Full Answer
How to refurbish a golf cart battery step by step?
Step-by-Step Guide: Golf Cart Battery Reconditioning
- Safety goggles
- Rubber gloves
- Apron
- Distilled water
- Epsom salt
- Bucket
- Baking soda
- Flathead screw
- Wrench
- Battery Reconditioning Chargers
How to recondition golf cart battery in 10 Easy Steps?
STEP 1 Before preparing your battery for reconditioning, you need to wear your protective gear: apron, gloves, mask, and goggles. Likewise, make a weak baking soda and water solution on the side to neutralize any sudden spills and splashes. STEP 2 You need to remove the corrosion in the battery terminal.
How long does it take to charge golf cart batteries?
Most golf cart chargers will charge at 10-20 amps. If you have a 220 amp hour battery and are charging at 15 amps, it will take about 14 hours to charge. If you are charging 100 amp hours at 10 amps, it will take 10 hours to charge. It really is a simple math equation based on your used up amp hours and your chargers charging amp hours.
How do you recharge a dead golf cart battery?
You will need:
- Battery charger
- Epsom salts
- Baking soda (and an old paintbrush)
- Distilled water (and a turkey baster)
Do new golf cart batteries come fully charged?
New Batteries Don't Always Come Fully Charged In fact, by the time installation of the new battery is complete, its charge will most likely be hovering between 70 - 75%.
How long do fully charged golf cart batteries last?
Typically, an electric golf cart has between 45 and 90 minutes of full-power run time on a fully charged battery. Times depend on the age of the battery, with newer batteries having longer run times.
How do you break in a new golf cart battery?
Plug the charger in and leave it alone until the charger shuts off by itself. Then drive to discharge the batteries to 75% of battery pack capacity (see chart for voltage readings or use 9 holes of golf as a reference point) Plug the cart back in and repeat the charge cycle.......
How long does a new cart battery take to charge?
A relatively-new battery – say 1-3 years old – will typically charge quicker than an older battery. For comparison, a five-year-old battery that is almost fully discharged may take 10 hours or more to charge while a newer battery with the same discharge level may only take 1-3 hours to reach full power capacity.
Should I charge my golf cart after every use?
Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
How far will a golf cart go on a full charge?
Depending on the manufacturer, most gas golf carts have between a 5 and 6 gallon gas tank and get about 40 miles to the gallon. Electric golf carts with fully charged batteries in perfect condition get about 35 miles to the full charge.
How much does a new golf cart battery cost?
Average Price of Golf Cart Batteries The average price of a golf cart battery replacement is going to be in the $800 to $1,500 range. Depending on the type of battery, it could even be in the $2,000 ballpark because powerful golf carts like a 72V need more expensive batteries installed.
Is it OK to just replace one golf cart battery?
Let's discuss in detail. When it comes to changing the golf cart batteries, technically, you can change just one at a time. However, this is not advisable as it can cause permanent damage to each battery. When a battery has gone bad, you should change all of the batteries.
Do new golf cart batteries need water?
Also, to avoid corrosion, keep the plates from being exposed to the air. When should I water my batteries? Brand new batteries will use very little water at first, but with average use, will need water about every other month.
How often do golf cart batteries need water?
The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
How many miles can a 48V golf cart go?
The maximum range of this new battery when powering a 48V E-Z-GO RXV golf cart is approximately 20.5 miles when moving at 12 miles per hour. In golfing terms, this equates to around 3 rounds or 54 holes.
How do you tell when a golf cart is fully charged?
1:574:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipMost will flash or blink during charging and present a solid green light when finished.MoreMost will flash or blink during charging and present a solid green light when finished.
Lifespan of a Golf Cart Battery
Batteries that are maintained and treated well will inevitably last longer. If the cart is part of a golf course's fleet, it should have a life of around five to six years based on wear and tear. If the battery in question is for your own personal golf cart, you could expect that battery to last up to eight years or more.
Things to Consider
Is your cart only for golf? If so, there are years of rounds ahead on a new battery. If you cart is for transportation and recreational use within a community, it obviously sees much more use.
Proper Charging
Always charge your electric golf cart when you're done using it, whether you played nine or 18 holes. If possible, leave it charging overnight. Short-charging can make your batteries unbalanced and shorten their lifespan.
Water
Check your battery water level and add distilled water when needed. Don't use tap water, which contains minerals that will reduce battery capacity.
Winter Storage
If your golf cart gets stored at the end of the season it's important to make sure your batteries are taken care of before doing so. The batteries should be stored fully charged and disconnected from any circuit that could discharge the battery pack. Clean each battery and remove from the battery case.
Golf Cart Battery Problems
The biggest killer of battery power is disuse, which will deep discharge them and affect their longevity. If not used, lead sulfate crystals form on the plates inside the battery and lower efficiency. This process is accelerated in hot weather, the climate in which most cart batteries are used.
How to Know When Golf Cart Batteries Are Dying
Hit the gas pedal smoothly after you turn on the golf cart with the key. If your battery is getting near the end of its life cycle, your starts will be slower than normal. You might notice more than a two-second delay from the moment your foot hits the gas pedal to the time the cart moves.
So, How Long Do Golf Cart Batteries Last?
Golf cart batteries can last up to 10 years, but it is a very rare occurrence. The average lifespan can vary greatly depending on how often you use it.
Making Golf Cart Batteries Last Longer
Here are a few handy tips to make your golf cart batteries last longer:
When to Replace Your Golf Cart Battery
It is best to replace your golf cart battery at the right time rather than wait for it to stop working completely.
Wrapping Up
Golf cart battery life is an important consideration for golf cart owners. It is one of the biggest factors in maintenance cost and everyone wants to get their money’s worth when it comes to vehicles.
How long do golf cart batteries last?
The batteries of privately owned golf carts can be expected to last between 6 and 10 years.
What factors affect the battery life of a golf cart?
Another factor that affects battery longevity, albeit a lesser one, is the number of extras the golf cart has. For instance, some may be fully decked out with headlights, horns, and windshield wipers (as well as any other components that make a golf cart street legal) – features that put a bit more strain on the battery, affecting its longevity.
How does overcharging affect golf cart batteries?
This basically when the charger continues to pump power into the battery even when it is fully charged, over-cooking the internals. If this becomes a regular habit, it will drastically affect the lifespan of the battery.
Is it good to leave a battery empty?
Leaving them empty for long periods of time isn’t good for them. Going through a regular cycle of discharge and charge is healthy for a battery, and will help to prolong its lifespan. Also, be sure to charge them in a well-ventilated area. This will prevent them from overheating.
Do golf cart batteries expire?
But for all the benefits of deep-cycle battery power, there’s no avoiding the inevitable expiry date. No battery can last forever. But when, exactly, is this expiry date?
How long do golf cart batteries last?
They may last anywhere from months, up to 5-7 years under the right circumstances.
What type of battery does a golf cart use?
These golf carts are commonly powered by lead-acid batteries with a 6, 8, or 12-volt deep-cycle. Unlike the battery in your car, golf cart batteries do not automatically ‘recharge’ themselves during use.
On Average, How Long Does It Take to Charge a Golf Cart Battery?
It takes on average 5-6 hours to fully charge a golf cart battery. Also, there are several factors affect a cart battery’s charging potential, so you must keep your battery in good condition and maintain it regularly.
How Long Does It Take to Fully Charge a 48v Golf Cart?
While battery charging time can change depending on the condition of your battery, it should take around 6 hours to fully charge a 48-volt golf cart battery.
How Long Does a Golf Cart Battery Last on One Charge?
In most instances, a golf cart will be capable of traveling between 25 – 40 miles before requiring a charge. In golf terms, that’s more than enough time to complete a couple of rounds of 18 hole golf.
Should You Charge Golf Cart Batteries Every Day?
It’s not necessary to charge your golf cart batteries every day unless, of course, you ride it every day. It’s a good idea to install an automatic charger that turns itself off once the battery is fully charged.
How Can I Make My Golf Cart Batteries Last Longer?
There are three main ways to ensure your golf cart batteries last longer. This includes ensuring you are following the correct charging technique, avoiding inferior charging products, and finally making sure you adhere to a simple battery maintenance schedule.
Should I Charge My Golf Cart in Tow or Run?
99 times out of 100, you should charge your golf cart in run. Tow should only be used if you’re not using your cart for an extended period of time or if you plan to take out the battery for whatever reason.
Should I Leave My Golf Cart Plugged in All the Time?
Overall, you should not leave your golf cart plugged in all the time. This is because your golf cart battery doesn’t need to be constantly connected to power to operate at full capacity.
