On a gas-powered E-Z-Go golf cart, here’s how to adjust the governor. Locate the governor arm, which is located on top of the rear axle case, which is below the cart. Loosen the adjusting locknut that is located at the end of the governor spring. Tighten the adjustable locknut until it is snug.
How to adjust Governor EZGO?
Things You'll Need
- A crescent wrench
- A pair of channel lock's
- A set of torx screwdriver bits
- A screwdriver with interchangeable bits
How do you adjust the governor on a golf cart?
Yamaha G29 Governor Adjustment
- Remove the rear inspection panel from the golf cart. The spring accelerated governor is right below this panel.
- Use a 10mm wrench and tighten the nut a little by moving it in to expose the threaded rod a little more. ...
- Take the cart for a test drive to check for the desired speed.
How to remove drive clutch on EZGO golf cart?
How to remove a secondary clutch on an EZGO golf cart. First of all, make sure that the golf cart is turned off, and the brake is in place. Make sure to put pressure on the gas pedal. Use a clutch puller to remove the drive belt. Loosen the central bolt using an air gun.
How do you change oil in EZGO golf cart?
- The power from the engine transfers to the ring gear through a pinion gear. Again, the ring gear is connected to a spider gear. ...
- The spider gear can rotate at two different angles. ...
- The spider gear also meshes with the two side gears.
- This simple but complex mechanism allows the differential to act conveniently when you are making a turn.
How do you adjust the speed limiter on a EZ Go golf cart?
90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly. If you cannot find this spring, you likely have a newer model that is more difficult to adjust, though this is rare. Lift up the seat.
Is there a governor on an electric ezgo golf cart?
Considering electric golf carts don't have governors like gas powered carts, the old-school method of simply removing the governor is not an option.
How do you bypass the governor on a EZ Go golf cart?
General InstructionsDetach the cable from the carburetor. The cable is about the width of a straw. ... Follow the disconnected cable up to the governor. ... Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ... Using your wrench, remove the bolt on the gas pedal shaft.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
How do you adjust the governor on a golf cart?
Adjusting an EZ-GO Golf Cart GovernorStep 1 - First, lift the seat of your engine to reveal seat cousins. ... Step 2 - Remove the seat cushions over your motor. ... Step 3 - Remove the black plastic cover to expose the motor. ... Step 4 - Loosen the smaller one and tighten the larger one to increase your cart's speed.More items...•
How can I make my electric EZGO go faster?
0:1613:00How To Make Electric Golf Cart Faster | Plum Quick Bandit Speed UpgradeYouTubeStart of suggested clipEnd of suggested clipWe want to put this switch into tow mode. And also. I like to remove the positive battery cable toMoreWe want to put this switch into tow mode. And also. I like to remove the positive battery cable to the pack.
How do I turn off speed governor?
1:072:00How to remove your car's speed limiter como sacar limitacion de ...YouTubeStart of suggested clipEnd of suggested clipSelect on that and then. When you press cancel it means you're done and the tune will start toMoreSelect on that and then. When you press cancel it means you're done and the tune will start to upload you'll hear the fan kick on and then when you're all done it'll say the press select to enter.
How do I speed up my EZGO TXT electric golf cart?
You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries.Add more torque.Upgrade the motor.Increase the battery voltage.Decrease the load.
How can I make my electric EZ Go golf cart go faster?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
Where is the speed controller on an ezgo golf cart?
These speed controllers are located under the EZGO cart seat. Check the speed controller's attachment near the carburetor.
How does a golf cart governor work?
How Does a Golf Cart Governor Work? A golf cart governor is a mechanical device that helps in controlling the maximum speed of the cart when it moves on flat ground. This device prevents the engine RPMs from increasing beyond the recommended specifications.
How fast can an ezgo Rxv go?
The EZGO RXV golf cart can do speeds of 27 to 43 KMPH. However, the legally allowed top speed for golf carts is 20 MPH. So, the top speed is usually set just below this mark at 19.6 MPH (31.5 KMPH).
What is a golf cart governor?
A golf cart governor is a mechanical device that helps in controlling the maximum speed of the cart when it moves on flat ground. This device prevents the engine RPMs from increasing beyond the recommended specifications.
How fast is an EZGO golf cart?
The top speed of an EZGO golf cart is usually 19.9mph and the average speed is 14mph to 15mph. With governor adjustment, the EZGO cart can go faster by 5 to 10mph.
How to start a golf cart with a gas pedal?
Locate the gas pedal that is fitted to the governor and remove the connection. Re-route the gas pedal to the carburetor. Remove the bolt present on the shaft of the gas pedal. Slide the shaft upwards so that the gas pedal has more play. Tighten the bolt and start the golf cart.
How to change the speed of a golf cart?
Locate the spring on the differential or carburetor that helps in changing the cart speed by adjusting its tension. Increase the length of the cable that is fitted on to the body of the throttle and clutch of the two-stroke engine.
How to ride a golf cart at full speed?
Ride the cart at full speed over a course of known length. This will ensure that the governor controls the speed of the cart within factory specifications. Fasten the black plastic cover and put the seat back in place. Take care when tightening the nut. The more you tighten, the faster your cart will go.
Where is the governor arm on a golf cart?
Locate the governor arm of the golf cart. This is mounted above the rear axle housing and under the cart. Depending on the cart model, there may be a protection plate above the governor.
Can you remove a golf cart governor?
It doesn’t take much time or skill to remove a golf cart governor. With some basic mechanical expertise and general-purpose tools, you can do this yourself. The process is more or less the same in all golf carts.
How to make a cart faster?
Step 1. The first option to making your cart faster is to replace the electronic speed control. This will enable more voltage to pass to the motor, producing the desired result. Unfortunately, this upgrade is not inexpensive as the unit can run anywhere from $100 to $1,000. Step 2.
How fast can a factory cart go?
The factory gear most likely has a 12.5:1 ratio, which allows the cart to achieve somewhere around 14 mph. If you swap out the factory gear for one with an 8:1 gear ratio, you'll up your top end to about 20 mph.
Can you drive a golf cart faster?
It should be noted that the golf cart you are trying to make faster may not be designed to do so. Weigh the options carefully and exercise caution whenever driving a golf cart at any speed. Remember that golf carts are not equipped with seat belts, air bags and other safety equipment that you find in automobiles.
How to increase speed of EZ Go golf cart?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Do golf buggies have a carburetor?
Many older models have gas powered engines with a throttle and carburetor linkage. Aside from using the accelerator pedal to go slower or faster, there is a variety of options to adjust the speed of these great golf buggies.
