both the Fuel In and Fuel Out lines. Inside the pump, there are several diaphragms which use the pulsing action created by the vacuum of the crankcase pressure to draw fuel from the storage tank and push it onward to the carburetor of the golf cart.
How do you test a fuel pump on a club car?
Club Car DSTurn the engine of the golf cart on and remove the gas cap.Keep a rag around the filler hole.Blow hard into the gas tank. You may have to do this a few times until the engine starts purring and the fuel filter has fuel in it.
Why does my golf cart not accelerate?
Bad Solenoid If your golf cart does not accelerate, there is a possibility of the damaged solenoid. The solenoid is basically an electrical switch that enables the battery's flow from the battery into the motor. Check out the signs of the bad solenoid.
Why does my golf cart jerk when I accelerate?
Why does my Club car golf cart jerk when accelerating? The main reason why a Club car golf cart jerks when you accelerate it is due to a misaligned Inductive Throttle Sensor or dirty clutch.
Why does my golf cart go then stop?
In some cases, this happens because the coil of the battery is worn out or is too old. It can also be a sign of a faulty battery or even loose connections within the solenoid. Additionally, you could be dealing with overheated contacts. This is an issue you need to take seriously.
What does DS stand for in golf carts?
What does DS stand for in Club Car golf carts? The Club Car DS model type, in production from 1980 to 2014, was named after Dom Saporito, a vehicle designer at Club Car in the 1980s. The DS model was named after Dom, thanks to his input in the design. Are gas golf carts better than electric?
Do club cars have VIN numbers?
Club Car Low Speed Vehicles (LSVs) have VIN numbers. Non-LSV Club Car vehicles do not have VIN numbers. Instead, serial numbers are used. The serial number of each vehicle is printed on a bar code decal mounted either below the passenger side cup holder or above the accelerator or brake pedal (Example: PH0901-123456, as shown, or F9901123456).
Why does my golf cart have a dirt filter?
Some of the possible causes are stated below: There could be dirt filled in the carburetor, potentially stopping the gas flow from the tank to the engine. If the air filter can be opened from the golf cart and around 2 ounces of fresh gas get drilled in to the pump, then the issue may get sorted.
Why is my golf cart not full?
The fuel filter of the golf cart may not stay full because of a fault vacuum tube. Please keep in mind that the overall operations of the golf cart do not get affected if the fuel tank stays half full. The fuel filter on both new and older EZGO carts may not stay full due to the vacuum tube which connects the crankcase and the fuel pump, ...
What is the G16 golf cart?
The G16 model of Yamaha golf carts suffers from the glitch of not receiving the required levels of gas, which ends up hampering the overall performance of the golf cart.
Why is my golf cart starving for fuel?
A golf cart can be starving for fuel because of old gas in the engine, or because the flow of gas to the fuel tank is blocked. If the engine was running smooth until a few days ago, then it can be presumed that there is no glitch with the engine. Some of the possible causes are stated below:
Why is my carb pump not getting sorted?
If the problem still does not get sorted, then chances are that the pump is faulty and the vacuum line has got clogged.
Why is my Yamaha G9 getting out of breath?
The Yamaha G9 has been recorded to be getting out of breath due to lack of enough fuel levels in the tank. Some of the reasons for the glitch along with possible solutions are stated as below: It may be that the air box is not sealed properly due to which air would enter inside the tank.
What happens if there is no air in the pump?
If there is no air in the pump, then fuel should be pumped at any cost. The hose should be taken off the carb which should give out fuel at every revolution on starter. If there is any sort of leakage detected, that would only end up multiplying the issue.
Do cart tires have air pressure?
Tire Pressure. · Please note that when cart tires are low on air pressure, they do not appear “flat” like car tires. You must use a pressure gage to insure that the tires area properly inflated. · Use caution when inflating tires. Due to the low volume of the small tires, over-inflation can occur quickly.
Should I plug a car charger in at all times?
Since the charger should be plugged in at all times, it is wise to protect it against lightening. · Batteries should be charged after EACH period of use, no matter how short you used it. · When plugging charger into car, verify that the ammeter needle moves to the right side of the meter window.
Can a car be plugged in?
Charging –Cars should be plugged in at ALL times, when not in use. This includes cars that are out of use. Cars that are not plugged in can self-discharge over several weeks and virtually “kill” the battery pack. · Connect your battery charger to a readily available surge protector outlet/strip.
Strut is leaking oil or shows physical damage
Most of the time if a strut is going bad it is because a seal holding the fluid (usually oil) in the shock starts to get old and starts to let the oil escape. This can often be discovered by a simple inspection of the shock. If it appears to be oily, wet or caked with dust and dirt, it is likely that the shock is leaking and needs to be replaced.
Golf cart is experiencing excessive body roll
Excessive body rolling is another indication of a strut going bad. This test can be performed by driving the golf car then turning the steering wheel so that the golf cart is tracing out an “S” pattern.
Bonus tip
If none of these tests or inspections reveal that your shock is bad, you may want to inspect the shock bushings. These are the rubber or plastic bushings at the ends of the shocks and also found where the leaf springs are bolted to the spring plates or brackets.
How many volts does a club car battery have?
If the OBC on the Club Car is functional and the batteries are above 35 volts, you should hear a "click" from the relay inside the charger when the round plug is inserted into the cart and the charger should come on and begin charging.
What is an OBC golf cart?
Since 1995, 48 volt Club Car's come with an OBC. The OBC is is a small device that is wired into the golf cart that’s purpose is to regulate the batteries charge. As you use and drive your golf cart, the OBC records the amount of energy consumed and then directs the charger to replace exactly the amount of energy needed to fully replenish ...
How to check if golf cart is charging?
First, check to ensure that your golf cart was charged before you took it out. Plug it back into the charger and follow the instructions. Just in case the charger is the issue, check that the battery charger is turned on. There should be an indicator light to show that it is charging the batteries. In the morning, disconnect ...
How to tell if golf cart battery is bad?
1. Charging Issues. First, check to ensure that your golf cart was charged before you took it out.
What hole does a golf cart stop dead?
It’s a real hassle if your golf cart stops dead and you’re only at the 15 th hole of play. Not only is this an embarrassing event, but it’s a major pain to have to arrange for the cart to be towed back to the parking lot.
Why won't my cart fire up?
But more often than not, your cart suddenly refused to fire up and go due to a dead or bad battery.
Can you top up golf cart batteries?
Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries. If this is the case, you will notice how several individual batteries have been “daisy-chained” together to form one large battery. 4.
Can you top up a golf cart battery with distilled water?
You need to leave enough room for expansion, so the acid should only be filled to just above the lead cells inside. Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries.
Do golf cart batteries last forever?
Golf cart batteries won’t last forever. In fact, each year they age a little bit closer towards their final use. If your battery is close to its warranty end date you may want to consider simply making the upgrade now.
Why is my electric golf cart not going fast?
3) Your Golf Cart does not accelerate as fast as it used to. Electric Golf Carts are known for being fast and having acceleration power. However, the day you start to feel your electric golf cart being slower to reach top speed is typically a sign of your batteries needing to be replaced. Also, another sign may be that it has trouble climbing hills ...
How many volts does a golf cart battery have?
Now, just because a battery pack displays 48 volts or more after a full charge does not mean they’re good. The real test would be to test them after they have been used for a few miles. The reason is that a deep cycle golf cart battery will not exhibit signs of needing replacement until after they are fully discharged.
How far can a golf cart go on a single charge?
Most Golf Carts can travel at least 7 miles or more on a single charge. However, if you are used to playing golf with no battery charge issues, but then one day you start to notice you can barely finish nine holes without having to limp home, then this could very easily be a sign of weak batteries.
Is it good to test a battery pack?
So once the batteries are fully discharged (used for several miles of driving), it is good to test the total battery voltage and each individual battery. A weak battery pack can sometimes be indicative of one individual battery being bad.