These are some symptoms of a bad speed sensor:
- Your golf cart may move very slowly as if it’s creeping along or it may move at an erratic speed.
- You may experience stuttering in your golf cart like when you have a bad battery or there is a low voltage problem.
- A broken or damaged magnet on the motor can result in a bad speed sensor. ...
- Your golf cart may go fast initially and slow down drastically on its own after some time. This will happen repeatedly in a cyclic pattern. ...
How do I know if my electric golf cart is bad?
Electric golf carts are usually trouble-free and do their job efficiently and with no fuss, but sometimes you suspect your golf cart is experiencing a problem. If the speed seems to be off, or your cart gives off a burning wire smell, your golf cart motor might have a problem.
How do I know if my motor is bad?
Then, make sure that continuity is present between the F-1 and F-2 terminal and A-1 and A-2 terminal, but not between the two—A-1 to F-1. This test will show if there is something wrong with the motor, even if the required 36/48 volts is applied.
How do you test a golf cart motor without removing it?
Using a multimeter, a jumper wire, and a 12-24 volt power source, you can test the condition and functions of your golf cart motor without removing it from the cart. What Is The Difference Between Series and Sepex Motors?
What are the most common symptoms of a gas golf cart failure?
For a gas golf cart, the most common symptom is the starter failing to engage, so the engine doesn't turn over. Starters have the responsibility of activating the flywheel.
How do you troubleshoot an electric golf cart motor?
Ignition or Motor Issues Look for a small red button located near the main power supply. Press the button and put your cart back together before hooking it up to charge. In many cases, this will solve the problem. If it doesn't, try removing the motor and testing it with a separate, fully charged battery.
How do you test a golf cart electric motor?
3:5410:28Testing 36 volt golf cart motor with 12 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou just want to connect the two together with this again a2 to s1 with this jumper cable. And youMoreYou just want to connect the two together with this again a2 to s1 with this jumper cable. And you want to take the battery box or positive cable and put it on the s2.
Do electric golf cart motors wear out?
Just like solenoids (mentioned above), your golf cart motor works HARD. When properly taken care of, the typical gas or electric golf cart motor can last many, many years (20 to 30+). But the fact of the matter is, many people neglect taking proper care of their golf cart motor.
How do you reset a golf cart motor?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you're in luck!
How do you test a Club Car golf cart motor?
0:251:28Testing an electric golf cart motor - YouTubeYouTubeStart of suggested clipEnd of suggested clipNegative 2 a1. And there we have it one wheel peel. But it's working brakes might be a little stickyMoreNegative 2 a1. And there we have it one wheel peel. But it's working brakes might be a little sticky on that side.
Why does my golf cart click but not move?
A Club Car golf cart can start clicking but not move, due to dust accumulating inside the battery ports. Opening the battery ports and checking whether there is any dust accumulation can tell you if this is the case. Cleaning it thoroughly with a cloth can resolve the problem.
What happens when an electric motor burns out?
When a motor burns out, a short circuit occurs in the windings and the motor ceases to turn. You can test for a short circuit by checking the resistance of the windings with an ohmmeter; a reading of 0 ohms (Ω) indicates a short.
What is the average life span of a golf cart?
For example, some experts estimate that the average golf cart has a useful life range of about 5-7 years. That said, golf carts can still be used for 10 years or more depending on how well they are maintained and how much money a buyer wants to put into their vehicle.
What would cause a golf cart not to run?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
Do all golf cart motors have a reset button?
Electric golf cart motors have a reset button on their chassis which is designed to put your motor back into its original factory state. While it doesn't repair damage that may have occurred to the motor over the years, obviously, it does help to overturn any changes to the operation which may have occurred.
Why does my electric golf cart have no power?
The main reason why a EZGO golf cart can lose power is because the battery is not charging due to loose cables or the corrosion of the connecting terminals. If they become loose or some of the electrical circuits' connecting wires snap, the battery loses power.
Can you rebuild a golf cart motor?
When the engine becomes difficult to start or you experience a loss of power and oil compression, you may need to rebuild the club car motor. By rebuilding the motor, you can avoid having to buy a new one. Disconnect the muffler, cables and any other component that attaches to the club cart motor.
What to do if your motor has an S terminal?
If your motor has an S terminal instead of an F, then test the S-1 to the A-1 terminal to make sure there is no continuity. Then, test the S-2 terminal, to the A-1 terminal for no continuity. These continuity tests will help you determine where the problems with your motor lie.
How to check if a battery is working?
Insert the screwdriver into the slot on a clamp and turn counterclockwise to remove it. Repeat this step with the other clamp. Then, test the voltage of the battery by touching each side of the wires to your 12-volt tester. This needs to be done to check all the batteries, as even one not working can cause your motor to malfunction. Don’t forget to remove the clamps before testing the other batteries as well. If at any time the tester shows less than 12 volts, the batteries need to be replaced.
Why is my golf cart not starting?
If the cart does not start, there is a big possibility of a damaged solenoid. Another reason for a bad solenoid is that the contacts are starting to get damaged due to overheating or high current passing through them. Note: You may not necessarily experience all of these issues to recognize bad solenoids on your golf cart.
Why won't my golf cart turn over?
For a gas golf cart, the most common symptom is the starter failing to engage, so the engine doesn't turn over. Starters have the responsibility of activating the flywheel. When the flywheel starts to work, the starter is supposed to disconnect.
How to tell if golf cart solenoid is bad?
One of the most common and obvious signs of the bad solenoid is the golf cart's failure to start when you initiate the ignition process. Once you click the accelerator and turn on the ignition switch, it is supposed to send a signal to activate the solenoid and start the cart. If the cart does not start, there is a big possibility ...
What is a solenoid in golf carts?
Simply put, a solenoid is a device that can transform electrical energy into mechanical energy. It's a coil of wire which is used as an electromagnet. The solenoid has the capability of creating a magnetic field with the help of an electric current. Solenoids work as the “go switch”, which is a must for any golf cart.
How to find out if your cart has a burnt out motor?
First, you’ll want to reset your motor. Get out your handy screw driver and work to uncover the motor itself. It should have a small reset button (Usually it will be red) located near the main battery supply.
Why does my golf cart quit?
motor burnt-out. One of the big reasons your golf cart could quit on you is that your motor burnt out. Motor burnout happens when your engine gets too hot and overheats, frying the wiring and other components inside. One common cause of golf cart motor burnout is continually pressing the pedal to the metal like you’re trying to drive a race car.
Why won't my cart start up after resetting the motor?
However, if your cart doesn’t start up after resetting the motor, you are most likely dealing with burnout. If this seems to be the case, remove the motor from your cart and inspect it to see if there are individual parts like bearings, coils, or brushes that are just broken. You can purchase these parts for a pretty low cost ...
Where is the reset button on a cart?
It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again. If it starts up then you’re in luck!
What happens if your car oil is too dirty?
If it gets too dirty it can cause your engine to not get enough air and stall out. Check the oil level and make sure you have enough and that the color is light and not black. If the oil is blackened or dark, you need to change it. Get a new oil filter and enough oil to refill the engine.
What to check for when replacing gas lines?
Gas Lines. You are also going to want to check all the fuel lines coming from the gas tank and going into the engine. Check for leaks, brittleness, and holes. If these lines have issues, you will need to replace them. This is easy to do as they are held on with clamps.
Do you need to troubleshoot a golf cart?
If you have a golf cart you will eventually need to troubleshoot the golf cart motor. This is an easy thing to do quickly. Remember, it is a gas-powered engine that is not much different than your lawn mower or car. You are going to go through some of the same steps to troubleshoot the motor.
How to tell if golf cart battery is bad?
1. Charging Issues. First, check to ensure that your golf cart was charged before you took it out.
How to check if golf cart is charging?
First, check to ensure that your golf cart was charged before you took it out. Plug it back into the charger and follow the instructions. Just in case the charger is the issue, check that the battery charger is turned on. There should be an indicator light to show that it is charging the batteries. In the morning, disconnect ...
What hole does a golf cart stop dead?
It’s a real hassle if your golf cart stops dead and you’re only at the 15 th hole of play. Not only is this an embarrassing event, but it’s a major pain to have to arrange for the cart to be towed back to the parking lot.
Why won't my cart fire up?
But more often than not, your cart suddenly refused to fire up and go due to a dead or bad battery.
Can you top up golf cart batteries?
Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries. If this is the case, you will notice how several individual batteries have been “daisy-chained” together to form one large battery. 4.
Can you top up a golf cart battery with distilled water?
You need to leave enough room for expansion, so the acid should only be filled to just above the lead cells inside. Only top up your golf cart batteries using distilled water. Also, it is common for golf carts to be powered by multiple batteries.
Do golf cart batteries last forever?
Golf cart batteries won’t last forever. In fact, each year they age a little bit closer towards their final use. If your battery is close to its warranty end date you may want to consider simply making the upgrade now.
What happens if my golf cart is not charging?
If you do not have any voltage in the batteries you will need to get some back into the battery bank before the golf cart charger will charge again .
Where to find battery in golf cart?
You will usually find the batteries to your golf cart under the front seat which opens or folds out towards the golf cart steering wheel on most Club Cars, Ezgo and Yamaha golf carts. Look for the two terminals with the most wires going to them. Usually this is the positive and negative most terminals in the battery bank.
What voltage do golf cart batteries work on?
All golf cart battery chargers usually operate on 110VAC but some have the ability to operate on multiple voltages for other power grids like in Europe vs US. 110/230VAC would reflect this feature on charger. Good DC side connection. This is the wire or cord with a connector that you would plug into the golf cart.
What is the third pin on a golf cart?
Then the third pin is usually a low voltage signal for a lock-out feature on these newer style golf carts. This is so the user cannot drive off with a golf cart “If the charger is still plugged in”.
Do golf cart batteries work the same?
Wiring batteries in a series style circuit is quite simple and always the same. No mater how many golf cart batteries you have it will always work the same.
Follow These Simple Steps to Check the Solenoid
1. You will need a couple of tools: a voltmeter or multimeter, and (typically) a ½” wrench.
36-Volt Solenoid
This article is accurate and true to the best of the author’s knowledge. Content is for informational or entertainment purposes only and does not substitute for personal counsel or professional advice in business, financial, legal, or technical matters.
