Full Answer
How much voltage does an automatic golf cart battery charger need?
An automatic golf cart battery charger needs a minimal amount of voltage in the batteries to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
Why is my golf cart Charger always hot?
A cheap extension cord can cause the charger to overheat. Give the charger room to breathe and make sure it is on a hard surface, preferably the garage floor. With that said, if the golf cart charger is always hot and always giving off a bad smell, you should contact the manufacturer to confirm that everything is functioning properly.
Should you leave your golf cart charger plugged in?
If you leave the battery chargers plugged in for an extended amount of time, the electrolytes in the battery pack should be checked monthly and distilled water should be added. Therefore, according to Club Car if you are storing your golf cart you should leave it plugged in consistently.
Can I use a 36V charger for a 48V golf cart?
Really, any 36V charger, you are good to go. With 48 volt chargers, the same applies (you can swap out plugs), EXCEPT when you are attempting to use a 48V Club Car or its charger with the round 3-pin plug. The 48V Club Car chargers are completely different than all other golf cart chargers.
Why does my golf cart charger plug get hot?
There can be numerous reasons why a golf cart charger may get hot. As electrical power flows from one terminal source to another, the golf cart typically gets a little warm. However, overcharging and straining the battery forces the battery to get excessively hot.
Can you plug a golf cart into a regular outlet?
Electric golf carts are powered by a rechargeable battery pack, 36 or 48 volts, and fully recharge by plugging the cart charger into a regular outlet.
Does it hurt to leave golf cart plugged in?
Final Thoughts. No, it's not recommended that you leave your golf cart plugged in all the time. Although automatic chargers are designed to prevent over-charging, there is still the risk of the circuit breaker tripping, which would result in damage to your battery's cells.
How many amps should a golf cart charger put out?
The ammeter on a 36-volt charger should show at least 15+ amps when the charger is plugged into the golf car, even if the batteries have not been used for a short while. A 15+ amp reading shows that the charger is actually charging, not just humming (humming is NOT an indication that the charger actually works).
Should you charge golf cart batteries after every use?
Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
Can you charge a golf cart in your garage?
Golfers may not realize it but their golf carts could be ticking time bombs if they charge them inside a garage. That's because golf cart batteries, especially older ones, emit hydrogen, an odorless, colorless gas that is highly flammable.
Can I leave my golf cart plugged in for a month?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How long should you leave a golf cart plugged in?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
How often should you fill golf cart batteries with water?
about once every 30 daysThe typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
How many amps does a 48v golf cart pull?
On average, electric golf motors operate at 36 or 48 volts and draw between 50-70 amps of current while cruising at about 15 miles per hour.
How many amps does a 48v golf cart charger pull?
A 48-volt system of 4×12 volts can deliver approximately 600 amps. Yet a 48-volt system of 8×6 volts can deliver 1,800 amps. This alone can increase the range of a golf cart from about 12 miles to about 35 miles. Both systems deliver the same voltage, so their speed and acceleration will be similar.
What should a golf cart charger read while charging?
1:564:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipBut it's most common to have a light to indicate that ac power is present meaning it's plugged intoMoreBut it's most common to have a light to indicate that ac power is present meaning it's plugged into the wall.
How do you charge a golf cart?
0:050:49How to Charge an Electric Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipEvery cart you don't use one charger for the other carts every card has its own charger comes withMoreEvery cart you don't use one charger for the other carts every card has its own charger comes with it has a plug in it plugs into the cart you merely pull the card. In take the charger.
How many volts does a golf cart have?
The standard electric golf cart will have four, six, or eight batteries in total. The voltage will be either 36 volts or 48 volts.
How do you hook up a USB outlet to a golf cart?
9:0410:08Adding USB Ports & Volt Meter to 48 Volt Golf Cart without a ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd there we go 49.2 volts pull a little cover i tested the usb ports they both work. So this is aMoreAnd there we go 49.2 volts pull a little cover i tested the usb ports they both work. So this is a pretty inexpensive way to just add usb ports to a 48 volt golf cart.
How do you hook up a 36 volt golf cart?
0:5411:26EZGO Golf Cart Radio Install And Upgrades - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what we're gonna do is we're gonna hook up our converter. Which I got off Amazon as well convertsMoreSo what we're gonna do is we're gonna hook up our converter. Which I got off Amazon as well converts 36 to 48 volts down to 12. So you can run our accessories for the LED bar and the stereo.
Why My Golf Cart Motor Has A Burning Smell?
There are several reasons why the electric golf cart may be producing a burning smell, most of which are related to the amperage and the batteries. If you smell something burning and the cart has stopped, you probably have a burnout case on your hands. When you have ruled out the possibility of burnout, look at the following possibilities.
Should I store my golf cart outside?
This seems like the most obvious solution, especially if you live in a warm climate. You won’t have to worry all that much about hydrogen gas creating fires, but there are other issues with storing your golf cart outside that can come up if you’re unprepared.
Can Electric Golf Carts Overheat?
Yes. Electric golf carts can overheat for several reasons. As mentioned earlier, the engine casing temperature will normally range between 150-180 degrees which means that anything above that is overheating. Several reasons can cause an electric golf cart motor to overheat. Let’s look at some of them.
Will My Golf Cart Stop If It Gets Too Hot?
If you were driving your golf cart with a hot engine and it suddenly stopped, there is a good chance that the cart stopped due to overheating. The best-case scenario is that the battery is dead and needs a recharge, but if the power is intact, then you’re facing a motor burnout.
Can you charge a golf cart battery in a closed garage?
Preferably, you should charge your cart on the outside, but if you have sufficient airflow and ventilation in the garage, you should be fine.
Can golf cart batteries give off carbon monoxide?
The short answer is no, most lead acid batteries that golf carts use don’t emit that kind of gas. However, as mentioned above, they emit hydrogen gas, especially if the battery is at risk of overcharging.
Should A Golf Cart Motor Get Hot?
The golf cart motor will get hot at some point. This is typical of many electronics, so it should not alarm unless the motor gets extremely hot. With normal use, the motor casing temperature will read 150º, although a high of 180º is also acceptable.
How many volts does a 2005 Yamaha Golf Cart have?
I have a 2005 Yamaha golf cart 48 volt. zThought my charger
What voltage is a Ruff Tiff cart?
Purchased ruff tiff 48 volt cart and it has rather new
How many volts does an EZGO have?
EZGO electrict 36 volt EZGO: Good evening I have 2, 36 volt,
What amp reading does a charger show?
What amp reading does charger show? High amp reading would make charger plug hot, but if amperage is 15 or less, check the contacts and the cables in the connection for a bad or loose connection. Heat is caused by high amperage or bad or corroded connection. Heat is resistance! High amperage can indicate you have a battery with bad cell. Do you have a voltmeter to check each batteries voltage?
What year was the Yamaha G19 48V?
Ref 1969 Yamaha G19 48V elec golf cart: I bought a brand-new
Does a golf cart charger get hot?
Charger male plug to golf cart gets very hot when charging - Answered by a verified Electric Vehicle Mechanic
Does EZ go cart move?
EZ go cart will not move. Clicks when engaged but will not
How to check if a golf cart battery is hot?
Use a multimeter and check the resistance of the battery wire that you find is quite hot. If you find that it has a low resistance, replace the wire with one that has a higher resistance, ensuring that it is well within limits prescribed for the golf cart.
Why does my golf cart get hot?
If you find a particular cable getting hotter than the other cables, check for the connection made with that cable. A bad or loose cable connection can cause it to get hot.
What Causes Golf Cart Battery Terminals to Melt?
Just like the battery cables of your golf cart, the battery terminals also tend to melt. You must check them often and take the necessary measures to avoid damage to your golf cart.
Why does my golf cart battery melt?
The main reason why golf cart battery cables will melt is because of too much current passing through the jumper cable; resulting in overheating and melting. A poor contact connection or a missing ground strap between the chassis and the engine may also result in the melting of your golf cart battery cables. Alternatively, corrosion of either of ...
What happens if a golf cart battery leaks?
If you have a leaking battery, then corrosion is inevitable and it will affect the battery terminals. This will eventually seep into the posts and melt them. Check out for a battery terminal protector from your golf cart parts store. This is usually available in the form of a spray.
Why do the bolts on my cable terminals melt?
The bolts on the terminals often melt because of excess heat and even tend to break. When this happens, the terminals are also affected. One main reason for the heat generation is a corroded connection. This corrosion increases the cable resistance and thereby the heat, which leads to melting.
How to keep golf cart motor from overheating?
Get your golf cart’s motor cleaned from time to time and keep it dust-free as far as possible. This will not only ensure the maximum efficiency of the motor but also prevent overheating of the battery cables to an extent.
What is the amperage of a golf cart?
Golf Cart Battery Amps. Amperage can be considered akin to the fuel in a gas-powered engine. Similar to a tank of gas, the amount of amperage will dictate how far you can drive your cart on a single electric charge.
How many volts does a golf cart have?
There is a major difference between 36 volt up to 48 volt systems, impacting both performance and potential upkeep and maintenance costs. Hint: some batteries are much more expensive ...
What does the owner manual on a golf cart tell you?
If uncertain, referring to your golf cart’s owner manual will provide guidance as to the type of battery your make and model was made to handle. As always, if you have questions or need further assistance, our talented and highly trained staff is standing by to assist and make sure you get just what you need to enjoy the trails or links worry-free.
What does voltage mean in a battery pack?
Voltage represents how much power your system will be delivered, resulting in increased ability to tow, carry more weight, and accelerate faster.
Does a golf cart battery need to be recharged?
In this regard, a higher voltage (although more powerful) often comes at a cost. That cost is that it can burn through more amps faster, draining the golf cart battery quicker, and requiring you to recharge more frequently.
Two chargers, neither works
Just got my new golf cart battery charger in the mail. Super fast shipping but it doesn’t work either. My other charger just stopped working so I assumed it was the charger. Could there be something going on with my golf cart? The kids used it all weekend and ran it down to the point we had to push it into the garage.
Battery Desulfators
Thanks Pete for the fastest delivery I have ever had. I have installed my new Delta Q QUIQ 48 volt golf cart battery charger and everything is working. I have a question about the charger.
How many amps does a coach charger use?
That is based on the onboard wattage regulator for the outside outlets. However, the charger requires at least 15 amps.
Is the coach outlet wire too small?
The wire size on the coach outlets is probably too small to support a high amperage charger. Like you mentioned, the outlet is just an extension of the line from the coach to the supply box. Although the cable to the supply box is adequate, the coach is probably internally wired with 14 ga wire which is too light to carry the amperage.
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
Where is my User’s Manual for my golf cart battery charger?
Our manufacturer does not provide owner’s manuals. Here are the links to the Lester charger manuals (they are also linked to on our product pages):
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
Should I charge the golf cart after each use?
Yes. It is healthy for the batteries to be fully charged at all times. So, you should charge your golf cart every night. Automatic golf cart chargers will shut off once the batteries are fully charged, so there isn't a concern that they will be over charged.
How cold should a golf cart battery be?
As we know, it is a pain to uninstall and reinstall golf cart batteries, my recommendation would be to make sure your golf cart is stored above 32 degrees F and keep them charged and maintained throughout winter. This will prolong their life and keep older batteries running for a long time.
Who makes electric golf carts?
The three major manufacturers of electric golf carts are Club Car, E-Z-GO, and Yamaha, and it seems most of the confusion surrounding the question at hand is their fault. Well, let’s not blame any of the three companies, but they are certainly responsible, for each of these three major golf cart manufacturers address the question differently.
Why do golf cart batteries deteriorate?
The main reason would be a concern for the golf cart battery. Manufacturers recommend leaving your golf cart plugged in all of the time, but only if using an automatic battery charger. This will keep the batteries topped off and ready to go. If batteries are not charged over a storage period of several months, they can deteriorate ...
What type of batteries does a club car use?
They have produced carts with 48V lead-acid configurations and lithium ion batteries. However, the 48V lead acid carts are the most common. The Club Car guidelines for charging such a cart are as follows:
What happens if golf cart batteries are not charged?
If batteries are not charged over a storage period of several months, they can deteriorate and provide less capacity. When there are experienced and inexperienced owners asking the same question, you have to wonder if this question is being addressed by golf cart manufacturers and where the confusion surrounding the questions is sprouting from. ...
Can you leave a golf cart plugged in?
In conclusion, the answer to the question at hand is most likely: No, you shouldn’t always leave your cart plugged in when you are not using it. However, depending upon which type of golf cart you have, the proper guidelines from your manufacturer will differ. According to Club Car, you should leave your cart plugged in during storage and let the computer detect when the batteries need a charge. According to E-Z-GO, you can leave your cart charging during storage, but you should consistently check on your power source. And, according to Yamaha, you should remove your batteries from the cart completely.
What temperature should a storage unit be?
The location of storage should maintain a temperature between 0 degrees celsius (32F) and 32 degrees Celsius (90F).