An EZGO RXV golf cart won’t charge because of a dead battery, low battery pack voltage, a non-charging charger or a faulty battery cable. Measure the positive and negative voltages of the battery pack using a multimeter. Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart.
Full Answer
Why is my EZGO golf cart not charging?
Why is my EZGO golf cart not charging? Your EZGO golf cart may not be charging due to problems with batteries or the charger. It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries.
How many amps should a golf cart battery charger have?
They will flash red if your cart's batteries are significantly discharged, and green if the amount of discharge is slight. You should also see a total amperage of approximately 21 amps on the charger. Charge the cart batteries until the charger turns off.
Are EZ GO golf carts any good?
Their products are well-known for being some of the most reliably built golf carts on the market with both electric and gas powered options available when you are shopping for a cart. A common task for the electric golf cart owner is charging your EZ Go Golf Cart.
What is amperage in an electric golf car?
It determines how far you can travel before having to fill up the tank. Well, Amperage in a golf cart is like the gas tank in your car. It will determine how far you can travel on a single charge in an electric Golf Car. The more amperage in a battery pack, the further you can drive before having to charge.
How many amps should my golf cart charger show?
The ammeter on a 36-volt charger should show at least 15+ amps when the charger is plugged into the golf car, even if the batteries have not been used for a short while. A 15+ amp reading shows that the charger is actually charging, not just humming (humming is NOT an indication that the charger actually works).
How many volts should a golf cart charger put out?
They require a minimal number of volts to begin charging. At least 20-25 volts across the set will be required for a 36 volt golf cart. At least 30-35 volts across the set will be required for a 48 volt golf cart. Please see above for charging dead batteries.
How many amps is a ezgo golf cart charger?
EZ-GO Golf Cart Charger 25 Amp.
How many volts is a full charge on a 36 volt golf cart?
The peak charging voltage for Gel batteries is 2.3 to 2.36 volts per cell, and for a 36 volt charger this works out to 41.4 to 42.5 volts, which is lower than a wet or AGM type battery needs for a full charge.
How do I know when my ezgo golf cart is fully charged?
The charger will begin charging as soon as it is plugged into the cart. Allow the charger to complete the full charging cycle; unplugging the charger before the cycle is complete will result in damaged batteries. When the LED displays long red flashes, the battery is fully charged.
How do I know if my golf cart is charging?
1:564:02How Do I Read My Golf Cart Charger? | ASK DAVE - YouTubeYouTubeStart of suggested clipEnd of suggested clipOff if you're using a more modern style charger like this one you'll find led indicator lights toMoreOff if you're using a more modern style charger like this one you'll find led indicator lights to show that charging is in progress depending on the make.
How many amps does a 12 volt golf cart battery have?
6 vs 8 vs 12-Volt Golf Cart Batteries – Runtime at 56 Amps The average runtime minutes at 56 amps was 164 for the 6-volt batteries. 8-volt batteries averaged 128 minutes of runtime. While the 12-volt options clocked 110 minutes of runtime.
How many volts is a full charge on a 48 volt golf cart?
55.2 to 56.6 voltsThe peak charging voltage for Gel batteries is 2.3 to 2.36 volts per cell, and for a 48 volt charger this works out to 55.2 to 56.6 volts, which is lower than a wet or AGM type battery needs for a full charge.
How long does it take to charge a 36 volt ezgo golf cart?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
Does the AMP matter on a golf cart charger?
Otherwise they are very different. Any 36-volt battery charger should initially start by providing at least 15+ amps to the batteries. The amps may drop down very quickly if the batteries are fully charged but the ammeter should show at least 15 amps to start off.
How many amps does a 36v golf cart need?
The Importance of Distinguishing your Battery PackBattery SystemTotal VoltsTotal Amps (Approx)6-6 Volts36 Volts1,3504-12 Volts48 Volts6006-8 Volts48 Volts1,0208-6 Volts48 Volts1,8001 more row•Jan 30, 2017
How many volts is an EZGo golf cart?
The electrical drive system powered for EZGo golf carts is either 36-volt or 48-volt. Some newer models are 72 volts. This requires a combination of multiple batteries in other to work properly.
How many volts does a golf cart have?
There is a major difference between 36 volt up to 48 volt systems, impacting both performance and potential upkeep and maintenance costs. Hint: some batteries are much more expensive ...
What is the amperage of a golf cart?
Golf Cart Battery Amps. Amperage can be considered akin to the fuel in a gas-powered engine. Similar to a tank of gas, the amount of amperage will dictate how far you can drive your cart on a single electric charge.
What does voltage mean in a battery pack?
Voltage represents how much power your system will be delivered, resulting in increased ability to tow, carry more weight, and accelerate faster.
Does a golf cart battery need to be recharged?
In this regard, a higher voltage (although more powerful) often comes at a cost. That cost is that it can burn through more amps faster, draining the golf cart battery quicker, and requiring you to recharge more frequently.
How Many Batteries Are In a Golf Cart?
An electric golf cart will have either 4, 6 or 8 golf cart batteries and will have either a 36 volt or 48 volt electrical drive system.
48 Volt Golf Cart Voltage Example (12V Batteries)
If you have additional questions about your batteries or charger, check out our Battery Charger Frequently Asked Questions page or learn about how amperage works in a golf cart.
How to charge a golf cart?
Step 2. Confirm the golf cart battery charger by inserting it into a power source (wall outlet) and then plugging the charger plug into your golf cart's charging receptacle. Step 3.
What happens if you don't charge your battery?
If you do not allow the charger to fully charge the batteries, they can become unbalanced and require replacement sooner than normal. Step 5. Conduct an equalization charge monthly in order to eliminate sulfation and stratification.
What does it mean when your cart lights up red?
They will flash red if your cart's batteries are significantly discharged, and green if the amount of discharge is slight. You should also see a total amperage of approximately 21 amps on the charger. Charge the cart batteries until the charger turns off.
Where is the battery bank?
You will find the battery bank for your golf cart directly under the drivers seat. In some cases the battery system is quite large and will most likely be continued under the front nose cone area of popular carts like Gem cars or other 4 or more passenger golf carts.
What do you see there?
Ok, so you pull the seat back and what do you see? Here is an example of a popular golf cart. This picture is of a older style club car with a 36 volt battery system. Which is easily determined because you will count (6) six batteries.
Another example
Here is another example to make sure you got it. How many volts are found in this battery system found in a late model motor coach waiting for new batteries to be installed? Again 1,2,3 = 6 volts (2 volts x 3) 1,2,3,4,5,6 = 6 volts batteries = 36 volts total (6 volts x 6 batteries) Hey, You are getting good at this! Here is one more for you.
Our shop cart test
Our shop cart has 4 batteries under the seat but each battery has (6) six filler holes or cells on each battery. Would this be a 48 volt system? Yes, It is a 48 volt system because you have 6 cells per battery and you have 4 batteries. (6 cells x 2 volts = 12 volts) (4 x 12 volt batteries = 48 volts).
How many volts should a jumper have before it is shorted?
Before the jumper is shorted to ground, the voltage at B+ should, of course, reflect the charge state of the battery (around 12 volts), but when the jumper is touched to ground (which is what the Voltage Regulator does in instantaneous bursts), the voltage at B+ should rise as the motor’s speed is increased.
How many volts should a starter generator output?
It should peak at about 15 volts (the maximum output of the Starter/Generator’s charge ability). If it does increase, then the Starter/Generator is alright. If it doesn’t, there is a problem with the Starter/Generator.
How fast can a golf car go?
Consumer golf cars or personal transport vehicles (PTVs) often can have a top speed of 19.5 mph. This speed comes at the expense of the run time of your batteries. Golf courses usually have the speed of their fleets set at 12 – 15 mph.
What size batteries are used in golf cars?
Golf car batteries are generally build in three different sizes. 6V, 8V, and 12V. Usually, the run time on the battery is inversely related to the battery voltage rating. Meaning, that a 48V golf car with 4 x 12V batteries will have a shorter run time than a 48V golf car with 6 x 8V batteries.
What will increase the drag on a golf car?
Terrain that has steep hills will require more power from the motor and from the batteries. Wet, soft ground will increase the drag on the golf car and limit the efficiency, causing the motor and batteries to supply more power. Hard, flat terrain will extend the driving time of the batteries.
What factors should be considered when driving a golf car?
Any terrain that limits the amount of work the golf car has to do will also limit the amount of power consumed from the batteries. Terrain that has steep hills will require more power from the motor and from the batteries.
What is the most common golf car battery?
Historically, the most common golf car battery was the “wet cell” FLA. The price and quality of this type of battery can vary significantly due to manufacturing materials and processes.
How much pressure should a golf tire be?
The tire pressure on a standard golf car tire should be inflated to 22 psi. Under-inflated tires causes significantly more friction and drag, causing the golf car electric motor to work harder and pull more power from the batteries, thus reducing the driving time.
Do Yamaha golf cars have AGM batteries?
They are maintenance free batteries, which is nice, unfortunately, they do not perform well as an electric golf car’s source of power. In 2020, Yamaha Golf Cars announced that they are outfitting their electric golf cars with AGM batteries. Early tests are not encouraging.
How many volts does a golf cart use?
Golf carts that are powered by 48 Volts consist of either (6) 8 Volt batteries or, in the case of some Club Car Precedent golf carts, (4) 12 Volt batteries.
What is voltage in golf carts?
Technically speaking, voltage is the potential difference in charge between two points in an electrical field. The greater the voltage is, the greater the current.
How to tell if a golf cart is 36V or 48V?
To determine whether your golf cart is 36V or 48V, follow these steps: Lift up the seat to view the battery compartment. Count the number of holes on each battery. You may need to remove the battery cap to see the holes.
How to determine golf cart battery voltage?
Count the number of holes on each battery. You may need to remove the battery cap to see the holes. Multiply the number of holes by 2 to determine the golf cart battery voltage. Multiply the golf cart battery voltage by the total number of batteries.
Is it more expensive to replace a 12 volt battery?
Batteries are more expensive to replace. If the system uses 12 Volt batteries, run time will be less due to a lower battery lead volume. Replacement motors and controllers are typically more expensive. 48 Volt cart are more expensive to purchase. Whether you decide to go with a 36 Volt or a 48 Volt, the important thing is ...
Can a 36V golf cart be used off road?
They produce less power than 48 Volt systems. They are less efficient and therefore, yield fewer hours on a charge. It is not recommended that a 36V golf cart be used offroad, since it has less power.
Why won't my Ezgo golf cart charge?
Some reasons why an EZGO RXV golf cart will not charge could be because of a dirty charging port, loose or broken wire, a blown-out fuse or a problem with the auxiliary contact. Clean the charging port so that it’s free of dust and dirt accumulation. Sometimes, dust and dirt can prevent proper charging.
How many volts does an EZGO 2012 hold?
Check the battery pack voltage using a multimeter. For a 48-volt cart, this should be between 46 to 50 volts based on the charge level.
How to check if golf cart battery charger is faulty?
The charger may be faulty. Check this by plugging the charger into the golf cart and see how much it charges the battery pack using a digital voltmeter. Alternatively, you can use another charger to do the charging and see if there is a difference. Allow the charger to charge the pack fully and shut down on its own.
How many volts should a golf cart battery pack have?
Charge two batteries at a time with a 12-volt charger and then use the auto golf cart charger to resume the charging. The battery pack must have at least 28 volts for the cart charger to be able to kick in. Also, ensure that the battery plates have at least 1/4 inch of distilled water above them before charging.
Why is my Ezgo cart not charging?
It could be due to a lack of battery voltage, a faulty charger or a lack of hydrogen in the batteries. A charger problem can also be associated with the charger making a loud clicking noise, failing to stop charging after the batteries have attained full charge ...
How many volts should a 48 volt battery be?
Depending on the charge level, it should read between 46 to 50 volts for a 48-volt cart. If the reading is abnormally low such as 16 volts or 24 volts, check the voltage of each battery individually by hooking on to a regular charger. Also, check the water level in each battery.
How to check if a voltage regulator is faulty?
To check if the regulator is defective, remove the green wire connecting the generator and the stator at the generator end. Get the engine running, ground the disconnected end and check the voltage rating using a voltmeter.