What are the different types of performance gears for golf carts?
This section contains various performance gear sets for a variety of golf cart makes and models including EZGO, Club Car and Yamaha. For some models, they are available with a 15:1 gear ratio (provides low end torque), 8:1 (medium speed) and 6:1 (high speed). Performance gears have been around forever in many different applications, like racing.
How do I choose the right gears for my golf car?
Be sure to select the proper gears for your intended application, taking into consideration the terrain. Most golf cars have a factory installed gear set (gas and electric) of about 12.5:1 ratio (the motor turns 12.5 times for each rotation of the drive wheel).
Is there a rear end diagram for club cars?
Here's a Club Car rear end diagram that will probably be all you need. It's pretty straight forward to install the gears. Thank you hot rod I found that diagram but the one you forwarded is much more clear. You had mentioned that thread but I searched with 0 luck but then again it is easy to miss a topic ..
How to fix a golf cart that won’t drive?
These are easy to fix but may require you to take the cart to a service provider. There is a spacer attached to the vehicle under the rear tire on the driver’s side. This can be found between the transaxle and the tire.
How do you change gears on a golf cart?
3:1118:56How to Increase Your Golf Cart Speed - Gear Upgrade Install - YouTubeYouTubeStart of suggested clipEnd of suggested clipYou can start to do it going back and forth finding just a little bit and you'll eventually get itMoreYou can start to do it going back and forth finding just a little bit and you'll eventually get it loosened. To where you can just grab the gear. It is fairly heavy.
How can I speed up my electric golf cart?
6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.
Do electric golf carts have differentials?
The differential and transmission are vital to your E-Z-GO cart's smooth function. The differential transmits torque to the golf cart wheels and allows them to turn at different speeds, especially on turns and curves.
How do you change the speed on a EZ Go golf cart?
Tighten the governor spring located in the engine of most golf carts to adjust your cart's top speed. 90% of EZ Go Carts have simple springs which limit the speed of the engine. To raise the top speed of your golf cart, all you need to do is locate this spring and tighten it slightly.
How can I make my electric golf cart go faster without upgrading?
How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.
Why is my electric golf cart so slow?
Low Battery Usually, the most common reason golf carts slow down is when they don't get enough power output from the battery. If the battery pack charge is very low and your cart is out of power, your cart will run slow.
What is a rear differential on golf cart?
A golf cart rear axle, often referred to a differential, helps propel your Yamaha G1, G2, G8, G9, G14, G16, G19, G22, and G29 the drive gas or electric golf cart. A differential slows the rotational speed of your clutch or electric motor before it hits the rear wheels.
How do I add oil to my rear end golf cart?
0:532:06Yamaha Drive 2 Quietech Golf Cart Rear Diff Oil Change - YouTubeYouTubeStart of suggested clipEnd of suggested clipOnce your oil is done draining. And you have reinstalled your drain plug you can then remove theMoreOnce your oil is done draining. And you have reinstalled your drain plug you can then remove the rubber fill plug this unit holds 16 ounces of gear oil they recommend an 80 90 weight.
What is a differential on a golf cart?
Your differential transmits torque to the Club Car wheels and allows them to turn at different speeds. While the transmission uses internal oil pressure to change gears and efficiently transmit engine power to the driveshaft and rear axle.
How fast will a 48v golf cart go?
The standard 48v golf cart will travel between 12 to 14 mph. However, if you apply modifications to the vehicle you can expect top speeds of 20 to 24mph.
How do I speed up my EZ Go golf cart 48v?
Increase the Voltage of Your Batteries Changing the batteries to ones that have higher voltages is one way to increase the speed of your golf cart. Increasing the battery pack voltage will increase the motor output of your cart. This will in turn boost the speed of the cart.
How do you take the limiter off a golf cart?
General InstructionsDetach the cable from the carburetor. The cable is about the width of a straw. ... Follow the disconnected cable up to the governor. ... Disconnect the gas pedal cable from the governor and reroute it to the carburetor. ... Using your wrench, remove the bolt on the gas pedal shaft.
How can I make my EZGO faster?
One way to increase the speed of EZ Go golf carts is to incorporate an octane booster when you fill the tank. The cart will have more pick-up, and it could gain as much as 5 mph. A different approach is to take out the throttle linkage governor on the carburetor.
Can you put 4 12-volt batteries in a 48 volt golf cart?
With many golf cars requiring 48-volt battery packs, one of the most common money-saving assumptions is that purchasing fewer batteries with higher voltages will be a less expensive alternative. For example, a typical 48-volt golf car may use eight 6-volt batteries, six 8-volt batteries, or four 12-volt batteries.
How do I speed up my EZGO TXT electric golf cart?
You can make your EZGO golf cart go much faster by adding more torque, upgrading the motor of or increasing the voltage of the batteries.Add more torque.Upgrade the motor.Increase the battery voltage.Decrease the load.
Do electric golf carts have governors?
Considering electric golf carts don't have governors like gas powered carts, the old-school method of simply removing the governor is not an option.
What is the gear ratio of a golf cart?
For some models, they are available with a 15:1 gear ratio (provides low end torque), 8:1 (medium speed) and 6:1 (high speed ).#N#Performance gears have been around forever in many different applications, like racing. However, they only made it into the golf car market in recent years. Performance gears not only include those designed for low torque, high speed applications, but also encompass those gear sets designed for high torque and low speed.
How many times does a golf car turn?
Most golf cars have a factory installed gear set (gas and electric) of about 12.5:1 ratio (the motor turns 12.5 times for each rotation of the drive wheel).
Do golf cars have gears?
However, they only made it into the golf car market in recent years. Performance gears not only include those designed for low torque, high speed applications, but also encompass those gear sets designed for high torque and low speed. Since golf cars have a fixed gear set in a non-shiftable configuration (the differential), ...
Why does my golf cart make a grinding noise?
If your golf cart is making a weird grinding noise while it is running, the issue could be due to bearings. Normally, we find that the cart makes a kind of groaning and grinding noise that can be very irritating. This is usually due to a problem with one of the physical or mechanical parts.
Where is the spacer on a car?
There is a spacer attached to the vehicle under the rear tire on the driver’s side. This can be found between the transaxle and the tire. If the spacer is loose, it could cause some grinding noise from the rear end. Check whether the axle is spinnable by hand and if so, it is indeed loose.
Is the Ping G25 adjustable?
Is the Ping G25 driver adjustable? The Ping G25 driver is adjustable. It’s possible to do four adjustments using the hosel adapter of the driver apart from the stated loft setting and...
Is the Taylormade M4 driver adjustable?
Is the TaylorMade M4 driver adjustable? Yes, the TaylorMade M4 driver is adjustable. It’s possible to have twelve different options for the loft, lie angle and face angle, including the standard...
Can a golf cart make a noise?
Golf carts can sometimes make some very weird noises. While these noises may not be particularly dangerous, they can be irritating and possible a sign of damage. If you want your golf cart to last you for many years to come, you’ll want to investigate and fix such noises. I have created this handy guide to help you troubleshoot any golf cart noises ...
