(VIDEO) How to Change Your Golf Cart Batteries – A Step by Step Guide
- Disconnect Charger and Turn Key to OFF. Make certain the cart key is in the off position and the charger is not connected. ...
- Take a Picture and Make a Sketch. Remove the seat to get to the battery bay and then make a sketch that clearly labels the position and polarity of ...
- Disconnect Main Negative and Positive Cables. Disconnect the main negative terminal first, then the main positive. ...
- Remove Remaining Cables. Remove the remaining cables, careful to make sure the wrench doesn’t touch the terminals and give you a shocking new hairstyle.
- Remove Golf Cart Batteries. Using the battery strap remove each old battery. They are very heavy, so be careful when doing so. ...
- Clean the Battery Bay. First place some cardboard covered with a towel under the battery bay. Battery acid can permanently mark concrete and almost anything else.
- Install New Golf Cart Batteries
- Reconnect Battery Cables. Start reconnecting all the battery cables and we recommend using lock washers when doing so to prevent cables from loosening over time.
- Test Test Test. With everything done correctly you should test the operation of the lights and other electronics and verify that the cart will operate in forward and reverse ...
- Charge the New Golf Cart Batteries. Give the new batteries a full charge before using the cart and you’ll be back on the fairways/roads at full power.
How to change the battery in a golf cart?
(VIDEO) How to Change Your Golf Cart Batteries – A Step by Step Guide 1) Disconnect Charger and Turn Key to OFF. Make certain the cart key is in the off position and the charger is not... 2) Take a Picture and Make a Sketch. Remove the seat to get to the battery bay and then make a sketch that ...
Do golf cart batteries go bad?
Knowing when your golf cart batteries are going bad is largely based on capacity. You would do a capacity test by fully charging the batteries, and then discharging them to verify that the capacity matches up within a reasonable number of specs based on the battery life. Over the life of a lead-acid battery, that capacity will diminish.
Why does my golf cart battery jump up when charging?
The voltage of the golf carts battery bank should jump up from the static state before you turned on the golf cart battery charger. You should always hook up your golf cart charger to your golf cart after use to keep the batteries in peak condition.
What kind of battery charger do I need for a golf cart?
We will be installing the New 912-4800 48 volt 13 amp Delta Q QuiQ golf cart battery charger which works better for on-board use. We will mount it out of sight and reclaim our much needed cargo space. Step One-Take Pictures!!! Even Battery Pete’s team takes pictures before a project like this.
How do you change the batteries in a golf cart?
Now, follow these step-by-step directions and you'll be patting yourself on the back for a job well done.1) Disconnect Charger and Turn Key to OFF. ... 2) Take a Picture and Make a Sketch. ... 3) Disconnect Main Negative and Positive Cables. ... 4) Remove Remaining Cables. ... 5) Remove Golf Cart Batteries. ... 6) Clean the Battery Bay.More items...•
Can golf cart batteries be replaced individually?
Replacing just one or two batteries instead of all can cause an imbalance. Newer batteries will release their power more efficiently, but older ones may experience too much resistance due to age and their condition, which doesn't help them either way.
How do I change the battery in my EZ Go golf cart?
1:225:28How to Replace Your Batteries in a EZGO RXV Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipWhile working with this golf guard doing anything electrical be sure to put the car into tow beforeMoreWhile working with this golf guard doing anything electrical be sure to put the car into tow before the beginning there are two battery nuts to each battery.
How do you hook up a 48v golf cart battery?
The main positive lead for the battery bank coming from the frame of the cart will connect to the positive terminal of the first battery in the bank. Then, connect a cable from the negative terminal of the first battery to the positive terminal of the subsequent battery in the bank.
How do I know if one of my golf cart batteries is bad?
Here are six signs to look for when batteries need replacing.Charge Times Are Out of Hand. Just like any rechargeable battery, the repeated cycles of draining and charging your battery can take a toll on it. ... No “Get Up and Go” ... You See Visual Signs. ... Driving Until They Die. ... People Are Always Running The Radio.
How much does it cost to replace a golf cart battery?
Average Price of Golf Cart Batteries The average price of a golf cart battery replacement is going to be in the $800 to $1,500 range. Depending on the type of battery, it could even be in the $2,000 ballpark because powerful golf carts like a 72V need more expensive batteries installed.
How do you put batteries in a 36 volt golf cart?
1:284:34Reviewing Battery Install of a 36 Volt Golf Cart - YouTubeYouTubeStart of suggested clipEnd of suggested clipBack on right 6 of them tied. In series creates 36 volts so you know this is your charge port onMoreBack on right 6 of them tied. In series creates 36 volts so you know this is your charge port on that on that easy go on the front. Here.
Can you put 4 12 volt batteries in a 48 volt golf cart?
With many golf cars requiring 48-volt battery packs, one of the most common money-saving assumptions is that purchasing fewer batteries with higher voltages will be a less expensive alternative. For example, a typical 48-volt golf car may use eight 6-volt batteries, six 8-volt batteries, or four 12-volt batteries.
How long should golf cart batteries last?
That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs. Other major factors include the type of options on the cart that may increase the draw from the battery pack.
What order do golf cart batteries go in?
7:399:14How to Replace Your Golf Cart Batteries - YouTubeYouTubeStart of suggested clipEnd of suggested clipOne thing that I do want to say is that you need to reconnect the cables that are connecting theMoreOne thing that I do want to say is that you need to reconnect the cables that are connecting the batteries first. And then your accessories. And then lastly.
How do you hook up 12 volt batteries in a golf cart?
1:193:39Using 12v Batteries in a 48v Golf Cart, instead of 8 / 6 volt battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd then positive to negative positive to negative positive to negative and then positive to theMoreAnd then positive to negative positive to negative positive to negative and then positive to the motor and by hooking them up in series you simply add up the volts.
How do you charge a 48 volt golf cart with a 12 volt charger?
0:353:54How To Charge Your Golf Cart Batteries Manually If ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipThese are eight volt batteries each but the 12 volt charger will not fully charge them but it willMoreThese are eight volt batteries each but the 12 volt charger will not fully charge them but it will get it up enough.
Can you mix new golf cart batteries with old ones?
Generally, mixing old and new batteries is not recommended due to possible issues with performance and safety. No matter what type of battery you use and the brand manufacturer, all batteries will eventually lose their electrical capacity as they age.
How long should golf cart batteries last?
That all being said, properly maintained battery packs in fleet carts tend to last about 4-6 years while private owners tend to get about 6-10 years out of their battery packs. Other major factors include the type of options on the cart that may increase the draw from the battery pack.
Should you charge your golf cart every time you use it?
Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use. Basically, new batteries love to be charged.
Can you run a golf cart on 5 batteries instead of 6?
Golf carts can run on 4 or 5 batteries. However, they are typically designed to run on 6 batteries and you need to make sure you have the correct amount of Volts.
How to remove old batteries from a car?
Use a battery strap to remove the old batteries and lift the new ones into place (if you can’t find one get some heavy duty zip ties). The batteries are much heavier than you might think.
How to know if your cart is slowing down?
The signs are already visible. Your cart starts to slow down before you finish 18. The batteries don’t seem to take a full charge. You could truck your cart to a dealer or have someone come by and install the new batteries for you, but all of that adds labor to the cost of the six 8 volt batteries, which is already substantial. Fear not. ...
How to clean battery bays?
Battery acid can permanently mark concrete and almost anything else. Then grab your baking soda and water solution and totally clean the battery bay and dry with a towel. Use a paint scraper to remove any excess acid.
Can you put batteries on cardboard?
Using the battery strap remove each old battery. They are very heavy, so be careful when doing so. In addition, they may have residual acid on the, so it is not a bad idea to place them on cardboard or some other form of a shield barrier to cement or the garage floor.
Do you need to charge the batteries before using the cart?
Give the new batteries a full charge before using the cart and you’ll be back on the fairways/roads at full power.
How To Change A Golf Cart Battery
In this article, we’re going to provide a detailed guide about how to install a golf cart battery safely. don’t worry It’s a very easy task and even a beginner can do it without any difficulty.
Tools Required For Replacing Cart Battery
To replace your golf cart battery, you’ll need some of these basic tools:
A Step-by-Step Guide About How To Change A Golf Cart Battery
Follow each of these steps carefully and install your batteries. In the end, you’ll be patting yourself for performing this job efficiently.
How To Make Batteries Last Longer?
There are a number of ways by which you can take care of the battery of your golf cart. Below we’ve mentioned some tips and basic rules to keep your battery safe and efficient for a long time.
FAQs – Frequently Asked Questions
For seeking optimal longevity, a battery with a high ampere capacity will hold a long charge. If you keep it clean and maintained, then its lifespan can be at least five years.
Does Battery Pete take pictures?
Even Battery Pete’s team takes pictures before a project like this. It is so easy to forget where “that wire” goes, especially if you get side tracked once you start this job. Everyone on the planet walks around with a camera in their hand these days – use it! You will thank yourself later when you need to reference something during the install.
Do golf cart batteries need to be replaced?
Golf cart batteries are heavy, so the less you have to handle them the better. You may need to replace the golf cart battery hold downs as they tend to rot out from years of battery acid leaking on them.
How many volts does a golf cart battery have?
Now, just because a battery pack displays 48 volts or more after a full charge does not mean they’re good. The real test would be to test them after they have been used for a few miles. The reason is that a deep cycle golf cart battery will not exhibit signs of needing replacement until after they are fully discharged.
How far can a golf cart go on a single charge?
Most Golf Carts can travel at least 7 miles or more on a single charge. However, if you are used to playing golf with no battery charge issues, but then one day you start to notice you can barely finish nine holes without having to limp home, then this could very easily be a sign of weak batteries.
How many volts does a battery pack have?
Typically, a charged battery pack will have 2-3 volts higher on a charger than its rated voltage. For example, a 48 volt system will have 51 to 52 volts after a full charge. We can test this by using a Volt Meter. Now, just because a battery pack displays 48 volts or more after a full charge does not mean they’re good.
Why is my electric golf cart not going fast?
3) Your Golf Cart does not accelerate as fast as it used to. Electric Golf Carts are known for being fast and having acceleration power. However, the day you start to feel your electric golf cart being slower to reach top speed is typically a sign of your batteries needing to be replaced. Also, another sign may be that it has trouble climbing hills ...
What happens if a battery goes bad?
Batteries that are going bad will expand and have bulges on the battery cases themselves. Also, batteries will be prone to leaking acid out of the case when they are on their last leg.
Do batteries hold a charge?
As the batteries age, they will not hold a charge as well as they used to. Unfortunately the charger will not know that, so the charger will continue to charge the batteries thinking they will eventually get to a full charge which means it will take longer to charge the batteries than normal.
Can batteries leak acid?
Also, batteries will be prone to leaking acid out of the case when they are on their last leg. RELATED: Symptoms of a Bad Solenoid on a Golf Cart.
No Pick-Up
Every golfer wants to hop in the cart and drive to the next hole quickly. This is a nearly impossible feat if the motor isn’t running as it should. Consider replacing the batteries if the cart has no pick-up. There’s nothing worse than spending ten minutes searching for a ball because the engine is moving slowly.
Funky Charging Times
Most golf carts should stay charged long enough so that a person can finish an entire round of golf. Golfers should think about replacing the golf cart batteries if the charge doesn’t hold. No one wants a cart to die while on the course. Luckily, Golf Cart Stuff has tons of golf cart parts and accessories to help resolve this issue.
Leaks & Bulging
Sometimes drivers can actually see when their batteries need to be replaced. Look into getting new batteries if there’s a strange leak under the vehicle. Acid leaks indicate that the cart is on its last leg, and the batteries have to go. Another visual sign it’s time to replace your golf cart batteries is if they’re emerging from their cases.
How to keep golf cart batteries charged?
Another good thing to have for your golf cart batteries is a watering system. Make sure you check the water level in your golf cart batteries monthly to make sure they are still saturated. ( always do this after your batteries are fully charged because if you check them and fill them before you charge them 100% you could over fill them and acid will leak out the top of the batteries while they charge and get all over your cart and in the garage or where ever you store the golf cart. Which is not good because battery acid will eat away at your concrete floor in the garage. Checkout Pete’s great deals on a new One point golf cart watering system to avoid over filling them and making a mess or getting battery acid on your cart, clothes or garage floor and do it with ease. ( In minutes – not an hour or more… weekends are meant to be spent with the family or watching the game not in the garage filling batteries… so get yours today!)
What to do if your golf cart battery hasn't taken a full charge?
If the battery has taken a charge, replace the cell caps and use your golf cart for a long ride and see how long the charge lasts.
How to clean a battery with acid?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.
Can you replace a golf cart battery?
If the ride and power is short lived it is still likely you will need to replace your golf cart battery. It is also quite possible that your golf cart battery charger is not charging properly. You will need a volt meter to check the power output of your battery charger.
