The golf cart motor will get hot at some point. This is typical of many electronics, so it should not alarm unless the motor gets extremely hot. With normal use, the motor casing temperature will read 150º, although a high of 180º is also acceptable.
Full Answer
What are the signs of a bad starter generator in golf cart?
Overheating is one of the more obvious signs of a bad starter generator in a golf cart. A bad starter-generator can heat up to an extent that it starts letting out smoke after a short while. A starter generator starts overheating primarily when the current it produces becomes more than what is needed to run the golf cart.
Why won't my golf cart start in the spring?
If you don't disconnect your battery's wires, you may find yourself with a golf cart battery that won't start in the spring. Set the key switch to "OFF". If your golf car is an electric RXV, make sure the 'Run/Tow' switch is set to the 'Run/Storage' position.
Why does my golf cart battery get too hot?
Loose battery connections and dirty terminals are the main reason why your golf cart battery will get too hot. A battery that feels too hot while charging usually means that the water level is too low.
How do I prepare my golf cart battery for winter storage?
We'd like to walk you through what steps to take when preparing a golf cart battery for winter storage today. Before leaving your golf cart, ensure that the battery is clean, fully charged, and has been disconnected from any source of electrical drain.
How hot should a golf cart motor get?
How hot should a Yamaha golf cart motor get? Generally, a temperature of 170ºF is considered reasonably safe for your Yamaha golf cart motor. If the temperature exceeds 250ºF this indicates a serious problem.
Is a golf cart charger supposed to get hot?
It is entirely normal for golf cart chargers to get hot while charging them golf cart batteries. When the golf cart battery charger is plugged in, it gets hot and produces an odor. The heat from the golf cart charger is normal when used for long continuous hours.
Why is my golf cart battery charger getting hot?
But here are a few general tips to keep the charger from overheating: Make sure that your battery cable connections are correct, clean and tight. Bad connections can cause a charger to overwork and overheat. Ensure that you have adequate water levels in your batteries.
How do you test a golf cart starter?
0:011:03How to Check the Generator on Your Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd you should see the voltage jump up from around 12 volts with the cart running to about 16 voltsMoreAnd you should see the voltage jump up from around 12 volts with the cart running to about 16 volts that that happens that proves the generator is fine you simply need to change.
How hot should my charger get?
The heat coming from your charger is easily noticeable and may make you nervous, but it is typically normal as long as it does not exceed 50 degrees Celsius (122 degrees Fahrenheit).
How hot should a battery get when charging?
BU-410: Charging at High and Low TemperaturesBattery TypeCharge TemperatureDischarge TemperatureLead acid–20°C to 50°C (–4°F to 122°F)–20°C to 50°C (–4°F to 122°F)NiCd, NiMH0°C to 45°C (32°F to 113°F)–20°C to 65°C (–4°F to 149°F)Li-ion0°C to 45°C (32°F to 113°F)–20°C to 60°C (–4°F to 140°F)
Is it normal for a battery charger to get hot?
Is it normal for a battery charger to become very hot? The answer is, yes. The charger becomes hottest during what we call the "bulk charging phase", which is when most of the battery's capacity becomes recharged.
Can a hot charger catch fire?
Yes, a hot charger can catch on fire. This is the biggest reason why you should not leave your phone charger plugged in if it is hot, as they have been known to cause electrical fires.
Can you leave golf cart charger plugged in all the time?
Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.
How do I know if my starter generator is charging?
0:000:42Zip Tip Starter Generator Testing - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd while it's spinning down come over to your. Field. If it stops like that and acts like anMoreAnd while it's spinning down come over to your. Field. If it stops like that and acts like an electric brake. You have a good starter dinner zip tip out.
How does a golf cart starter work?
The starter generator works in two ways; the starter portion cranks the engine and the generator portion recharges the battery. When the gas pedal is depressed the starter cranks the engine over. When it begins to run on its own, the generator portion of the unit begins to charge the 12-volt battery.
How do I test my starter generator not charging?
To check if the starter generator is causing the battery charging issue in your EZ-GO golf cart, all you've got to do is short the green wire to ground. Remember, you need to short the wire and not the terminal itself. After doing that, apply a full field current at the battery terminal.
How to tell if a golf cart starter is bad?
The following are four common symptoms that of a bad golf cart starter generator. Turning the Key Doesn’t Turn the Cart On. This can happen if either your cart’s battery or starter generator is out of order. Check if the lights on your cart are working. If yes, then it’s a bad starter generator.
Why is my golf cart starting with a bad starter generator?
You might even find yourself stranded once it fails to turn over the motor and start your golf cart. The starter generator generates current for the cart to operate on. It relies on the electromotive force supplied by the battery.
How does a starter generator work?
The starter generator generates current for the cart to operate on. It relies on the electromotive force supplied by the battery. It consists of a coil of wire, which when moved produces a current in the coil. The coil is connected to the main axle of the cart for the necessary movement of wires. The starter generator doesn’t just generate current ...
Why won't my golf cart turn over?
A golf cart starter generator will not turn over due to low battery voltage, misaligned rotation or mechanical damage to the pulley and brushes. Although you may not be able to identify the exact reason, failure to turn the motor over could be due to any of the three reasons mentioned here. Low Battery Voltage.
Why is a starter generator important?
It’s critical in charging the battery, starting the car, powering carts’ lights and also serve as a limited power source when needed. Identifying whether your cart’s starter generator has gone out of order or your cart’s battery is not working, is often a tough task.
What does it mean when your cart lights are not working?
Check if the lights on your cart are working. If yes, then it’s a bad starter generator. If no, then something is wrong with your cart’s battery. If your cart is taking longer than expected to start cranking, then you probably have a bad starter generator. This might happen due to a battery issue as well.
Which way does a Starrer generator turn?
For an engine that requires the starrer generator to turn clockwise, the starter generator has to be aligned in such a way that it does turn clockwise. Any misalignment will prevent the engine from turning over. Mechanical Damages.
How does Golf Cart Starter Generator Work?
In this article, we will describe the full process of a starter-generator works. Anyone can be helpful by reading this article. We show here some important steps with troubleshooting a golf cart starter generator. And also find a way to resolve these kinds of issues.
What is a golf cart starter generator?
For every golf cart, there should be a starter generator. It is known as a very special device that helps for turning the engine and also charges the battery of the golf cart simultaneously. Usually, it works in two ways.
How does golf cart starter generator work?
Generally, every electric golf cart and gasoline golf cart has a starter generator. It starts to work when the gas pedal decreased its workability, then the engine of the golf cart needs to crank. This job is done by the starter. The starter cranks the golf cart engine properly while the battery is getting charged up by the generator.
How much torque does a golf cart battery need?
According to the majority of the golf cart battery manufacturers, the torque required falls between 85 to 100 and 5-inch pounds.
How far should the battery be from the plate on a golf cart?
According to some studies, there should be a gap of ¼ inch above the plates. Sometimes, your golf cart batteries are old and worn out. Such batteries fail to work efficiently and will eventually die. These factors will force your charger to add more pressure on the batteries to get them completely charged.
Why is my cart hot after charging?
Using your cart with a dry battery will cause heat damage quickly! Maintaining optimal water levels is a must. If you find your batteries becoming hot soon after charging, it may indicate low water levels. Don’t forget to check the cable connections as well.
Why does water boil in golf cart batteries?
Why Water in Wet-Cell Batteries Keeps Boiling While Charging. There are multiple reasons for the water in wet cell batteries to boil. Sometimes, you may have more water in your golf cart batteries than what is needed. According to some studies, there should be a gap of ¼ inch above the plates.
Why do golf cart batteries melt?
Why Do Golf Cart Battery Terminals Melt. The terminal of a golf cart battery will usually melt when connections become loose or dirty. To avoid terminals melting, ensure you use the correct size wires, and that limps, nuts and bolts are tightened securely.
What is a post on a golf cart?
The post is associated with the cell plates of the golf cart’s battery. This helps in the transferring of power from battery to the engine of the golf cart. Remember that leaving connections loose or dirty can easily lead to some resistance.
Is it normal for a golf cart battery to be hot?
It’s quite normal for golf cart batteries to feel a little warm while in use or during charging. This comes as no surprise as a large amount of energy is being transferred when using your golf cart. However if your battery or charger feel too hot, or even worse you smell an odor, it’s time to stop and troubleshoot the issue.
Reasons Why You Have to Choke Your Golf Cart to Get it to Start
The choke is used to inject fuel into the engine so that it can start. There are a few reasons why you have to choke your golf cart in order for it to start. Some of the most common are:
7 Common Fixes for having to Choke your Golf Cart all the Time
There are a few problems that you may experience with golf cart chokes. Being able to diagnose these problems and fix them will have your golf cart working better and result in you having to choke your golf cart less. Here are some common problems you may be experiencing with choking your golf cart:
Why Do You Need to Choke a Golf Cart all the time?
Your golf cart will not start on its own because no fuel flows into the engine until it’s running, so you need to choke your golf cart before it will start. A new engine should fire right up when flooded with gas. If you live in an extremely cold climate, the choke is critical for getting your golf cart to start.
How Many Times Should I Have to Choke My Golf Cart Before It Starts?
It depends on outside conditions and how much fuel is in the carburetor already. If your thermometer reads below freezing, choking will help get your golf cart’s engine going. If it isn’t that cold, but still cool, you should be able to start up normally as long as there’s enough gas in the carburetor.
When Should I Choke My Golf Cart?
Whenever necessary outside conditions call for it. If it’s cold or you haven’t started it in a while and your golf cart won’t start right away, you might need to choke it. Choking gets more important when temperatures are low since colder air contains less oxygen which makes starting engines more difficult.
Can you turn off the radio on a golf cart?
Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.
Can you use an automatic battery charger when it is fully charged?
It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.
Can you drive a golf cart up steep hills?
Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.
Should golf cart batteries be charged?
Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.
What Gas Do Golf Carts Take And Why?
Gas-powered golf carts require at minimum 87 octanes for the engines. This is because 87 octane has less than 10% ethanol, and most (if not all) manufacturers recommend 87 octanes for their carts and advise against using any other grade of fuel.
What Fuels Do You Use For Yamaha, EZGO And Club Car?
For most of the major manufacturers, the recommended fuel is ‘unleaded’ and is essentially the same as you would use in your car, so this would be either 87 or 89, and if you are at altitude, you may need higher octane.
When Could You Use A Higher Octane Fuel In A Golf Cart?
The only time you could use a 93 octane or higher is when you are using the cart at altitude or if you have installed a high-performance engine. This is because where there is less oxygen, the fuel burns slower, and using a lower octane fuel like 87 could lead to a loss of power from the engine as there is less oxygen to fuel the ignition process.
Is 87 Octane The Best Fuel For Golf Carts?
Since 2017, increasingly more opinions have been expressed that 87 Octane may not be the best fuel for golf carts. This has come around due to mechanical issues seen in golf carts like stalling, exhaust smoke, clogged carburetors, damaged fuel pumps, and dissolving of rubber components.
How Can I Keep My Golf Cart Fuel System In Good Condition?
Aside from the fuel itself, you can take some other preventative measures to ensure that external factors don’t affect your cart’s performance.
Conclusion
As for gas-powered golf cart owners or buyers, you should always be advised which grade of fuel would be preferable in your cart, and the older carts would still probably run best on 87 octanes.
What is the 'Run/Tow' switch on a golf car?
If your golf car is an electric RXV, make sure the 'Run/Tow' switch is set to the 'Run/Storage' position. Remember, if it's left in the 'Tow" position, it will continue to drain the batteries over time.
Do golf cart batteries self discharge?
Before leaving your golf cart, ensure that the battery is clean, fully charged, and has been disconnected from any source of electrical drain. Batteries will continue to self-discharge, even during periods where they are not used or are being stored away. If you don't disconnect your battery's wires, you may find yourself with a golf cart battery ...
Can you put away a golf cart in winter?
If you're the type to put away your golf cart or ATV for winter storage, there are a few steps you'll need to take to ensure that your battery stays in peak condition, even if you're not heading out on the course or into the woods during the colder months. We've spoken before about winterizing your ATV, but we haven't really taken a close look ...