Golf carts have a button or lever that allows you to switch between forward and reverse gears. The reverse switch is found below the driver’s seat, and can be activated by pulling the handle left or right. Once pulled, the golf cart will start moving in reverse.
Full Answer
Why won’t my gas golf cart work in forward or reverse?
A surprisingly common problem with gas-powered golf carts is that they fail to work in forward or reverse. Why Won’t My Gas Golf Cart Work in Forward or Reverse? Most of the time golf carts won’t work in forward or reverse due to the shift cable being broken, electrical issues, ignition switch issues, or a too low idle speed.
How do the gears on a golf cart work?
Golf carts only come with forward and reverse gears. They usually have a lever or a button that allows you to switch from forward to reverse and back again. When you step on the pedal, the cart takes a second to initiate and then powers forward with a sometimes startling jolt. Golf carts are also very prone to tipping,...
How do you operate a gas golf cart?
To operate a gas golf cart, start the ignition. Make sure that the parking brake is pushed all the way down or the engine will not start. Golf carts only come with forward and reverse gears. They usually have a lever or a button that allows you to switch from forward to reverse and back again.
How do I switch between forward and reverse on a golf cart?
Golf carts have a button or lever that allows you to switch between forward and reverse gears. The reverse switch is found below the driver’s seat, and can be activated by pulling the handle left or right.
How does a gas golf cart reverse work?
How does reverse work on a golf cart? Golf carts have a button or lever that allows you to switch between forward and reverse gears. The reverse switch is found below the driver's seat, and can be activated by pulling the handle left or right. Once pulled, the golf cart will start moving in reverse.
How do you reverse a Club Car golf cart?
0:5911:38Golf Cart Forward Reverse Switch - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo the way it works is when you shift in the forward it's going to pick up the hot in the ground oneMoreSo the way it works is when you shift in the forward it's going to pick up the hot in the ground one direction and then when you shift into reverse.
How does a golf cart forward reverse switch work?
0:139:43Golf Cart Forward and Reverse Switch Direction Selector Tutorial - YouTubeYouTubeStart of suggested clipEnd of suggested clipThat is brand new it simply cables connect to the bright copper colored contacts. And the switchMoreThat is brand new it simply cables connect to the bright copper colored contacts. And the switch rotates through a hand action and that changes the polarity.
Why does my golf cart not go in reverse?
The simplest and most likely cause of reverse problems in a golf cart is a malfunctioning F&R switch. This switch – which stands for forward and reverse – is common on most golf carts and makes it easier for you to go forward and in reverse without requiring a lot of complex machinery or levers.
Why won't my gas golf cart go forward or reverse?
The problem could be with either the Run/Tow switch or Forward/Reverse switch or both. Check the switches to ensure that they aren't stuck midway. If they are, getting them released should help. However, if they show signs of wear and tear, you must get them replaced.
Where is the micro switch on Club Car?
2:1211:27Replacing Mircoswitches on Club Car DS - YouTubeYouTubeStart of suggested clipEnd of suggested clipTop and then I'll come right off and our micro switches are underneath. That all right we got theMoreTop and then I'll come right off and our micro switches are underneath. That all right we got the cover of that fuse box removed. And we can see our micro switches right.
How do you test a directional switch on a golf cart?
Place your foot on the car's brake, insert the key, and put the forward-reverse key in the forward position. If you see that the solenoid charges up pushing the pedal, then your forward reverse switch is working fine. As you put your Golf Cart in the forward mode, check your multimeter for full voltage.
How do you test a Club Car micro switch?
Micro Switch Testing The micro switches are simple 2 wire on/off switches. They open and close mechanically. You can test function with a voltmeter if you first verify 36v in on the supply side of the switch, then mechanically trigger the switch, and test for 36v on the output side.
Does a gas golf cart have a transmission?
All golf carts (much like cars) have a clutch, which is the part of the drivetrain that helps the put the power of the motor down through to the wheels/ground. Golf cart clutches are a part of the Continuously Variable Transmission (or CVT).
Where is the reset button on a Club Car golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
How to check if micro switches are working?
First, get the forward and reverse switch in a neutral state. This is followed by disconnecting the micro switches, both forward and reverse. Use an ohmmeter to check the micro switches as you move them in forward and reverse position. If the switches are working perfectly, put them in back in place.
Why is my golf cart only going in reverse?
Golf cart only goes in reverse. If your golf cart is only moving in reverse, there could be an issue with the contacts in the forward and reverse switch. This can be checked by swapping the two wires present in the swivel terminals in the center. The micro-switch present at the FR knob might be preventing the golf cart from going in ...
Why is my golf cart not rolling?
If the golf cart is not rolling across freely, there might be an issue with the brakes. Inspect the brakes and rear ends and check out for any seizing up. There can also be an issue with the controller. Make sure that you have new batteries inserted in the golf cart and that they are not drained.
Why won't my golf cart move forward?
There might be several reasons why a golf cart won’t move in forward or reverse. The most likely reason is incorrect wiring or a faulty accelerator. If you’re mechanically experienced, you can attempt to use the tips below to fix the problem yourself. I have outlined the most likely causes and steps to fix this below:
Can a golf cart controller get wet?
Often the plug between the controller can get wet, and this would keep the golf cart going in reverse only. Get it dried out and see if it gets your golf cart working in the forward direction. Often, the plug stays wet when the cart is washed, so make sure you dry it out properly. The forward and reverse switch is controlled by a single solenoid.
Do golf carts run on gasoline?
Once pulled, the golf cart will start moving in reverse. Golf carts are based on electric motors. They are explicitly designed to be eco-friendly as they do not run on gasoline that would release toxins into the environment. There is no considerable difference between the mechanics of cars and golf carts.
Do you put a seat belt on a golf cart?
As a precautionary measure, it is always good to put on your seat belt even though golf carts do not go up to a very high speed. Next up, you need to get your golf cart in gear that can either be ‘forward’ or ‘backward.’. This may, however, vary from cart to cart. Make sure that you lock the lever before proceeding any further.
When did golf carts evolve?
Club Car Golf carts have evolved many times since 1975, and although the basic electrical design has stayed close to the same, there are small differences. These differences are important when troubleshooting your cart.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf...
Loose Cables
Loose power cable connections are the primary culprit in the failure of traditional mechanical rotary style forward reverse switches. Power cables are the thicker, usually 6-gauge, cables that connect the forward reverse switches to the starter generator, in the case of 2-cycle gas golf carts.
OEM 6 Gauge
For most golfing applications 6-gauge cabling is adequate to the task of carrying two golfers and their two golf bags around the course, stopping every 200 yards or so while they play their next shot.
Upgrades
The larger diameter tires require more current (amps) to simply get the cart rolling. Added passengers mean more pay load demanding still more amps through the electrical system. Add a hilly or mountainous terrain and the amp draw just keeps getting higher.
Sepex Controllers
Many modern golf carts have an electronic speed controller that handles the forward and reverse switching function internally. These carts have a toggle switch of some design to change direction rather than the older mechanical rotary forward reverse switches common to many golf carts.
How does an electric golf cart work?
How Does a Golf Cart Work. In the most basic sense, your electric golf cart works by providing electric power from a battery pack to a motor that turns your wheels. Everything else involved is just a way of controlling when and how much of that power is being delivered. The battery pack is pretty basic.
How do golf cart batteries work?
Batteries work by changing chemical energy into electrical energy. Different types of batteries use different types of chemical reactions to do this, but for the most part they’re all very similar. We did a whole article on golf cart batteries ...
What is a golf cart solenoid?
We did a write up on golf cart solenoids if you want to get deeper knowledge, or learn how to test them. Like I said before, a solenoid is basically a switch, but more specifically, it’s a relay, meaning that it’s a switch that uses one circuit to control another.
What is an inductive throttle sensor?
What that really means is when you push down your electric golf cart accelerator, you’re actually pushing a rod through an inductive sensor coil. The sensor coil uses this to tell the speed controller how much voltage to consume.
How many volts does a golf cart battery pack have?
The battery pack is pretty basic. It could be anywhere from 6 to 48 volts, but it’s usually 36 or 48 volts on most newer electric golf carts. The battery pack’s power is routed to the motor, but along the way, it is changed by a solenoid and a speed controller to give you only the power you’re asking for and only when you’re asking for it.
How long have electric golf carts been around?
Electric motors have been around for a couple hundred years, and honestly after around the 1890s, not a whole lot has changed.
What is the part of a motor that moves?
The part that is moving is called the rotor. It’s essentially a rod wrapped in copper wire that reacts to the electromagnetic forces in the stator. With only those two parts, the rotor would find the attractant pole of the stator, and then the motor would stop. That’s what the commutator is for.