By taking the extra step to fill your golf cart batteries with distilled water, you help keep corrosion away and make your batteries last longer. You can check the water level simply by lifting up your seat where the batteries are located and you can take off the caps with a pair of gloves.
Why do golf cart batteries need water?
- Unplug the golf car charger from the golf car.
- Add water to the fill canister, or empty water bottle.
- Remove the caps on the batteries
- Place nozzle of fill canister or water bottle over the battery cell opening.
- Dispense water into the battery cell.
- Proceed to the next cell in the battery.
- When each battery is watered, replace the battery cap.
How to fill a battery with distilled water?
Wipe up spills and close the ports.
- If you accidentally overfilled the battery but there is no overflow onto the top surface of the battery, the best thing to do is just to stop filling and let ...
- Clean it with a rag or with paper towels by wiping away from the ports. ...
- After the job is done, discard the rinsed-out rag or paper towel in the regular trash. ...
Which golf cart battery is best?
What are the Advantages of Lithium Batteries for Golf Carts?
- Constant power – Unlike lead-acid batteries, lithium batteries operate at full power throughout discharge, even when they are at less than 5%. ...
- Lightweight – Lithium batteries are 50-60% lighter than their lead-acid equivalents. ...
- Fast charging – Lithium batteries can be fully charged within 1-3 hours. ...
Can I use purified water in my golf cart battery?
When the water inside the batteries evaporates, this results in a dry battery; resulting in reduced water levels. To add water to golf cart batteries, you need to fill the battery cells with distilled water. Fill the water above the battery plates by 1/4 - 1/2 an inch, but below the level of the vents.
How do I know if my battery needs distilled water?
above the internal “plates,” or about 1/2- to one-inch from the top of the battery (just to the bottom edge of the fill hole). If the fluid is below that, it needs to be topped off.
How often do you put distilled water in golf cart batteries?
Ideally, you should add as much distilled water as necessary to achieve a water level approximately one-eighth to one-fourth of an inch below the bottom of the vent when the battery is on a full charge.
What happens when golf cart batteries are low on water?
If the water level in your golf cart battery is too low, the plates inside the battery will dry out and begin to flake off. When this happens, you will lose the ability to recharge your golf cart, and you will have to replace your battery altogether.
Can you overfill water in golf cart batteries?
Overfilling the cells of a battery will cause the gas bubbles to expand inside the cell, which can lead to an explosion, if they are vented up in one spot. If the battery is overfilled with acid, it will cause an electrolyte reaction that adds more heat to the process of gassing. This can also lead to an explosion.
When should I fill my battery with water?
While a battery should only be filled after it is completely charged, you should also check the water level before charging to make sure there is just enough water to cover any exposed plates. After charging, add enough water to bring the level to the bottom of the vent, about ¾ below the top of the cell.
How much water do I add to a golf cart battery?
You'll want to add water to 1/2 inch from the top of the battery. 2) We recommend service once or twice a year. 3) Always use distilled water so you don't add additional minerals into your battery.
How often do you need to add water to a battery?
A battery should only be watered after it is completely charged. But, you should always check the water level before charging. Before charging, make sure there is just enough water to cover any exposed plates (rectangular metal parts visible when you look inside a battery).
How do you put a golf cart battery back to life?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. ... Step 2: Mix 8 ounces of Epsom salts into 2 quarts of warm distilled water: Stir thoroughly. ... Step 3: Put the battery or batteries on a charger.
How to add water to golf cart batteries?
To add water to golf cart batteries, you need to fill the battery cells with distilled water. Fill the water above the battery plates by 1/4 – 1/2 an inch, but below the level of the vents.
Why is distilled water bad for batteries?
This is because distilled water is the purest form of water and is free of contaminants, minerals, or chemicals that can hamper the chemical process that takes place inside the batteries. The presence of contaminants, minerals, or chemicals in the water can damage the batteries.
Why do you need to refill golf cart batteries?
This is one reason why you must always refill water in your golf cart batteries only when they are fully charged. Overfilling batteries with too much water can also result in boiling. Water from other sources may have been used instead of distilled water for refilling the batteries.
Why does my golf cart battery water boil?
This can be due to several reasons as given below. The charger used for your golf cart batteries is malfunctioning or is not working properly.
What are golf cart batteries made of?
Golf cart batteries consist of sulfuric acid and several other electrolytes. The battery plates must be submerged in them so that the required energy is produced to get the cart in motion. When the batteries are discharged, the level of the water that contains these electrolytes goes down.
Why does my golf cart have a problem with water?
The biggest problem that your golf cart will face if the batteries run out of water is sulfation. This happens because a lack of water in the batteries exposes the battery plates to the air for a much longer period than usual. As a result, the plates begin to start drying out and it starts flaking.
Why is my battery water level low?
Some of the reasons for a low level are as follows. The battery was not filled to the required water level last time when it was refilled. The ideal water level is just below the battery vent and above the battery plate. The battery has not had distilled water poured into it for a long time.
How do I know if my golf cart batteries need water?
When you are checking the water level in the cells of your battery, you want to make sure that the plates in the battery are covered with water, and that the water level is at the correct level when the battery is fully charged.
What type of water should I add to my golf cart battery?
Every major battery manufacturer recommends that distilled water be added to flooded lead acid batteries. There are a couple of acceptable alternatives, such as de-ionized (demineralized) water, or reverse osmosis water. But the recommendation is distilled water.
How much distilled water do you put in a golf cart battery?
The actual amount of water you may have to add will vary based upon the current level of water in your golf car batteries, but the end result is that you should add as much as necessary to achieve a water level approximately 1/8 – 1/4th of an inch below the bottom of the vent well when fully charged. See diagram above.
Can you put too much water in golf cart batteries?
You can add too much water to your golf cart battery cell. This should be avoided at all costs. You do NOT want to fill your golf cart battery to the cap. This will result in battery acid spilling out of the top of your battery, causing a mess and losing electrolyte and resulting in your battery losing capacity.
Can you use bottled water instead of distilled water in a battery?
Most bottled water has minerals added for taste. You should not use bottled water to fill your golf cart battery. Minerals will be attracted to and accumulate on the plates inside the battery and significantly reduce their capacity and life.
Should I charge golf cart batteries after adding water?
Your golf car should be fully charged before adding water to your batteries, but if you want to charge the golf cart batteries after adding water you can. Your charger may initiate an equalization charge which may cause your batteries to bubble and gas, so you may want to prevent or stop the equalization after charging for an hour or so.
What happens when golf cart batteries are low on water?
Trojan will periodically request that dealers or golf car distributors send them batteries that are being processed for warranty due to failure so they can perform a “battery autopsy” to determine the cause of failure. Sometimes a battery failure is due to a manufacturing defect, but many times they discover the failure is due to poor maintenance.
