Golf-FAQ.com

how low does the batteries on a 48 volt golf cart get before the charger comes on

by Emilie Reichert Published 3 years ago Updated 2 years ago

What voltage should a 48 volt golf cart battery read?

Healthy batteries will indicate about 50 to 52 volts on the voltmeter. Most battery packs hold around 48 volts. Keep in mind that the high number doesn't mean that the batteries are instantly good. This measured value doesn't take the load or cart's power consumption into consideration.

How long does it take a 48 volt golf cart to charge?

Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.

How do I know if my golf cart battery is low?

Here are six signs to look for when batteries need replacing.Charge Times Are Out of Hand. ... No “Get Up and Go” ... You See Visual Signs. ... Driving Until They Die. ... People Are Always Running The Radio. ... Golf Cart Batteries Can Be Sensitive.

How often should you charge a 48 volt golf cart?

Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.

How do you test a 48 volt golf cart charger?

Turn on the Charger – Once you have the voltmeter attached to your battery charger, turn on the charger to read the electrical output. Typically, the needle on the voltmeter will move from left to right – with right being higher – to gauge the amps produced. A reading of about 36 amps is typical for a battery charger.

How do you tell when a golf cart is fully charged?

1:574:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipMost will flash or blink during charging and present a solid green light when finished.MoreMost will flash or blink during charging and present a solid green light when finished.

How long do 48 volt golf cart batteries last?

between five and ten yearsWhen you take care of your golf cart's battery, you can expect it to last anywhere between five and ten years.

How long should you charge a golf cart?

Your batteries should be fully recharged after 8-10 hours, but may require longer if they are older. You can purchase automatic golf cart battery chargers – such as this one from manufacturer LIYYOO – which will shut off once peak charge has been reached, ensuring the batteries aren't overcharged as a result.

Should you leave a golf cart plugged in all the time?

Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.

How long does it take to charge a 48V battery?

between 2.5 - 6 hoursFully charging a battery typically takes between 2.5 - 6 hours, depending on the type of battery charger. Here's how to work out how long a charger will take to charge your bike battery: Let's say you have a 48-volt battery with 10 amp hours* and a 2 amp charger.

How many miles can a 48V golf cart go?

The maximum range of this new battery when powering a 48V E-Z-GO RXV golf cart is approximately 20.5 miles when moving at 12 miles per hour. In golfing terms, this equates to around 3 rounds or 54 holes.

How often should you add water to golf cart batteries?

about once every 30 daysThe typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.

Find A New Golf Cart Battery Charger Or Batteries

1. All Golf Cart Chargers 2. Club Car Chargers 3. EZGO Chargers 4. Yamaha Chargers 5. Buyer's Guide - Picking the Best Golf Cart Charger. 6. Golf C...

Troubleshoot An Old Golf Cart Battery Charger & Batteries

1. Why is my golf cart battery charger not working? 2. I manually charged my batteries, that did not work, now what? 3. Do I have a battery or a ch...

Golf Cart Charger Questions

1. How do I choose a replacement charger for my Powerdrive, Powerwise, etc.? 2. What's the difference between the Links & Summit charger? 3. How lo...

Golf Cart Battery Questions

1. Do I have 6v, 8v or 12v golf cart batteries? 2. Do I have a 36 volt or 48 volt golf cart? 3. How long do golf cart batteries last? 4. How can I...

How far can a golf cart go with a new battery?

An electric golf cart with new batteries will go anywhere between 25 to 40 miles depending on the battery configuration, the model, and voltage of the cart.

Why do golf cart batteries need to be charged?

Charging. Batteries need to get fully charged between uses. Using your golf cart when your batteries aren’t fully charged leads to hard sulfation and can affect battery performance and the range of your batteries. Make sure your batteries have enough time to complete a charge cycle before using your cart.

What type of motor is used in a golf cart?

Golf carts are powered by either a 4-stroke internal combustion engine or a 36V or 48v electric AC or DC motor. Originally, these vehicles were only electrically powered, but with time, gasoline-powered variants started to emerge. Most communities prefer the electric version over gas powered carts for several reasons:

How does driving affect golf cart batteries?

Things like going uphill or carrying a large load for a long period can reduce the batteries function quickly .

How far can a golf cart go on a single charge?

You can also see golf carts go beyond 50 miles on a single charge, although you might not want to do that since it can shorten the battery life and can leave you stranded if the battery depletes beyond its power usage. Check out our golf cart maintenance and troubleshooting checklist for other tips.

How many amps does a golf battery use?

A typical round of golf will require about 40 minutes of run time while discharged at 56 amps. With all three configurations, the batteries have more than enough capacity to get through two rounds. But you’ll also want to look at the battery’s depth of discharge or DOD.

How does extra weight affect golf cart speed?

This is because the extra weight of the body and other operating parts put more strain on the drivetrain, requiring more power to move as compared to the lighter 2-seater cart. If you’re looking for ways to make your golf cart go faster, just know the extra weight also effects the golf cart speed as well. A typical round of golf will require about ...

How to tell 12 volt golf cart battery?

A 12 volt battery can be identified by seeing batteries with 6 cell caps on top of the battery indicating 2 volts per cell. A single 12 volt golf cart battery will have the least amperage capacity and is commonly used in 72 volt battery systems which are not terribly common among golf carts. EZGO golf cart batteries are known to be use 4-12 volt battery systems in some of their golf cart models.

How powerful is a golf cart battery?

Let’s take a close look at Voltage in a battery pack. For comparison, we like to take a look at cars since we are familiar with horsepower and miles per gallon (MPG). Therefore, voltage in a battery pack inside of an electric golf cart has to do with power. It does not have to do with fuel. Therefore, voltage in a battery pack within a golf cart will be comparable to the horsepower in a car. With this knowledge in place, we can determine a 72 volt system can be more powerful than a 48 volt system, and a 48 volt system can be more powerful than a 36 volt system. If you took notice, we said that it “can” be more powerful. The reason for this is due large in part to the controller inside the vehicle. A controller determines how much amperage is delivered from the batteries to the controller.

How much does it cost to replace a golf cart battery?

Pricing varies from pack to pack. The general consensus for golf cart battery replacement ranges from $600 on the low end to $1600 on the high end. If you are buying batteries in the lower end of the price range, then they are most likely cheap golf cart batteries that will not last as long (you really do get what you pay for when it comes to batteries). Some packs cost as much as $2500 when you start dealing with 72 Volt systems and sealed for lithium batteries. But, for the typical lead acid battery pack, $900 to $1500 is about the norm. This price range is assuming you are working with a local golf cart dealer.

How to tell if a golf cart battery is 6 volts?

A 6 volt golf cart battery can be identified by seeing batteries with 3 cell caps on top of the battery indicating 2 volts per cell. Generally speaking, a single 6 volt battery will have the highest amperage capacity and will allow for the greatest range in an 8-6 volt battery system.

Why are golf cart batteries so expensive?

Simply put, Golf Cart Batteries are expensive because you aren’t visiting the gas station every week. When you purchase them, you are essentially pre-paying for fuel. Yes, you still have to charge the vehicle, however the electricity cost usually breaks down to pennies per mile. In some studies, it was shown a golf cart costs less than $.02 per mile to operate in terms of electricity cost. Buying higher quality batteries versus cheaper ones will be better in the long run and will actually cost you less since you are replacing them less frequently.

How many miles can a golf cart go in a day?

However, if you have determined your Golf Cart use will be driven less than 5 miles per day, than you can have your pick of battery packs. Keep in mind though that a standard 18 holes of golf ranges between 5-7 miles per round depending on your handicap ;).

What to do when buying an electric golf cart?

If you are in the market to purchase an electric golf cart, then the simplest thing to do first and foremost is considering the age of your golf cart batteries. This is important due to many consumers being misled as to the age of the batteries in the cart they are purchasing. At times, a consumer will be told by a private party or dealer ...

How many volts does a golf cart battery need?

An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.

How to charge a golf cart battery?

You just hook up the red wire (the positive) to the positive terminal on the first battery in the set, and then hook the black wire (the negative) to the negative terminal on the last battery in the set. So, positive to positive, negative to negative. Forget about the blue wire (for more on the blue wire read What's the Blue Wire? ). The ring terminals on the leads are universal and will fit on all batteries. Because all of the golf cart batteries are connected with battery cables, all batteries will be charged in series.

What voltage do you need for a 36V golf cart?

You must match volts to volts. A 36V cart requires a 36 volt golf cart charger. A 48V cart requires a 48 volt golf cart charger. You can burn up your batteries if you do not charge with the proper voltage.

Why is my golf cart battery red?

Every golf cart battery charger is different with respect to indicator lights, but in general the red light is a fault light that indicates something is wrong with the charging process. Occasionally a red fault light on a golf cart charger can mean that the batteries do not have enough voltage in them to allow the charger to kick on (see Charging Dead Golf Cart Batteries above). However, most of the time, especially with EZ-GO Powerwise chargers, this is the "red light of death" or an internal charger failure indicating that the charger needs to be serviced or replaced.

Why is my golf cart battery charger not working?

Bad connections will cause any battery charger to not function properly. After you've charged up your batteries and checked every connection and you are still having issues, it's probably safe to say you've got a golf cart battery charger problem and may need to service it or buy a new one.

How long do golf cart batteries last?

If golf cart batteries are properly maintained they generally will last for around 5-6 years.

Why do you need to clean a golf cart battery?

You will need to clean it off because if it builds up it may cause the battery cables to lose contact with the battery and keep your cart from running. Again, please see our Golf Cart Battery Maintenance article for further details.

How to test a 48V golf cart charger?

First, you will need a voltmeter. Attach a voltmeter to the positive and negative clamps of your battery charger to calculate the amount of power it creates.

How many stages does a 48 volt golf cart charger take?

The current 48-volt battery charger theory employs microprocessor-controlled charging profiles in three stages, sometimes two or four stage s.

What is the voltage of a 48 volt battery charger?

The AGM/flooded 48 Volt charger’s absorption stage, roughly the remaining 20%, includes the charger keeping at the absorption voltage which is between 57.6 VDC and 58.8 VDC, depending on charger set points and progressively decreasing the current until the battery pack is fully charged.

Why does my battery charger hum?

If repairing the wires didn’t get your charger working again, you can turn it back on and listen for the battery charger’s humming. The presence of a humming sound suggests that the transformer is operational, but the absence of a hum indicates a serious problem that may necessitate transformer replacement.

Why is my golf cart battery charger not turning on?

If your charger isn’t turning on, make sure it has some charge by hooking it to a car battery and check the wiring as well .

What happens if your battery charger fails?

You can become stranded if your batteries run out. If your battery charger ever fails, you should be able to figure out what’s wrong and how to fix it. You won’t be able to fix every issue with a quick DIY fix, but a thorough diagnosis will save you hours of frustration.

How to retain battery power?

To retain battery power and service life, follow the battery manufacturer’s instructions for charging procedures and voltages, or use a high-quality microprocessor-controlled charger.

Can you turn off the radio on a golf cart?

Any lights, radio, or electric components in your cart should always be turned off when you stop using it. Leaving the radio or lights running on an idle golf cart can run down the battery incredibly quickly. In the case of a gasoline-powered golf cart, you may end up having to jump-start the cart to get it working again if this happens.

Can you use an automatic battery charger when it is fully charged?

It's important to make sure you're using an automatic battery charger that will stop being active as soon as the battery is fully charged. We've had clients come in with what they felt were "bad" batteries, only to have to explain to them that the battery had simply been damaged by being overcharged too many times.

Can you use a bad boy golf cart for long distances?

Many of our great E-Z-Go, Cushman, and Bad Boy options are designed for longer-distance use, but even they have their limits. Forcing your golf cart up very steep hills or to go longer distances than it is made for will run the battery down and could leave you stranded. Just keep a careful eye on distance traveled and consider using a truck or trailer when transporting your golf cart longer distances.

Should golf cart batteries be charged?

Another common issue is golf cart owners who think that golf cart batteries should only be charged when they've become very low. If you drive your golf cart that day? Charge the battery. Letting golf cart batteries run down until near-empty or totally dead will damage them over time just as much as overcharging them.

A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9