Golf-FAQ.com

how to check vw golf water pump

by Dr. Freddy Ward Published 3 years ago Updated 2 years ago
image

Remove the three 10mm bolts holding the pump in place and gently pry the pump from the block. If you are inspecting the pump to see if it is good, you also want to check the gasket and mounting area as well for any corrosion or build up. Clean the mounting area before install a new pump.

Checking the Water Pump Pulley
Turn off your engine and then open the hood. Find the water pump pulley and wiggle it back and forth. The pulley shouldn't move at all. So if it feels loose, the bearings have failed and the pump will need to be replaced.

Full Answer

Is there a water pump on a Volkswagen Golf?

Your Volkswagen Golf’s water pump is one of the most crucial parts of the engine. If it doesn’t pump water through the engine, it’s going to overheat and do a lot of damage.

How do I know if my golf’s water pump is bad?

Typical signs of a bad water pump include overheating, white smoke, a bad smell, rough idle, and more. A water pump works by pumping water through the engine. If nothing turns it, it can’t pump any water. Taking a look at the health of the drive belt is always a great place to start if you are trying to figure out if your Golf’s water pump is bad.

Did VW know about water pump defects since 2016?

According to plaintiffs Michael Zhao and Dean Marriott, VW has known since at least June 2016 about the allegedly defective thermoplastic water pump modules which consist of a water pump, thermostat (engine temperature control actuator N493) and integrated sensors.

image

How do I check if my water pump is failing?

Five Signs Your Water Pump Is FailingOverheating. A dead or dying water pump cannot circulate coolant through your vehicle's engine and, as such, the engine will overheat. ... Coolant Leaks. Coolant leaks from the water pump are common and a clear sign that it's time to replace the pump. ... Corroded Water Pump. ... Whining Noises.

How do you check and see if your water pump is working?

5:1710:49HOW TO CHECK IF YOUR WATER PUMP WORKS & CIRCULATES ...YouTubeStart of suggested clipEnd of suggested clipTurn it up full blast through all the vents or open. And see if heats coming out got to be a lot ofMoreTurn it up full blast through all the vents or open. And see if heats coming out got to be a lot of heat. If.

What are the signs of a leaking water pump?

5 Symptoms of a Failing Water PumpCoolant Leaking. One of the first signs of a potentially faulty water pump is a puddle of coolant on the ground where you've parked your car. ... Rust or Deposit Build-Up. ... Noise. ... Overheating. ... Steam.

How does a VW water pump fail?

VW water pump usually leaks from the following areas: Age and/or high mileage is the most common cause of internal bearing and seals weakening or failing. Bad water pump bearings and seals usually cause a leak from the water pump shaft. Premature failure is typically due to contaminated antifreeze.

How do I know if my coolant is circulating?

Start your car's engine and allow it to idle. Look through the radiator filler neck to see if the coolant flows. At this time, it should not be flowing as your car has not reached the operating temperature to cause the thermostat to open. If you find the coolant is flowing, it means the thermostat valve is open.

What does a bad water pump sound like?

Whining or Groaning Noise A whining or groaning noise usually means that either a drive belt is loose, or the water pump pulley is bad. It may surprise your customer that a pulley could fail, but it does occasionally happen. Pulleys have been known to fail due to rust, which can cause cracking between their bolt holes.

What causes a water pump to fail?

The most common cause of water pump failure is simply from age and wear of its electric motor. Over time, most parts in a car or truck, auxiliary pumps included, start to break down due to constant wear and tear.

What happens when water pump goes out while driving?

If the water pump goes out while driving, your car will overheat almost immediately. Without a functional water pump, your vehicle has no way to push coolant into the engine.

How do you stop a water pump from leaking?

Water Pump Leak Repair: Water Pump RemovalFlush cooling system if necessary.Drain coolant.Remove engine belts.Remove other components to gain access to water pump bolts.Remove the water pump.Replace gasket or o-ring and install new pump.

How long do VW water pumps last?

Water pumps are designed to last at least 100,000 miles, however, if your water pump fails, you should replace it with a high-quality original-equipment level unit. Less expensive replacement pumps are available, but they might only have a service life of 30,000 miles.

How much does it cost to replace a water pump on a VW Golf?

$375 to $787Taking all these points into consideration, you can expect to pay anywhere from $375 to $787 (including parts and labor). Of course, shopping around to get a few quotes is your best bet to get the best deal.

Why is my coolant low but no leaks?

If you've ruled out an internal leak, that means your engine is burning the coolant somewhere else. The most common place is the radiator cap. Radiator caps hold the pressure inside the system, but if it's not sealing properly, then some hyper pressurized coolant will escape in the form of steam.

Where is the water pump located on a VW?

The location of the water pump on most engines is directly behind the timing belt on the front side of the engine. VW inline mounted engines must be put into the service position first.

How to tell if VW water pump is leaking?

When a VW water pump is leaking, you'll usually find a trail of coolant from the water pump area down to the lowest point of the engine (depending of model). Removing the engine covers and visually inspecting the water pump is necessary.

What causes a VW 3.0L water pump to leak?

However, the evidence revealed that the leak was caused both using RTV gasket material and coolant contamination. Using RTV material can cause the gasket to slip, resulting in misalignment during installation, producing a coolant leak. Sealing agents vary in composition and intended usage. When used in conjunction with composite paper gaskets, they negatively affect the gasket's ability to properly compress and perform the sealing function, rendering them ineffective. The abnormal coloration and thin film on the aluminum casting is evidence of acidic coolant contamination. See Crucial VW Coolant Flush and Fill Information.

How many miles does a VW 2.8L water pump last?

Image 1) Original water pump removed from a VW 2.8L V6 with approximately 80,000 miles. This pump was not leaking. Note the normal discoloration of the aluminum casting. This is the result of minimum coolant contamination for this type of mileage.

What happens if you don't flush the water pump in a VW?

If this debris or sediment is not thoroughly flushed from the cooling system when installing a new water pump, it will eventually lead to premature VW water pump failure.

What is a Blauparts water pump?

Blauparts only supplies the highest quality VW water pumps that are manufactured using the OEM design and components (i.e. internal bearings, seals, impeller). Blauparts supplies water pumps that use the OEM design. Including genuine OEM heavy duty bearings and seals (see VW water pump diagrams).

What causes a VW water pump to rub against other components?

There is the possibility that the internal VW water pump bearing will develop excessive play, causing a misalignment of the water pump pulley, allowing the timing belt to rub against other components, thus resulting in timing belt failure and engine damage.

1 Water Pump problem of the 2017 Volkswagen Golf

Replaced my water pump 2 times already. Now I am replacing thermostat housing. All this under 45000 miles. See all problems of the 2017 Volkswagen Golf 🔎 .

2 Water Pump problem of the 2015 Volkswagen Golf

This is a second repair for a failed thermostat housing/water pump on this vehicle. The first time, januaary 2019, the thermostat housing and related seals were replaced. This time the thermostat housing and water pump were both replaced. See all problems of the 2015 Volkswagen Golf 🔎 .

3 Water Pump problem of the 2017 Volkswagen Golf

Thermostat housing and water pump, coolant loss and leak. Dealer replaced thermostat housing March 2019 (24,000mi), 12/22/19 (37,400mi) another coolant leak likely from second thermostate or orignal water pump which was said not to have been replaced. Car is well maintained and cared for preemptively as a german car should.

4 Water Pump problem of the 2015 Volkswagen Golf

Thermostat housing & associated seals on the current 1. 8l and 2. 0l Volkswagen/Audi ea888 gen 3 engine are prone to failure, causing loss of engine coolant. This could affect any vw/Audi vehicle using the 1. 8 or 2. 0l ea888 gen 3 engine.

5 Water Pump problem of the 2012 Volkswagen Golf

While operating the vehicle under normal conditions, I heard a rattle from the engine, followed by the sound of something rattling in the engine compartment and then falling out. The engine died immediately and I was able to coast to the shoulder.

6 Water Pump problem of the 2012 Volkswagen Golf

On 12/24/2012, returning from a restaurant with my family, I heard a bang and my engine died while driving on a city street at 35 mph. I was able to safely put the car in neutral and roll off the street. I found out on 12/26 that my water pump had fallen apart, destroying my timing belt and engine head.

Why is VW water pump warranty unenforceable?

The class action also says VW's warranties are "unconscionable and unenforceable" because the pumps fail shortly after the warranties expire.

How much did the plaintiff pay for the water pump?

Technicians also performed a pressure test to verify there were no coolant leaks, and the plaintiff says he paid $1,340.82 for parts and labor. The water pump lawsuit alleges the part is made of plastic that cracks, while other manufacturers allegedly use different materials such as aluminum.

image
A B C D E F G H I J K L M N O P Q R S T U V W X Y Z 1 2 3 4 5 6 7 8 9