- Connect the battery and the charger like mentioned in the paragraph above (How to charge a golf cart battery that is completely dead) for charging a single dead golf cart ...
- If you’re using a 6V charger, charge each battery for a few hours until they have a 6V rating and connect to your cart’s charging receptacle to resume the charging.
- If you’re using a 12V charger, charge each battery for about half an hour before you make the changeover.
How to charge a dead battery in a golf cart?
Most golf carts are equipped with automatic chargers to ease the charging process. However, if this fails or there is some other problem like there is a dead golf cart battery, you may have to rely on manual charging. You can follow the steps given below for charging dead golf cart batteries or manually get the juice back to your batteries.
Do you need an 8 volt battery for a golf cart?
You never know when you need to use those little 8 volt batteries. They do come in handy. How to Charge Dead 8 Volt Golf Cart Batteries: One way to recharge dead golf cart batteries is to use a smaller 6 volt battery charger.
What to do if your golf cart battery is broken?
Again if the golf cart battery cables are broken or corroded they need to be replaced and reconnected accordingly. Also it is recommended to use some type of corrosion preventative on all terminal connections to avoid the elements eating away at your connector, cables or terminals. Try something like BatteryPete’s Corrosion Preventive!
How do you revive a 6v golf cart battery?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ... Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ... Step 3: Put the battery or batteries on a charger.
Can you revive a dead golf cart battery?
So being in a pinch a 12 volt battery charger will work to get some energy back into your dead golf cart batteries and revive them. The sole purpose here is to just get some energy back into the batteries so the golf cart battery charger itself can do the brunt of the charging and charge the batteries properly.
How do you force a golf cart battery to charge?
Drive the golf car for an extended period of time so the batteries will discharge, plug the golf car charger in again and repeat this cycle for about 3 or 4 times. Each time will increase the battery charge and golf car run time.
How long does it take a completely dead golf cart to charge?
Charge your batteries for 8 to 10 hours with the proper style of golf cart battery charger. The best practice is to charge overnight after you are done using your cart for the day. Even if you only used the cart for 5 minutes, you'll want to give the golf cart batteries a good charge.
How do I know if my 6 volt battery is bad?
1:373:37Testing For a Bad Battery - YouTubeYouTubeStart of suggested clipEnd of suggested clipThen hold the black lead from the voltmeter to the negative battery terminal. The voltage of theMoreThen hold the black lead from the voltmeter to the negative battery terminal. The voltage of the battery will appear reference this chart to determine if a battery has a short cell.
What do you do if your golf cart won't charge?
Golf Cart Won't ChargeCheck our outlet to make sure that you're getting power to your electrical outlet.Check the water level in your batteries, using distilled water to refill only. ... Check for corrosion or any loose cables on the batteries.Check the condition of your charger's cables (AC and DC cables).More items...
How do I bring my battery back to life?
Prepare a mixture of baking soda mixed in distilled water and by use of a funnel pour the solution into the cells of the battery. Once they are full, close the lids and shake the battery for a minute or two. The solution will cleanse the inside of the batteries. Once done empty the solution into another clean bucket.
Does Epsom salt help golf cart batteries?
Well, the battery acid in your cells may end up getting old and no longer holding a charge. When this happens, you can remove about half of it – as you have done already – and replace it with an Epsom salt and water mix. Salt is an electrolyte and will distribute electricity cells.
Does aspirin help golf cart batteries?
the battery. It is a reasonably safe approach and usually good for one more engine turn. Be warned that adding aspirin will shorten the battery life, as the aspirin will react with the sulfuric acid to form acetic acid. Good for a boost, but bad for the innards of the battery.
Can I charge golf cart batteries with a regular charger?
Golf carts usually come with their own charger, however a car charger can also be used to charge a golf cart. The trick is matching the voltage of the charger to the voltage of the batteries.
How do you trickle charge golf cart batteries?
2:186:30How to Charge your Golf Cart Batteries Manually if ... - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo what we're going to do is. Take your first positive. Right there and connect the 12 volt chargerMoreSo what we're going to do is. Take your first positive. Right there and connect the 12 volt charger lead to the first positive. Now we're not going to charge one battery at a time.
Can you overcharge golf cart batteries?
Overcharging your golf cart batteries may damage them. It is best to use an automatic charger that turns itself off when a battery is fully charged. Some older models lack this important feature. If you must use a manual charger, don't forget to turn it off.
How do you fix a dead golf cart battery?
2:355:42How to Charge Dead Golf Cart Batteries Manually - YouTubeYouTubeStart of suggested clipEnd of suggested clipIf possible by setting it to the correct voltage or by connecting it to the right number ofMoreIf possible by setting it to the correct voltage or by connecting it to the right number of batteries at a time to equal its voltage.
Does aspirin help golf cart batteries?
the battery. It is a reasonably safe approach and usually good for one more engine turn. Be warned that adding aspirin will shorten the battery life, as the aspirin will react with the sulfuric acid to form acetic acid. Good for a boost, but bad for the innards of the battery.
How often do you need to add water to golf cart batteries?
about once every 30 daysAlways fill the batteries after charging. The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
How do you revive a dead deep cycle battery?
Fill each of the battery's cells with distilled water and baking soda solution. Using a funnel, go gently with this approach. Replace the battery caps. For around 30 seconds, shake the battery.
How many volts should a wet cell battery be charged to?
A typical wet-cell lead-acid battery should be charged to about 14+ volts. Some manufacturers allow their batteries to support a maximum charging voltage of 14.3 volts. A sealed battery like a gel battery must generally not be charged beyond 14.1 volts. You may want to check whether the manufacturer offers a variation.
How to charge a deep cycle golf cart battery?
The following tips give an insight into the effective charging of a deep-cycle battery. Charge the deep-cycle battery fully between two consecutive uses of the golf cart. The battery must complete at least one full cycle before use. Check the water level periodically.
How many volts does a golf cart charger have?
There are about 8 different types of charger plugs that you can find across various golf cart models. While some of plugs are exclusively for either 36 volts or 48 volts carts, others will work with both voltages.
How to choose a golf cart battery charger?
How to Choose the Best golf Cart Battery Charger. You must choose a battery charger according to the voltage of your cart to prevent the possibility of damage to your batteries. Check the charging receptacle of your golf cart and select your charger accordingly.
What is the power of a golf cart generator?
The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart. The 48 volts system in a golf cart usually features an onboard computer (OBC) that controls the battery pack charging process and restricts the charging when the cart is moving.
Why does my golf cart go into tow mode?
Your golf cart usually runs in tow mode when it does not have enough power to get moving on its own. One reason may be that the batteries are old and do not have the same power as new ones. If this happens with new batteries, the most likely reason is that they don’t have enough charge.
How long does it take for a 5 year old battery to charge?
On the other hand, a 5 year old battery may take up to 10 hours to fully charge. With a good charger, you should be able to get your cart on the move with a few hours of charging. The charging time depends on various factors and following the right steps can help you get the best out of your battery.
Why is my golf cart charger not turning on?
This is because golf cart chargers get commands to turn on and off by receiving voltage back from the cart when plugged in. So, if your batteries have been run down all the way or left without charging for a long while, your charger may not activate when plugged in.
How many batteries does a golf cart have?
Because golf carts can have 6, 8, or 12 Volt batteries, you’ll want to pay attention to match that voltage on your charger if possible by setting it to the correct voltage or connecting it to the right number of batteries at a time to equal its voltage.
What happens if your cart battery isn't hooked up?
If your cart's batteries aren’t hooked up in the correct way, or there's a weak connection between them, it can lead to a loss of power and cause your charger to fail.
Can you charge a battery one at a time?
Ideally, your charger will match your batteries individual voltage and you can charge them one at a time, just like so. There is no need to disconnect battery cables, you’ll simply be sending low amp voltage into one battery at a time. Some owners may have to do some math here.
What is the Proper Way to Charge an Electric Golf Cart?
If your electric golf cart batteries are in good shape, the proper way to charge an electric golf cart is to plug it into the electric network using the charger that came with your golf cart. If your golf cart didn’t come with a charger, you should find one that matches your vehicle’s charging socket and voltage specifications.
How to Charge an Electric Golf Cart Step by Step
If your golf cart didn’t come with a battery charger, try to buy a charger from the same brand as your golf cart. If that option is not available, buy a battery charger that meets your golf cart’s specifications.
Can I Charge Golf Cart Batteries with a Regular Charger?
You can charge most golf cart batteries with a regular charger. However, there are some things you should keep in mind. There are different types of car battery chargers, and there are different types of golf cart batteries.
Can You Overcharge Golf Cart Batteries?
Overcharging golf cart batteries is dangerous and can cause damage so it’s not recommended. Batteries have many chemical components that heat up every time you charge them. Overcharging a battery will overheat these chemicals, ruining the battery and the heat buildup may make it catch fire.
What Should My Golf Cart Charger Read when Fully Charged?
Modern cart battery chargers have LED lights to show the charge status. Most of these chargers will have a light displaying that the charger is plugged into the wall and another light indicating that the charger is working. Once the charge is complete, another light will turn on, generally in green next to a sign “charge complete”.
How Do You Charge a 36 Volt Golf Cart Battery?
If your golf cart has a 36-volt battery pack, it will probably have three 12v individual batteries or six 6v batteries. If you don’t have the charger that came with your golf cart, or if you need to run a maintenance charge, you can charge each battery in the pack individually and charge it.
How Do You Trick a Golf Cart Charger?
When your golf cart’s batteries are completely discharged, you will have to “trick” your golf cart charger by using an automotive battery charger to manually charge them, at least to the point where your cart charger will read some voltage. That’s how you trick a golf cart charger.
How does a 12 volt battery charger work?
So being in a pinch a 12 volt battery charger will work to get some energy back into your dead golf cart batteries and revive them. The sole purpose here is to just get some energy back into the batteries so the golf cart battery charger itself can do the brunt of the charging and charge the batteries properly.
Why does my golf cart beep?
If you can get enough voltage and energy back into the batteries to make the golf cart move, beep or lights to work usually means there is enough voltage present at this point for the original golf cart battery charger to be plugged in and it will turn on to charge the batteries completely.
How many volts does a golf cart battery need?
Others require a little less. So for example a 36 volt battery charger would require approx. 25-30 volts to activate, whereas a 48 volt charger would require 30-35 or even 40 volts present to activate.
What does it mean when a golf cart battery is bad?
So being if the golf cart battery cable lug connector or connection between two batteries is bad the cart will usually not work, drive or charge. So check all the connections and cables for signs of corrosion or wear or completely broken off battery.
Why is my golf cart battery charger not working?
Ok…. So the first guess or main reason why your golf cart battery charger is not working right now is because the batteries in your golf cart are completely dead. ( Not always but usually 90% of the time) This is because the federal government years ago made it mandatory that all manufacturers ...
What to do if golf cart battery is broken?
Again if the golf cart battery cables are broken or corroded they need to be replaced and reconnected accordingly. Also it is recommended to use some type of corrosion preventative on all terminal connections to avoid the elements eating away at your connector, cables or terminals.
Can you use a 12 volt battery charger on a golf cart?
Hence tricking the charger to turning on. Otherwise you can use a regular 12 volt or 24 volt battery charger for a car, boat or Rv to get some energy back into those dead batteries.
Jumper Cables and Car Battery Method
Probably the least expensive method to individually charge your golf cart batteries is to use your car and a set of jumper cables. How you hook this up will depend on what type of golf car batteries you have installed.
Jumper connection (36V)
I typically connect the jumper clamps to the dead battery posts first, then in this case, you want to connect the other end of your jumper cables to your car battery posts. You may want to start your car before connecting the posts, so your battery doesn’t run too low on your car.
How long does it take for a golf cart battery to charge?
The good news is that most modern battery chargers do not take a long time to charge a battery. Maximum time may be 6 hours or less, depending. Tip #9: When you use your golf cart charger, just plug it in when the power gets low. These chargers will shut off once the batteries are at full power.
How to charge 8 volt golf cart batteries?
How to Charge 8-volt Batteries in a Golf Cart. The simplest way is to connect the proper charger to the corresponding battery post and then turn the charger on. There is no need to remove the batteries and you can do this one at a time or set of a series if the charger is powerful enough.
Why put 12 volt batteries in series?
That is why some people say to put the batteries in a series so that your 12 volt battery chargers can bring power to those dead batteries. While some people may have had limited success with using a 6-volt battery charger, the charger normally shuts down too soon.
What voltage does a gold cart come with?
Some will come with 8-volt batteries and others will come with 6-volt units. Do not assume which one your gold cart has. Double-check before you start your charging process or series set up. Then double-check to see if you have the right charger to handle the voltage required.
How much to fix a golf cart battery?
If not, then you may have to replace all the batteries in your golf cart. That may run you close to $1,000 to fix.
How long does it take to charge a 2400mAh battery?
For example, if you have a 2400 mah battery and your charger only puts out about 500 mah then you divide 2400 by 500. The answer is 4.8 hours to charge your battery. The key, of course, is not to overcharge your batteries.
Can you charge an 8 volt battery?
As you have already read, yes it is possible for you to charge up an 8 volt battery. There are a variety of ways this can be done. Some people advise against using a 12-volt battery charger on a single 8 volt battery. The risks involved may damage your charger during the process.