how to change carburetor on yamaha golf cart

by Lee Zieme PhD Published 3 years ago Updated 2 years ago

How to Adjust Yamaha Golf Cart Carburetor Yamaha G9 Carburetor Adjustment. Pull out the pilot adjustment screw. It must be present at a sharp point and not a flat spot. Rethread the screw back until it’s slightly seated. Turn the screw outwards by 1-1/2 turns. Push the throttle stop screw backward until the throttle shaft is closed completely.

Part of a video titled Yamaha Golf Cart G29 Carburetor Swap fast. - YouTube

0:03

16:55

Okay get the seat off raise it up lift it off okay before we get started this is all tools you'reMoreOkay get the seat off raise it up lift it off okay before we get started this is all tools you're going to need phillips 10 millimeter short extension 12 millimeter for the carburetor.

Full Answer

How to adjust a carburetor on a golf cart?

Jul 24, 2017 · Golf cart carburetor linkhttp://m.ebay.com/itm/CARBURETOR-Carb-1996-2003-EZGO-Golf-Carts-4-Cycle-350cc-ROBIN-Engine-72558-G05-/272524029100?epid=0&hash=item3...

How do you slow down a gas Yamaha golf cart?

How to properly charge your golf cart Yamaha?

Sep 24, 2016 · 9_ 23_2016, Yamaha Golf Cart $20 carb replacement, fits models G2 thru G11, years 1985 - 1995, 3 pieces to a running motor, a mechanically functional block,...

Why does my Yamaha golf cart backfire?

Feb 12, 2011 · #2 Yamaha G2 Golf Cart Tuneup - battery, airfilter and carburetor. Golf cart repair, maintenance, and tuneup. Fixing the battery, airfilter and carburetor.

Why is my Yamaha golf cart backfiring?

Engine backfiring occurs when there is an air leak within your golf cart or sometimes when there is too much fuel inside. This can cause the piston to slam against the cylinder head and cause a tapping sound. An essential component of any golf cart is the drive belt.

How do you adjust a carburetor on a golf cart?

Find the pilot adjustment screw on the edge of your carburetor. Pay attention to this screw – it should be a sharp point and not flat. Carefully remove this screw and then carefully screw it back. Turn this screw out one and one-half turns to adjust it properly.

How can I make my Yamaha golf cart faster?

Part of a video titled Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!

0:00

5:15

Itself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.

How do you clean the carburetor on a Yamaha golf cart?

Part of a video titled How to Make a Golf Cart Run Better - YouTube

2:12

17:47

Now in our good thing that works for cleaning these carbs is old toothbrushes it helps you to getMoreNow in our good thing that works for cleaning these carbs is old toothbrushes it helps you to get into all the nooks and crannies here.

Why does my golf cart only run with the choke on?

Cart Runs Only When Choke is On

This is normally due to a blockage in the fuel line. Another cause is the accumulation of dirt or other debris in the carburetor. To fix this issue, check for any blockages in the fuel line and other engine components.Dec 2, 2021

How do you idle a Yamaha golf cart?

Push the throttle cable toward the throttle valve body on the engine from the gas pedal position. Screw the throttle cable back in place on both the gas pedal and the throttle valve body on the engine. The golf cart will idle rather than shut off.

How fast will a Yamaha gas golf cart go?

19 mph

Although, new gasoline and electric golf cart versions of Yamaha all have the same top speed. The top speed of both versions of Yamaha golf carts is 19 mph (31 kph).Apr 12, 2021

Is 30 mph fast for a golf cart?

Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.Oct 4, 2021

How fast is a Yamaha golf cart?

Yamaha golf carts have a top speed of 19 mph for both gasoline and electric models.

How to remove cable from carburetor?

Remove the cable from the carburetor and cover its sheath opening using duct tape. To do this, make a small funnel with the tape and ensure that the wire sticks out from its middle. Loosen the nut that fixes the cable on to the mount housed on the motor just before its entry into the carburetor.

Which is more powerful, carb or EFI?

The carb model is more powerful as well as starts and goes faster when compared to the EFI. The EFI experiences delay to start moving when the pedal is pressed.

Where is the main jet on a 4-cycle engine?

The main jet in the carburetor diagram of a 4-cycle engine is located below the carburetor while the pilot jet is present on top of it. The needle valve and float pin are also housed under the carburetor.

What is a golf cart?

Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.

How many times can a Yamaha engine be rebuilt?

Yamaha engines are durable and because of the simple design, they can be successfully rebuilt 3 or 4 times . Initially, the Yamaha G1 2-cycle gas was the standard-bearer and in 1985 the G2 4-cycle single-cylinder gas engine was introduced as the new standard.

Does the G21 have a filter?

The G2, G9, G11, and the G21 model Fuel tank has a screw-in filter that is difficult to reach. It is advisable to remove the 2-4 bolts holding the tank in and pull the tank out to drain and replace the filter. Please note that on ALL models using the screw-in filter the tank will need to be drained.

What is an air filter?

The air filter is cylindrical with a foam prefilter sleeve that fits over the paper element. The air filter element is oil-impregnated, and attempting to use an air hose to blow out the impurities will result in reducing the oil. This makes the filter less efficient and should be avoided. The foam cover should capture the majority ...

Special offers and product promotions

Amazon Business: Make the most of your Amazon Business account with exclusive tools and savings. Login now

Product description

Yamaha Golf Cart Carburetor Assembly Fits Yamaha G16 & G20 Golf Carts. For Four Cycle Gas Carts. OEM # JN6-14101-15.

Customer reviews

There was a problem filtering reviews right now. Please try again later.

Customers who bought this item also bought

Pages with related products. See and discover other items: yamaha g16 parts, yamaha gas golf cart parts, yamaha golf carts parts

Golf-FAQ.com