Install the pivot bearing pin and drain plugs back, remove reverse light switch. Pour 1.9 L - 2.0 L of fluid back to the trans. Put the switch pack in. Unlock the selector mechanism. You are good to go.
Full Answer
What kind of transmission fluid does a VW 0d9 use?
The 02E and 0D9 6-Speed DSG transmissions use VW TL 521 82 transmission fluid quality specification. VW TL 521 82 transmission fluid is also known as OE part numbers G 052 182 A2 and G 052 182 A6. What is the VW transmission fluid fill capacity for the DSG transmission?
How do you drain the transmission fluid from a VW Jetta?
Remove the 14mm hex bit VW DSG transmission drain plug along with the crush washer. Allow the VW Jetta, Passat, CC, Golf, Beetle, or Eos DSG transmission fluid to drain from the transmission. During this step, not all the transmission fluid will come out. Roughly 1.5 liters – 2 liters of DSG fluid will drain.
When to change the transmission fluid on a VW Aisin transmission?
The recommended service interval for changing the VW transmission fluid on Aisin transmissions is every 50,000 miles - 60,000 miles. Those with more aggressive driving styles, constant extreme heat, heavy city traffic, trailer pulling, or other severe driving conditions may want to replace the VW transmission fluid sooner.
Is DSG transmission fluid the same as automatic transmission fluid?
The DSG transmission features both manual and automatic modes of operation. For this reason, in this article VW DSG transmission fluid isn't strictly referred to as VW "automatic" transmission fluid (aka VW ATF).
How do you check the transmission fluid on a 2006 VW Golf?
0:534:25How To Check and Fill VW Golf Transmission Fluid aka ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipFirst select control module. Then go to auto trans control module. Then select measuring blocks orMoreFirst select control module. Then go to auto trans control module. Then select measuring blocks or eight.
When should I change my transmission fluid Volkswagen Golf?
While each manufacturer sets their own standard, a good rule thumb is to change your transmission fluid every 30,000 to 60,000 miles.
How do you fill transmission fluid in a VW Golf?
0:5113:002017 VW Golf Sportwagen ATF Service - YouTubeYouTubeStart of suggested clipEnd of suggested clipHead so you'll need one of these to get the fill port. Off underneath the vehicle take off theMoreHead so you'll need one of these to get the fill port. Off underneath the vehicle take off the plastic sheet. And here you can see the transmission. Uh cover or the fill fluid pan and the fill port.
How do you change transmission fluid in a Volkswagen?
0:0010:5509G Transmission Fluid and Filter Change Volkswagen Aisin | TF60-SNYouTubeStart of suggested clipEnd of suggested clipYou can use a 10 millimeter socket to remove the eight uh bolts around the outside of the pan uhMoreYou can use a 10 millimeter socket to remove the eight uh bolts around the outside of the pan uh generally i'll leave one in two corners um still in the pan. So the pan can be supported.
Does VW recommend transmission flush?
Volkswagen recommends a transmission fluid exchange every 30,000 to 60,000 miles for vehicles equipped with manual transmissions. If your VW comes with an automatic transmission, then expect a fluid exchange every 60,000 to 100,000 miles.
Where is the transmission dipstick on a VW Golf?
If your vehicle uses front-wheel-drive, the dipstick will be found towards the front of the engine closest to you. Rear-wheel-drive vehicles typically place the dipstick towards the back.
How do you check the transmission fluid on a 2005 VW Golf?
Here's what you need to do:Start by turning the car on. ... Locate the transmission fluid dipstick. ... Remove the dipstick, and use your fingers to test the consistency of the fluid. ... Now it's time to check your transmission fluid level. ... Carefully, use a funnel to bring the transmission fluid back to the proper level.
What transmission fluid does VW use?
The correct fluid is a synthetic mineral oil, such as Pentosin ATF-1, Mercon V or Volkswagen G 052 162 A2. 3.750 liters is usually sufficient for a filter change. The transmission fluid is checked from underneath the vehicle while running and the transmission in park.
How do you check transmission fluid on a Volkswagen?
How to Check Your Transmission FluidTurn the engine on for a few minutes before starting. ... Find the transmission fluid dipstick. ... Remove the dipstick and touch some of the fluid. ... Use a rag to wipe off the dipstick. ... Use a funnel to bring the fluid level up to the correct line without overfilling.
How do you put transmission fluid in a 2006 Volkswagen Jetta?
0:594:29How To Check and Fill VW Jetta Transmission Fluid aka ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipOnce the fluid has reached the proper temperature range remove the drain plug if the fluid level isMoreOnce the fluid has reached the proper temperature range remove the drain plug if the fluid level is correct a small amount of transmission fluid should begin to drip out of the fill port level insert.
How much does VW charge for transmission fluid change?
The Best in Auto Repair The average cost for a Volkswagen Jetta transmission fluid change is between $187 and $213. Labor costs are estimated between $97 and $123 while parts are priced at $90. This range does not include taxes and fees, and does not factor in your specific model year or unique location.
How often should the transmission fluid be changed?
every 30,000 to 60,000 milesIf you drive manual, most manufacturers will recommend changing your transmission fluid every 30,000 to 60,000 miles. If you have automatic, you can typically boost that range up to 60,000 to 100,000 miles. There's no harm in changing your fluid early.
What transmission does a 2006 Jetta GLI have?
This procedure is demonstrated on a 2006 VW Jetta GLI with the DSG 6-speed automatic transmission. However, these DSG fluid and filter how-to steps and procedures also apply to the following VW models:
Is DSG transmission fluid automatic?
The DSG transmission features both manual and automatic modes of operation. For this reason, in this article VW DSG transmission fluid isn't strictly referred to as VW "automatic" transmission fluid (aka VW ATF).
