To change the oil of the EZGO Marathon golf cart, you are advised to twist and take off the engine’s cap. After doing so, you would need to insert a funnel at the opening and start pouring engine oil through it. You can use either 10W-30 or 10W-40 for this purpose depending upon the place you are living in.
Full Answer
How do I change the motor in my EZGO electric golf cart?
You may wish to change the electric motor in your EZGO electric golf cart and replace it with a new one. Some carts motors can be difficult to change. The first step is to remove the wires connecting the battery pack to ensure that the cart has no power. It is advisable to use protective gloves. Do not use wristwatch, rings or jewelry.
How do I tune-up my E-Z-Go gasoline engine?
These are the easy steps to perform a basic tune-up on your E-Z-Go gasoline engine using a minimum of tools and an optional tune-up kit. As always, we begin with the three basics…Air, fuel, spark. Unsure of your year and model?
What to do if your golf cart has no power?
The first step is to remove the wires connecting the battery pack to ensure that the cart has no power. It is advisable to use protective gloves. Do not use wristwatch, rings or jewelry. If you have to access the motor from below the rear seat, you must lift the rear of the cart using a jack.
How do you remove the belt from a golf cart starter?
The easiest way is to rotate the clutch towards the cart’s rear to slip off the belt. Remove the belt and keep it aside. Use the 8mm wrench to disconnect the ‘DF’ wire from the starter. Next, use the 10mm socket to remove the ground strap from the starter/generator and remove the part from the cart.
How do you change the body on a EZGO golf cart?
7:289:35EZGO TXT Body Removal | How to Remove Golf Cart Body | Episode 1YouTubeStart of suggested clipEnd of suggested clipWe've got all the rivets. Taken out of the rear body. So now we'll do is remove this rear bodyMoreWe've got all the rivets. Taken out of the rear body. So now we'll do is remove this rear body before we remove it let's go up front make sure this the front part of the rear body is up.
How do you change the oil on a EZGO TXT?
0:368:54Ez-Go golf cart oil change - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou remove those three bolts and there'll be an oil filter that'll pop out so if you give me aMoreYou remove those three bolts and there'll be an oil filter that'll pop out so if you give me a couple of seconds i'm going to remove those three bolts and i'll show you what i'm talking about.
How do I remove the motor from my EZGO golf cart?
3:109:45EZGO High Torque Electric Motor Swap | How To Install Golf Cart MotorYouTubeStart of suggested clipEnd of suggested clipOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock thatMoreOff while it's up in the air let's go ahead and we want to loosen and remove the rear shock that gives you direct access. So you can unbolt it loosen everything and put it right out the side.
What oil does a EZGO golf cart use?
10W-30 grade10W-30 grade engine oil.
Do ezgo golf carts have oil filters?
In every EZGO golf cart; there is an oil filter present presumably at the bottom of the vehicle.
Do golf carts have oil filters?
If you're new to Yamaha golf carts, you may be wondering “Do Yamaha Golf Carts Have Oil Filters?” The simple answer is no, most Yamaha golf carts do not have oil filters included in their engines.
How do you install a new golf cart motor?
4:155:58EZGO RXV Golf Cart Motor Removal & Installation How-To - YouTubeYouTubeStart of suggested clipEnd of suggested clipFirst we're going to run our main drive wires back to the front of the golf cart and the controller.MoreFirst we're going to run our main drive wires back to the front of the golf cart and the controller. Next we'll install our cable. Connectors. Not forgetting our motor.
Where is the reset button on a ezgo golf cart motor?
Locate the motor Remove the panel so the electric motor is visible. Electric motors usually include reset buttons that can perform similar to circuit breakers. Look in the area where several electrical wires enter the motor and locate a small red button. This is the reset button.
Are golf cart motors interchangeable?
The motors and controllers are in no way interchangeable between a series and separately excited system, so be sure to educate yourself prior to ordering.
How often should you change the oil in a golf cart?
If your golf cart is used often, you'll want to check on it more than that. You'll need to replace your engine oil and filter semi-annually, generally once it hits around 125 rounds or 600 miles of usage. For new engines, your initial oil change should be after 8 hours of run time.
Can I use synthetic oil in my ezgo golf cart?
Yes! We are pleased to tell you that it is indeed possible for you to use synthetic oil in your gas golf cart.
How many quarts of oil does a golf cart?
How much Oil does a Club Car Golf Cart need? A club car golf cart that comes with the gasoline engine can hold from about 1 ½ to 1 ¼ quarts 10w-30 oil.
Step 1: Air filter
The canister air filter is accessed by raising and lifting out the cart seat, locating the cylindrically shaped airbox with a cap on the end, and unsnapping the two holding clips on each side. Remove the lid and then the filter.
Step2: Spark Plugs
The recommended spark plugs are manufactured by NGK, number NGK BPR4ES. Locate the spark plug (s) on the top of the engine and remove the cable, exposing the top of the plug. Use a spark plug socket and ratchet to remove the spark plug and inspect the ceramic insulator.
Step 3: Fuel
The fuel filter is located in line between the fuel tank and the fuel pump. If the housing is clear plastic, make sure that the fuel inside is not dark amber or discolored from age.
Step 4: Valve Adjustment
Check and adjust the valves every 250 hours or every year To keep the engine starting and running properly.
Conclusion
All of these adjustments can be made on your EzGo Golf Cart without spending anything more than your time, BUT if any of the components are damaged, such as the gaskets, plugs or if the filters are too far gone to blow the dirt out of them, it is time to open the old wallet.
