The governor on a golf cart can be adjusted easily by loosening the tension on its springs using a wrench or screwdriver to get the golf cart going at a relatively faster speed. In some cases, the adjustment can be done by turning the cable nut that connects the cable to the throttle lever in the counter-clockwise direction.
How do I adjust the front end on a RXV golf cart?
For a 2010 EZGO RXV golf cart, the front-end adjustment can be done by doing a 1/8 to 1/4 inches toe-in adjustment at the ends of the tie rods off the steering box. You can consider pulling the tires and using a straight edge object for an accurate 1/8 inches toe-in adjustment.
How do I align my 2008 EZGO RXV golf cart?
For a 2008 EZGO RXV golf cart with a recently installed lift, it’s recommended that you take it to the person who installed the lift to get the front-end alignment done, along with a toe-in check and adjustment.
How do you adjust the governor on a golf cart?
Loosen the adjusting locknut on the end of the governor spring. Rotate the locknut to expand or compress the spring until its length is 2 1/2 inches. Retighten the adjusting locknut. Road test the cart by timing it over a course of known length at full speed to verify that the governor is controlling the speed within factory specifications.
How do you bypass the governor on an EZGO golf cart?
You can bypass the governor connection in an EZGO or Yamaha G1 golf cart as given below. Remove the cable connecting the carburetor and the governor. Disconnect the connection between the gas pedal and the governor. Connect the gas pedal directly to the carburetor opening.
How do you adjust the governor on a EZ Go RXV?
1:065:06How to Adjust an E Z Go Golf Cart Governor - WikiVideo - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut.MoreIf you are curious this is your carts carburetor loosen the small nut and tighten the larger nut. The more you tighten the larger nut the faster your cart will.
How do I speed up my EZ Go RXV golf cart?
Your cart will thank you in the long-run.Upgrade Your Golf Cart Motor.Improve Golf Cart's High-Speed Controller / Solenoid Contactor Relay.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Keep Your Cart Light / Keep It Clean.
How do you adjust the governor on a golf cart?
Adjusting an EZ-GO Golf Cart GovernorStep 1 - First, lift the seat of your engine to reveal seat cousins. ... Step 2 - Remove the seat cushions over your motor. ... Step 3 - Remove the black plastic cover to expose the motor. ... Step 4 - Loosen the smaller one and tighten the larger one to increase your cart's speed.More items...•
How can I make my golf cart governor faster?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How fast will a ezgo Rxv go?
The fastest EZGO electric golf cart is the EZGO Freedom RXV which can reach speeds up to 19.5mph.
How do I put my ezgo Rxv in Freedom mode?
Toggle the forward/reverse switch from the "neutral" position to "reverse" five times in quick succession. After a few seconds, the computer controller will beep four times, indicating it has shifted into the freedom mode. Flip the run-tow switch back to “tow” and then "run” to escape the diagnostic setting mode.
How do you remove the speed limiter on a electric golf cart?
Basically, an electric speed governor can be controlled by a tiny metal rod that's located by the clutch of your golf cart. First things first: The electric speed governor is connected to a cable. You can adjust your speed by rotating the nut in a counterclockwise rotation.
How do you remove a speed limiter from a golf cart?
0:040:46How to remove governor on a Club Car golf cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo the farther you bend that normally the faster it goes and then that's it basically when you wantMoreSo the farther you bend that normally the faster it goes and then that's it basically when you want to return your heart you just bend that back down and go back to normal speed.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
How do I turn off speed governor?
1:072:00How to remove your car's speed limiter como sacar limitacion de ...YouTubeStart of suggested clipEnd of suggested clipSelect on that and then. When you press cancel it means you're done and the tune will start toMoreSelect on that and then. When you press cancel it means you're done and the tune will start to upload you'll hear the fan kick on and then when you're all done it'll say the press select to enter.
What does removing the governor do?
Removing the governor will increase the maximum rpm of the engine, but the internal parts of the Predator 212 are designed for 3600 rpm. Generally, this isn't an issue with just the governor removal, the internal parts can usually withstand 5000 rpm without breaking apart (unless you go full throttle for too long).
Why is my golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
How to adjust EZ Go cart governor?
To adjust an EZ Go Cart Governor engine, start by removing the seat so that you can access the engine. Once the seat is off, remove the screws from the black plastic cover at the rear of the seat and then set the cover aside.
How to make a golf cart go faster?
Loosen the small nut and tighten the larger nut. The more you tighten the larger nut, the faster your cart will go. Start slowly, only tightening the nut a quarter turn to start. You can over-stress the engine if you try to run it too quickly, and it will skip and potentially burn out if you are too eager.
How to get a cart to move faster?
1. Remove the seat and plastic covering over the engine. Sometimes you'll need to remove screws while some models have seats that pop right out. Expose the engine so that you can get to work adjusting the motor. If you don't have a central governor spring, you can still get your cart to move a little faster.
How fast can a golf cart go?
Adjusting the governor can make your golf cart go 5–10 mph (8 .0–16.1 km/h) faster. If you do this to an E-Z-GO golf cart, you might be able to go from 15 mph (24 km/h) to 22 mph (35 km/h). It will only take about 5 minutes to do it. Steps.
How many screws are in a golf cart engine?
There should be five screws in most models. The engine is in the front of golf carts, underneath this panel. Take off the plastic cover and set it aside with the seats. ...
How to change the speed of a car?
Locate your clutch pedal and line. The clutch is the pedal (sometimes a handle near your knee) that you use to put the car into reverse or change speeds. You can adjust the clutch to send more gas to your engine, moving you faster. ...
How to raise the top speed of a golf cart?
To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly. If you cannot find this spring, you likely have a newer model that is more difficult to adjust, though this is rare. Lift up the seat. Remove the seat cousins, which hide the engine.
How to run a golf cart?
Turn each wheel around and mark a line around the tire circumference in the middle of the tread pattern. Bring the vehicle to rest on the ground and ensure that the tires are positioned pointing straight ahead. Move the golf cart forward by about five feet so that the tires are in the usual running position.
How to make a golf cart spin?
Use a crayon or chalk and draw a circle on one of the front tires in the middle of the thread as it’s spinning. Repeat the above step for the other front tire as well. Rest the golf cart on the ground and move it forward or backward by a few feet. Measure the distance between the lines on the front and back of the tires.
Why does my EZGO RXV shake?
The front end of an EZGO RXV may shake or vibrate due to one or more reasons. You may have an improper toe-in adjustment or there may not be sufficient pressure in the tires. You can do the following if the front end shakes when an EZGO PCS cart moves at a relatively high speed.
How to check if golf cart tire is bulging?
Jack up the golf cart in such a way that only a single end is lifted at a time with just enough ground clearance. Keep a spray can or any object with a straight edge at a distance of about 1/8 inches from the tire to check if it has bulges on the side.
How to check alignment on a cart?
Spin the front wheels using your hand. You can also check the alignment when they are in the air. Use a crayon or chalk and draw a circle on one of the front tires in the middle of the thread as it’s spinning.
Why do you need front end adjustments on a golf cart?
Front end adjustments for most golf carts are needed because of damaged parts like bent A-arms or bent or worn out tie rods as well as worn out bushings.
How to tighten tie rods?
To do this, you’ll have to turn the rods either counterclockwise or clockwise. If the rods feel snug, pour some penetrating oil on them. Tighten the nuts on either end of the tie rods and take a re-measurement to ensure that nothing has moved out of place. Grease the steering gear, spindles and ball joints.
How to get more speed out of golf cart?
Upgrading tires and increasing your tire size is by far one of the most economical and easiest ways to get more speed out of your golf cart. Equally applied, this is a great solution for both gas and electric golf carts. If you install a tire with a larger diameter on your golf cart, the end result is a higher top speed.
How does a new battery work on a golf cart?
Simply put, most types of golf carts are designed to work with a range of different batteries. A new battery will increase a golf cart’s motor output. The result of the motor output increase is higher speed. Purchasing new batteries with a higher voltage maximum will increase your golf cart’s speed dramatically.
How fast can a golf cart go?
Most new and used golf carts are made to go a top speed of around 15 miles per hour . Although that is the perfect speed for most folks, there is an equal amount (if not more) of folks out there who are looking to increase their golf cart top speed and go faster than 20 MPH let's say.
What is a series wound DC motor?
Series Wound DC Torque Motors are made with a larger field coil inside. A larger field coil inside of the motor , allows a larger magnetic field generation and holds the armature much more securely, thus producing greater torque. This is an excellent option if you're looking for more torque in your Club Car, EZGO or Yamaha golf cart, but are not so concerned about the speed.
Is there a catch all solution to increasing golf cart speed?
A golf-cart weighed down by unnecessary clutter and debris is not a happy golf-cart! In closing, something to keep in mind is: There is no "catch-all" solution to increasing golf cart speed / golf cart power. There are many factors to consider such as, how the parts, pieces and changes interact with your golf cart.
Can you install a torque motor in an electric golf cart?
Essentially, installing a torque motor or speed motor may not be the end solution. With that said, something that you will want to keep in mind as you are upgrading, are the two main/major electrical components within your electric golf cart, that play a huge role in your golf carts system:
Do you need a lift kit for a golf cart?
Note: Depending on the size of the tire and the make/model of your golf cart, some golf carts will require a lift kit to accommodate the size of the new tires. If you are unsure whether you need a lift kit for your golf cart before replacing them, we have an excellent Resource that discusses this topic in more depth.
How to make a cart faster?
Step 1. The first option to making your cart faster is to replace the electronic speed control. This will enable more voltage to pass to the motor, producing the desired result. Unfortunately, this upgrade is not inexpensive as the unit can run anywhere from $100 to $1,000. Step 2.
How fast can a factory cart go?
The factory gear most likely has a 12.5:1 ratio, which allows the cart to achieve somewhere around 14 mph. If you swap out the factory gear for one with an 8:1 gear ratio, you'll up your top end to about 20 mph.
Can you drive a golf cart faster?
It should be noted that the golf cart you are trying to make faster may not be designed to do so. Weigh the options carefully and exercise caution whenever driving a golf cart at any speed. Remember that golf carts are not equipped with seat belts, air bags and other safety equipment that you find in automobiles.
