Reconnect all the golf car battery cables and plug in your golf car charger. After a few seconds your golf car charger should turn on and begin charging your batteries. 8-volt batteries (48V System)
Can You charge a golf cart battery with a car charger?
You can charge a golf cart battery using your car charger designed for 6 volts or 12 volts applications by following the steps given below and adhering to a few precautions. Disconnect the battery cables from the battery using a wrench and take it out of the battery compartment.
Can I use a 36V charger for a 48V golf cart?
Really, any 36V charger, you are good to go. With 48 volt chargers, the same applies (you can swap out plugs), EXCEPT when you are attempting to use a 48V Club Car or its charger with the round 3-pin plug. The 48V Club Car chargers are completely different than all other golf cart chargers.
How to charge a lead acid golf cart battery?
The charging process is not complicated and by doing it correctly, you can extend the life of your lead-acid cart batteries. Check the temperature of the area where you have kept your golf cart. Postpone the charging process if the temperature is either too high or too low. Make sure that the cart is turned off before you begin charging.
How do you charge a 48v golf cart battery?
6:037:14How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo charge each individual battery for a half-hour. And then plug. In your old charger your regularMoreSo charge each individual battery for a half-hour. And then plug. In your old charger your regular golf car charger. And if it clicks on and starts to register voltage.
How do you trickle charge a 48 volt golf cart?
2:186:30How to Charge your Golf Cart Batteries Manually if your charger ...YouTubeStart of suggested clipEnd of suggested clipSo what we're going to do is. Take your first positive. Right there and connect the 12 volt chargerMoreSo what we're going to do is. Take your first positive. Right there and connect the 12 volt charger lead to the first positive. Now we're not going to charge one battery at a time.
Can you charge a 48 volt golf cart with a car battery charger?
These batteries are designed to be discharged almost completely and repeatedly with low loss in performance. Golf carts usually come with their own charger, however a car charger can also be used to charge a golf cart. The trick is matching the voltage of the charger to the voltage of the batteries.
Will a 12v charger charge a 48v battery?
However you can charge 48v with a 12v charger it will just take a lot longer also the slower you charge your battery the more life you will get out of it charging at a high rate does damage battery faster less life on battery.
Should I put a trickle charger on my golf cart?
If you tend to use the golf cart during the warmer months and store it during the winter, pick a trickle charger to make the battery last longer. These chargers connect to the battery over weeks or months at a time. They provide enough power to the battery to keep it charged but without harming the internal components.
How many volts is a full charge on a 48 volt golf cart?
55.2 to 56.6 voltsThe peak charging voltage for Gel batteries is 2.3 to 2.36 volts per cell, and for a 48 volt charger this works out to 55.2 to 56.6 volts, which is lower than a wet or AGM type battery needs for a full charge.
How do you trick a golf cart charger to charge a dead battery?
1:233:46Reviving Dead 6v & 8v Golf Cart Batteries FAQ - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since thisMoreSo what I'm going to do is I'm going to hook my positive to the battery one positive. And since this is this negative we make this battery six volt I jump to the corresponding.
How do you make a 48v battery charger?
0:1313:30How to make 12-48V battery charger with charging limit - YouTubeYouTubeStart of suggested clipEnd of suggested clipIt has to charge maximum to 34 volts and then disconnect. Because we don't want to or charge theMoreIt has to charge maximum to 34 volts and then disconnect. Because we don't want to or charge the battery cells to do that we need power inverter this is 48 volts power inverter you need some wires.
How do you put a golf cart battery back to life?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ... Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ... Step 3: Put the battery or batteries on a charger.
How do you charge a 48 volt with a 12 volt charger?
0:362:35Ask PYS - How Do I Charge a 48V Battery Bank With a 12V Alternator?YouTubeStart of suggested clipEnd of suggested clipHis suggestion was to probably change one of the 12 volt alternators to 48. And that's what i wouldMoreHis suggestion was to probably change one of the 12 volt alternators to 48. And that's what i would do too i'd have if i had the ability i'd have two alternators on my engine one for 12 one for 48.
How long does it take to charge a 48V battery?
between 2.5 - 6 hoursFully charging a battery typically takes between 2.5 - 6 hours, depending on the type of battery charger. Here's how to work out how long a charger will take to charge your bike battery: Let's say you have a 48-volt battery with 10 amp hours* and a 2 amp charger.
How many solar panels do I need to charge a 48V battery?
When charging 48V batteries, the system will need at least 2 panels in series but will perform much better with 3 or more panels in series, depending on the maximum voltage of the charge controller.
Can you use a battery maintainer on a golf cart?
With its small dimensions (6.5"W x 3.5"H x 1.8"D) you can install it anywhere you've got room on your cart, like under the seat. Or, just use it as needed without installation. Either way you'll enjoy all the features of this fantastic maintainer.
Can you put a battery maintainer on a golf cart?
36 Volt and 48 Volt Golf Cart Maintainers These units are designed for long term battery maintenance on golf cart or other 36 or 48 volt battery pack systems of 10 to 300 amp hours. They supply a float voltage (see tutorials), and pass whatever current is required up to 2.5 amps to maintain that voltage.
How do you charge a golf cart with a dead battery?
2:355:42How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf possible by setting it to the correct voltage or by connecting it to the right number ofMoreIf possible by setting it to the correct voltage or by connecting it to the right number of batteries at a time to equal its voltage.
How do you hook up a battery tender to a golf cart?
2:069:44Battery Tender trickle charge and maintainer installation - YouTubeYouTubeStart of suggested clipEnd of suggested clipThe bolt that goes on or the nut that goes onto the bolt that tightens that clamp around it but youMoreThe bolt that goes on or the nut that goes onto the bolt that tightens that clamp around it but you can keep the battery hooked up and that's really important because on modern day cars.
How Do You Charge a 36 Volt Golf Cart Battery?
If your golf cart has a 36-volt battery pack, it will probably have three 12v individual batteries or six 6v batteries. If you don’t have the charger that came with your golf cart, or if you need to run a maintenance charge, you can charge each battery in the pack individually and charge it.
What Should My Golf Cart Charger Read when Fully Charged?
Modern cart battery chargers have LED lights to show the charge status. Most of these chargers will have a light displaying that the charger is plugged into the wall and another light indicating that the charger is working. Once the charge is complete, another light will turn on, generally in green next to a sign “charge complete”.
What is the Proper Way to Charge an Electric Golf Cart?
If your electric golf cart batteries are in good shape, the proper way to charge an electric golf cart is to plug it into the electric network using the charger that came with your golf cart. If your golf cart didn’t come with a charger, you should find one that matches your vehicle’s charging socket and voltage specifications.
How Do You Trick a Golf Cart Charger?
When your golf cart’s batteries are completely discharged, you will have to “trick” your golf cart charger by using an automotive battery charger to manually charge them, at least to the point where your cart charger will read some voltage. That’s how you trick a golf cart charger.
How to Bring Golf Cart Batteries Back to Life?
When your golf cart batteries are completely dead, the best way of bringing them back to life is by charging them manually with a car battery charger. This is because your golf cart chargers are not designed to detect very low voltages and a regular car battery charger will jumpstart the process.
Can You Overcharge Golf Cart Batteries?
Overcharging golf cart batteries is dangerous and can cause damage so it’s not recommended. Batteries have many chemical components that heat up every time you charge them. Overcharging a battery will overheat these chemicals, ruining the battery and the heat buildup may make it catch fire.
How to connect a 36 volt golf cart to a 6 volt battery?
Step 1. Open the golf cart to expose the batteries. This is a 36-volt golf cart with six 6-volt batteries. Use the socket wrench to disconnect the batteries so they are connected in pairs. This can be done by disconnecting every other red positive battery cable. This produces three pairs of 6-volt batteries. The voltage of each pair equals 12 volts ...
What is a golf cart?
Golf carts are small battery-powered vehicles that are most commonly found and used on golf courses. These carts are also used as utility carts in some locations. Golf carts operate on multiple 6-volt or 8-volt deep cycle batteries. These batteries are designed to be discharged almost completely and repeatedly with low loss in performance.
How to charge two 6 volt batteries at once?
Turn the battery charger on and the charger will charge two 6-volt batteries at a time. Repeat Steps 2 and 3 for each pair of batteries. Another option is to use additional battery jumper wires to connect the other two battery pairs in parallel with the first battery pair. This would allow all of the batteries to be recharged at one time.
How many volts does a battery charger need?
Take the battery charger and verify that the battery charger voltage is 12 volts. Take the first pair of batteries and connect the outside positive and negative terminals of the battery pair to the positive and negative battery charger cables respectively.
Can you charge a golf cart with a car charger?
Golf carts usually come with their own charger, however a car charger can also be used to charge a golf cart. The trick is matching the voltage of the charger to the voltage of the batteries.
Jumper Cables and Car Battery Method
Probably the least expensive method to individually charge your golf cart batteries is to use your car and a set of jumper cables. How you hook this up will depend on what type of golf car batteries you have installed.
Jumper connection (36V)
I typically connect the jumper clamps to the dead battery posts first, then in this case, you want to connect the other end of your jumper cables to your car battery posts. You may want to start your car before connecting the posts, so your battery doesn’t run too low on your car.
How to save a golf cart battery from overcharging?
To save your battery from overcharging, you can use an automatic golf cart charger that will shut off once the batteries are fully charged.
What affects battery life of golf cart?
One of the most important things that affect battery life is your purchasing power. Do not buy a charger simply based on lowest cost. Consider the quality of the golf cart charger before buying.
How to save batteries from damage?
Avoid direct heat exposures such as radiators to save your batteries from damage.
Can changing batteries affect the battery?
However, improperly changing the batteries can surely affect the batteries. The wrong charger can break down the internal battery cells, so make sure to use the charger designed for your batteries.
Can you drive a golf cart on a steep hill?
Driving your golf cart forcefully on the steep hill could leave you stuck and damage your batteries.
Can you leave a golf cart inactive?
Leaving the golf cart inactive for an extended period reduces battery life. Using the batteries in a partial state of charge or storing the discharged batteries may damage them badly.
How long does it take to charge a golf cart?
It depends on three factors, 1) the quality of your batteries, 2) how discharged your batteries are and 3) the quality of your charger. If you have 5 year old batteries that are very discharged and you have a lightweight 2-5 amp charger, it may take a very long time (10 hours or more). If you have brand new batteries, they are 20-30% discharged and you've got a heavy-duty charger, it can be pretty quick (1-3 hours). Again, it depends on all of the above factors, so it really could vary quite a bit.
What is “Storage Mode” on my golf cart battery charger?
"Storage Mode" is a feature that comes with every Lester Electrical golf cart battery charger that we sell (except for the 48V Club Car Charge r - That battery charge r is ONLY automatic, meaning it will charge to full charge and then shut off. It will not come back on like the new Summit II battery chargers). When you plug in your charger to your cart it will fully charge the batteries. Once fully charged, the charger goes into its "storage mode" feature so long as it is connected to the golf cart and the wall. When in storage mode, it will charge your batteries only when the following two situations occur (1) the battery voltage drops to a certain predefined voltage AND (2) 10-15 days have elapsed. Once these two criteria are met, the charger will do a refresh charge to bring up the volts again to 100% fully charged. So, unlike a trickle charger that charges non-stop, the Lester charger charges only when the batteries need a good charge.
How Do I Troubleshoot My Golf Cart Battery Charger if It Isn't Working?
Just so you know, this situation happens EVERYDAY. The first question we always ask is, how long has it been since you've charged your batteries? We ask this because often times if it has been a while (a couple weeks or more), or if you just got brand new batteries, or if your batteries have been really run down recently, it is possible that the batteries may not have enough voltage in them for the charger to start working. An automatic golf cart battery charger needs a minimal amount of voltage in the golf cart battery to even start working. They need somewhere in the range of 20-35 volts in the batteries to allow the chargers to know that they are connected up to batteries and to kick on.
What are some symptoms of a bad golf cart battery charger vs. bad batteries?
Bad Batteries: IN GENERAL, if the charger doesn't kick on or show any signs of life when you plug it into your cart, this is most likely a battery/connection issue. Learn more about the signs of a bad golf cart battery.
Will the golf cart charger automatically stop charging once the batteries are fully charged?
Yes. All automatic chargers are designed to charge your batteries until they are fully charged and then stop charging. So you do not need to manually shut off the charger or worry about overcharging your batteries. All Lester chargers are made with a number of internal safety mechanisms that ensure that they will never overcharge batteries.
What if I charge my batteries until my battery charger stops charging, but my golf cart won’t drive very far?
You probably need to test your batteries and likely will need to get new golf cart batteries.
Should I charge the golf cart after each use?
Yes. It is healthy for the batteries to be fully charged at all times. So, you should charge your golf cart every night. Automatic golf cart chargers will shut off once the batteries are fully charged, so there isn't a concern that they will be over charged.
How many volts does a golf cart battery use?
Most modern-day golf cart batteries come in either 6, 8 or 12 volts (the voltage being the force needed to create an electrical current, indicating the strength of the battery).
How often should you charge golf cart batteries?
Golf cart batteries should be kept fully charged at all times – this means hooking them up to a charger as soon as you are finished using the cart. Regular charging will prevent damage to the battery and give it longer-lasting life.
Should your golf cart be turned on when charging?
No. You should turn your golf cart off when charging its batteries. Trying to charge a golf cart while it is running is a pointless exercise, as the battery will be draining while you’re trying to charge it. A golf cart should only be turned on once its batteries are fully charged.
Should golf carts be plugged in all the time?
No, you should not leave your golf cart plugged in all the time. While automatic battery chargers are designed to shut-off once at full capacity, leaving a battery connected to power for long periods leaves it susceptible to damage should the electrical circuit be overloaded.
Should golf cart batteries make noise when charging?
If your golf cart uses a standard 12 volt flooded lead acid battery, then it is quite normal to hear a bubbling sound when it’s charging. However, if your cart uses a sealed battery (such as a gel or AGM battery), then a hissing or bubbling sound may indicate damage.
How do I keep my golf cart batteries from dying or corroding?
To ensure long-lasting life for your golf cart batteries, make sure you: keep them fully charged at all times; keep the water level in your battery cells at an optimum level; and keep the terminal connections on your battery clean. Doing these three things will prevent your battery from corroding or dying.
What type of lead acid is used in golf cart batteries?
Golf cart batteries do come in different types and models – including Flooded Lead Acid; Gel Lead Acid; and AGM Lead Acid – so it’s important to seek clarification if you’re uncertain about which replacement to buy.
How does a Lester golf cart battery charger work?
The Lester Electric Golf Cart Battery Charger you purchased is a transformer style charger that is designed to apply amperage and voltage for a length of time that replaces the energy used from last discharge. This is fairly old technology but very effective to charge your golf cart batteries. Depending on the battery chargers output (Amperage), the batteries size (Capacity), and DOD (depth of discharge), all this will determine the amount of time required to fully charge the battery bank in question. In the process as they reach maximum capacity the more electricity that is forced into the batteries the more it excites the electrolyte and gets electrons moving in the battery itself… (That is the boiling sound you hear)
How high does a 48V battery run?
No worries … I have seen 48v systems run as high as 58-60v when charging, but it is normal to see voltages around 50v-52v when sitting static for several days after a fresh charge cycle. Most common size lead acid batteries will be from .6 volts to .8 volts over advertised voltage on battery when fully charged. Always good to re-charge cart at the end of the day, never let it sit 1/2 -3/4 charged. re-charge then store when not in use.
Why are AGM batteries so picky?
AGM and Gel style batteries are even more picky than traditional lead acid batteries because they like more voltage and amperage to complete the same process. Hopefully this was helpful and insightful to ease your worries about your golf cart batteries and the golf cart battery charger.
Why do Trojan batteries get hit harder?
So no worries as the charger is just doing its thing… Trojan batteries actually like to get hit harder ( More Amperage applied) than others thru the bulk phase and finishing phase of a charge cycle because the lead plates are thicker than most competitors.
How long does it take for a lead acid battery to cure?
It takes on average 15-20 cycles at 50% DOD “Depth of Discharge”, to completely cure the new lead plates in a new lead acid battery and allow the battery to reach full capacity (That will be the advertised Ah rating at the 20hr rate.)
Why do lead acid batteries make noise?
Make no mistake lead acid batteries will always make noise in the charge process and finishing phase because of the specific chemistry and design that make a lead acid battery. It is also an important part to insure good battery health as well.
How many cycles does it take for a lead plate to cure?
The gurgling sound is common – and okay! It takes 15-20 charging cycles to “cure” the lead plates. Add more water during this phase. The boiling sound will become quieter. There will (and should) always be a bubbling noise. This process helps the battery to charge and function. Rick – response.