How do I find out what model my Yamaha golf cart is?
Step 1: Serial Number Lookup on Your Yamaha Golf Cart: It is likely located: Under the rear bumper on the frame; or; Under the seat where the floor board meets the motor compartment; or; Under driver side glove box . Step 2: Match the serial number to the table below to determine the model and year of your Yamaha golf cart.
What are the codes for drop out fault on a golf cart?
In rare cases, a motor replacement may be needed. The IQDM controller response codes for main drop out fault are A and C.This fault is detected if there are open solenoids when the golf cart is in use. The solenoid is losing ground and is therefore not able to establish a contact.
Where do I find the serial number on a G3 golf cart?
Finding the serial number on these is a breeze simply look under the front on the frame rails. The G3 was short lived and soon to be replaced by the G5. You can find the serial number on the G3 under the cart towards the rear passenger side tire.
How do I determine the model and year of my Yamaha?
Step 1: Locate the serial number on your Yamaha golf cart: It is likely located: Step 2: Match the serial number to the table below to determine the model and year of your Yamaha golf cart. Please note: You only need to match the first 4 characters of your serial number to determine your model/year: Here is an example:
How do I reset my Yamaha golf cart?
Identify your main battery supply (usually the largest battery) on your motor. Check around this supply for a small red button that may or may not be labeled “Reset”. Press and hold this button for a few moments and then release it to reset the motor.
Where is the reset button on a golf cart?
First, you'll want to reset your motor. It should have a small reset button (Usually it will be red) located near the main battery supply. Hit the reset button and then put the cover back on the motor. The next step would be to recharge your cart and try turning it on again.
How do you reset a gas golf cart?
Easily Reset the Club Car Golf Cart OBCKey switch to off.Set forward/reverse to neutral.Put tow/run switch to tow.Disconnect the negative battery terminal from the battery pack.Put the tow/run switch to run.Put forward/reverse switch to reverse.Put key switch to on.More items...
What does the red light mean on a Yamaha golf cart?
The light, usually red, starts flashing when the battery has got less than 10 percent charge left, in an electric golf cart or less than 10 percent fuel in a gasoline-powered golf cart.
Where is the fuse box on a Yamaha golf cart?
Yamaha Golf Cart Fuse Box Location The fuse box in a 2014 Yamaha golf cart is located on the left side of the controller. The wires are tied to the roof drain. In a G2 electric cart, the fuses are present on the rear inner fender. This is on the front of the driver's side of the cart.
How do you fix a gas golf cart that won't start?
Fuel Issues As you can imagine, lack of fuel is the most common reason that gasoline golf carts don't start. This issue is incredibly simple to fix in most cases – just add fuel to the cart and it will start again.
Why does my Yamaha golf cart not start?
As the main source of power to your electric golf cart, the batteries are commonly the cause for why your electric golf cart won't start. Acid-based batteries are typically used for electric golf carts and must be recharged in order to work properly.
How can I make my Yamaha gas golf cart go faster?
0:005:15Yamaha G29 Drive Golf Cart Governor Adjustment - MORE SPEED!!YouTubeStart of suggested clipEnd of suggested clipItself by tightening this nut down you're putting more pressure on the spring. So that the governorMoreItself by tightening this nut down you're putting more pressure on the spring. So that the governor has to work harder to pull back on the throttle.
How do you test a fuel pump on a Yamaha golf cart?
A simple way to determine the fuel flow is to remove the fuel hose at the carburetor and hold over a small container. Attempt to start the engine and if all is well, the fuel should spurt out with reasonable force in pulses as the crankcase pressure varies. We hope you've enjoyed out tutorial on golf cart fuel pumps.
What does blinking light on golf cart mean?
A green light flashing on the battery charger of your golf cart usually indicates the charge level of the battery. Short green flashes mean the charge level is below 80%, where long flashes mean the charge level is above 80%. If it is one solid green light it indicates the golf cart's battery is fully charged to 100%.
How do you reset a golf cart battery meter?
Battery Meter Always Shows Full Reset the battery meter. Unhook power to the battery meter for 10 minutes. This will reset the battery meter.
Why is my golf cart battery light blinking?
The light begins flashing when the battery state of charge falls below 10%. indicate a battery charging session has begun. Verification of a completed charge cycle must be confirmed by viewing the status indicator lights on the ERIC charger.
How to reset OBC on a golf cart?
Press the throttle pedal and lock it using a heavy object or request someone to hold it down for you. Wait for the reverse buzzer to sound and go off in about half a minute. Allow the golf cart to stay that way for at least five minutes so that the OBC is reset.
How to check if a golf cart is working properly?
To check this, disconnect the wires at the bottom of the breaker and connect them to a blade fuse of the same rating. If the golf cart functions properly, you need a replacement breaker. There is a problem with the wire harness between the controller and the circuit breaker. Alternatively, the controller may be defective.
What is the IQDM controller response code for relay coil fault?
The IQDM controller response code for relay coil fault is B . This fault is identified when the solenoid receives a voltage from the speed controller to activate its coil but there are no closed solenoid contacts.
What is anti tamper on golf carts?
The anti-tamper functionality is integrated into the Visage GPS of a Club Car golf cart. It affects the maximum speed when a GPS signal is not detected on the golf course.
What does it mean when the pedal limit switch fails?
A fault can also occur if the accelerator is pressed when the preferred direction is altered with a press of the Forward/Reverse switch. This fault also specifies that the pedal limit switch has failed to close. On an Excel Club Car, one or more diodes in the wire harness aren’t functioning.
What is an open fault circuit breaker?
The circuit breaker open fault is connected to the walk-away circuitry that has a 20A fuse and a walkaway relay. The 24-pin Pin 3 connector has the same voltage as the battery when the Run/Tow switch is set to run position.
Where to find the year of a Yamaha golf cart?
Usually found under the seat, under the driver side glove box area or on the chassis towards the rear of the golf cart. Under the bumper area usually.
Where to find serial number on G1 golf cart?
You can find the serial number under the golf cart towards the drivers side rear wheel.
Where is the serial number on a G3?
The G3 was short lived and soon to be replaced by the G5. You can find the serial number on the G3 under the cart towards the rear passenger side tire.
What is a G11A?
The Hauler or G11 was a limited production utility vehicle Yamaha used to test the market to see if they could fulfill the need for commercial customers abroad not planning on playing golf. You can look under the seat towards the rear of the cart to find the serial number. Serial Number.
Step 2: Match the serial number to the table below to determine the model and year of your Yamaha golf cart
Please note: You only need to search and match the first 4 characters of your serial number to determine your model/year:
How to Find the Year of Your Golf Cart
If your serial number begins with "JW9-3" then you have a 2013 Yamaha DRIVE.
