How to Adjust the Governor on a Gas E-Z-Go Golf Cart
- Locate the governor arm mounted on top of the rear axle case underneath the cart. ...
- Loosen the adjusting locknut on the end of the governor spring. Rotate the locknut to expand or compress the spring until its length is 2 1/2 inches.
- Retighten the adjusting locknut.
How do you take the governor off a golf cart?
Method 2 Loosen the nut attached to the governor arm with a 7/16” wrench to turn the shaft. Push the governor arm to the back of the cart and grasp it with your hand. Turn the governor shaft in the counter-clockwise direction until it cannot be turned further. Retighten the nut and let …
How to disconnect the governor on golf carts?
How to Adjust the Governor on a Golf Cart. Step 1. Look for a small metal rod near your golf cart’s clutch. If you find this rod, then your governor can be easily adjusted by accessing the ...
How to adjust the governor on a Yamaha golf cart?
Mar 08, 2022 · On A Gas Club Golf Cart How Do You Adjust The Governor?? You can make this governor better by adjusting the nut on the cable at the throttle lever. The cable will effectively prevent it from pulling your golf cart’s throttle lever back by making the throttle lever longer, so your top speed will be higher.
How to remove Governor on a club car golf cart?
By mechanically pulling the throttle lever back, you decrease the gas flow to the engine and control the golf cart’s speed. This governor can be adjusted by adjusting the cable nut which holds the cable to the throttle lever.
How do you adjust the governor on a gas club golf cart?
0:040:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt looks up look inside. There's 12 cable down right here this lever you want to lift up and BendMoreIt looks up look inside. There's 12 cable down right here this lever you want to lift up and Bend and that pulls on the cable a little more.
What does the governor do on a golf cart?
0:061:28Where Is a Golf Cart Governor Located? - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt is a control speed.MoreIt is a control speed.
How do I increase the speed of my EZ Go golf cart?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.Jun 16, 2015
How can I make my Gas Club Car golf cart go faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.May 18, 2021
Why is my gas golf cart slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.Jul 14, 2021
Is there a governor on a golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.Oct 4, 2021
How do I get more torque out of my gas golf cart?
Change the Speed ControllerThe Speed Controller regulates the electric output of the motor; a higher voltage equals more RPM, and the faster your cart will travel. When you change the speed controller, you can reduce the voltage and increase the amperage of the motor, resulting in increased torque.Dec 2, 2016
How can I make my g22 golf cart go faster?
0:291:37How to make your Yamaha Gas Golf Cart go faster. 2007-2018 - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo your governors is right in the back. You markedly get a little faster you can tighten this justMoreSo your governors is right in the back. You markedly get a little faster you can tighten this just not if the closer you go this way it'll make it go faster. And anything loosen to not.
How to make a golf cart go faster?
Loosen the small nut and tighten the larger nut. The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.
How fast can a golf cart go?
Adjusting the governor can make your golf cart go 5–10 mph (8 .0–16.1 km/h) faster. If you do this to an E-Z-GO golf cart, you might be able to go from 15 mph (24 km/h) to 22 mph (35 km/h). It will only take about 5 minutes to do it. Steps.
How to get a cart to move faster?
1. Remove the seat and plastic covering over the engine. Sometimes you'll need to remove screws while some models have seats that pop right out. Expose the engine so that you can get to work adjusting the motor. If you don't have a central governor spring, you can still get your cart to move a little faster.
How to change the speed of a car?
Locate your clutch pedal and line. The clutch is the pedal (sometimes a handle near your knee) that you use to put the car into reverse or change speeds. You can adjust the clutch to send more gas to your engine, moving you faster. ...
How to get to the engine on a golf cart?
Open up your golf cart’s access panel to get to the engine. In many cases, the panel pops open like a car hood, but in some instances you’ll need to unscrew the panel first.
Who is Richard Kalinowski?
Richard Kalinowski began writing professionally in 2006. He also works as a website programmer and graphic designer for several clients . Kalinowski holds a Master of Fine Arts from Goddard College and a Bachelor of Science in education from the University of Wisconsin-Whitewater.
Can a golf cart be a nuisance?
In practice, golf carts can be more of a nuisance than a help, as many standard carts creep along at unbearably slow speeds. Luckily, you don’t have to stick with these standard speeds. Golf cart speed is often controlled by a device called a governor, and you can adjust the governor on a golf cart relatively easily to make the cart faster.
