How to Convert a 36-Volt Golf Cart to a 48-Volt Golf Cart
- Determine the number of volts the golf cart requires to operate. ...
- Locate the battery label to find out what the amp-hour rating is of the current batteries installed.
- Use the wrench to remove the connectors on each of the batteries. ...
- Examine the battery connector cables that were connected to the older batteries. ...
What size battery do I need for a 36V golf cart?
At the 36V level, a 220-250 ohm resistor is common, while if you upgrade to 48V, you need to source a 470 ohm resistor as the replacement. The diode is installed across the smaller terminals as polarity protection. A diode is a one way gate for electricity.
How do you calculate battery voltage on a golf cart?
Perform An EZGO 36v to 48v Conversion - Golf Carts Forum Best www.golfcartsforum.com. Perform An EZGO 36v to 48v Conversion. A 48v conversion will add approximately 30% or more for sepex carts to both speed and torque on your existing 36v cart.This write up is for both the series and the sepex cart.
How to upgrade the battery in a golf cart?
Perform An EZGO 36v to 48v Conversion - Golf Carts Forum Offer www.golfcartsforum.com. Perform An EZGO 36v to 48v Conversion. A 48v conversion will add approximately 30% or more for sepex carts to both speed and torque on your existing 36v cart.This write up is for both the series and the sepex cart.
How do I know if my battery is 36 or 48?
Aug 27, 2019 · I'm going to show you if upgrading from 36v to 48v on a stock motor will increase the speed on your golf cart. I'll show you what components I upgraded, and...
How do you make a 36 volt golf cart 48 volt?
21:2230:29How to swap a 36 volt EZGO to 48 Volts with The Navitas AC SystemYouTubeStart of suggested clipEnd of suggested clipThis is just a take-off wiring harness for a 48. You remember this cart was a 36 volt and we swappedMoreThis is just a take-off wiring harness for a 48. You remember this cart was a 36 volt and we swapped it to a 48. So we had to have the the wiring harness to go with it.
Can you run 48 volts on a 36 volt motor?
yes, you can use a 36V motor with a 48V controller.Jun 11, 2015
How can I get more power out of my 36 volt golf cart?
Change the Motor Achieving higher speeds can be as simple as increasing the voltage of the battery from the standard 36-volt to a 42-volt charge. The increased voltage to the motor will give you more revs per minute (RPM), resulting in speeds up to 20mph.Dec 2, 2016
Can you put a 36 volt motor in a 48 volt golf cart?
a 36v motor will be fine on 48v, as long as you don't use too large of a controller. i think up to 500 amps should be fine. mine runs well with a 480 amp controller.
Can a 36V controller handle 48V?
usually the 48V conversion on a 36V controller will work but you can change the input power resistors too if needed.May 24, 2012
Can I use a 36V battery with a 48V controller?
Many 36V controllers work fine at 48V too. On some, the difference is only the low-voltage cutoff mark.Jul 19, 2007
How can I make my 36V ezgo faster?
3:4312:07SPEEDING UP THE EZ-GO MARATHON (1994) - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo you got a 36 volt motor 36 volt controller the easiest way to upgrade the speed is to go to a 48MoreSo you got a 36 volt motor 36 volt controller the easiest way to upgrade the speed is to go to a 48 volt controller 48 volts worth of batteries.
Is 30 mph fast for a golf cart?
Depending on how far you want to go on a full charge, you might want a 40mph or a 30mph golf cart. At top speed, most golf carts do around 14mph. However, with the advent of street legal golf carts and modifications, it is possible to go 35mph and above.Oct 4, 2021
How fast does a 36V golf cart go?
12MPHStandard 36V and 48V golf carts are capable of the same top-end speed (12MPH). You can, however, make your golf cart go faster by doing a couple of things: Larger Tires - You can purchase larger tires.
Perform An EZGO 36v to 48v Conversion - Golf Carts Forum
Perform An EZGO 36v to 48v Conversion. A 48v conversion will add approximately 30% or more for sepex carts to both speed and torque on your existing 36v cart.This write up is for both the series and the sepex cart. This is for controllers rated at 400 amps or less. Larger controllers require a different solenoid, fuse and diode. More ›
Basic Golf Cart 36V - 48V Conversion
The single largest misconception in the golf cart industry is that 48V cart will go further than 36V versions. You will NOT gain more range if you convert from six 6V batteries to six 8V batteries, but you WILL gain range if you use eight 6V batteries due to greater amount of lead. It all depends on your battery bank used with this 36V to 48V ...
How to Convert a 36-Volt Golf Cart to a 48-Volt Golf Cart ..
Step 1. Determine the number of volts the golf cart requires to operate. You can read the owner's manual to find the information, or you can remove the battery casing and see how many batteries are in the box. Multiply by six by the number of batteries you see to calculate the total voltage. The total should equal either 36 or 48. More ›
How To upgrade your electric v-glide ... - Golf Carts Forum
If you have a 36 volt v-glide Club Car and looking for more power options and a greater top speed you should look into upgrading to 48 volts. The first thing you must find out is if the cart is a resistor car or if it has an electronic controller. Click here to find out! The following things must be replaced when upgrading these carts. More ›
Converting a golf cart to run on lithium batteries ..
Depending on how you use your golf cart, and how hilly your golf course is, you can choose to replace the six eight-volt batteries (48-volt system) with either two, three or four 48-volt lithium batteries. A major difference between the lead acid batteries in a golf cart and lithium, is that lithium is scalable. More ›
Ezgo Golf Cart High Speed Series Motor Kit 36v 48v - Pete ..
Pete's Team is always standing by to help you! Please call direct 772-247-4653 if you are having technical problems placing your order. Additional information. Weight. 75 lbs. Dimensions. 24 × 24 × 14 in. Golf Cart High Speed Series Motor Kit Club Car Motor Controller Solenoid Ezgo Golf Cart High Torque Series Motor Kit 36v 48v. More ›
How to Upgrade Golf Cart Speed (Chip, Magnet, Code 2,3,4,5)
You can't use a speed chip in an EZGO TXT Series golf cart. If you're driving a 2002 EZGO Electric 36V TXT PDS golf cart on hilly terrain with four people, it's advisable not to opt for speed freedom or steep hill chip as it can burn the motor because of the load. Consider getting a new 400 amps controller, diode, solenoid, resistor and ... More ›
How many volts does a golf cart have?
Typically a golf cart holds a series of 6-volt batteries that power the drive train. The number of volts is determined by the number of batteries installed in the golf cart battery box. You can upgrade the battery system by replacing the current batteries with four 12-volt batteries for added power. By having a higher amp-hour rating on the larger ...
How to connect 12 volt batteries to a cart?
Place one of the 12-volt batteries in the cart box. Position the battery so the positive connection is near the battery connecting lead. Place the other batteries in the cart box with the opposite polarity terminals side by side. The final battery should have its negative connector facing the cart box's negative battery connector.
How to connect golf cart batteries?
Check to make sure the ignition switch on the golf cart is turned off. Align the batteries in the cart box so you can connect them in sequence. You will want to place negative connector cable of the first battery over to the positive connector cable of the second battery. Then you will place the negative connector of the second battery over to the positive connector of the third battery. Continue this process until you have linked all four batteries together.
When did Rod Myers start writing golf carts?
Turn on the switch, and your golf cart should work. Rod Myers began writing in 1995 at the "Houston Post.". He's also written for the "Houston Chronicle" and was the sports editor for the "LV Tribune.". Myers studied hotel/ restaurant management and business management at the University of Houston. How to Charge the Batteries in a Club ...
Can you replace batteries in a cart?
By having a higher amp-ho ur rating on the larger batteries, you can avoid more recharging times for the cart. You can replace the batteries with a few simple tools and limited knowledge of electrical circuits.
How much does a Dakota lithium golf cart battery weigh?
The best part is a set of Dakota Lithium weighs 1/4 as much as a set of lead acid golf cart batteries, allowing you to cut 300 lbs or more off your cart. Experience better golf cart handling, less wear & tear, and lower maintenance costs.
What is the amperage rating on a motor controller?
The amperage rating on the motor controller is the maximum amount of amps it will pull at any given time. This is important to know as lithium batteries can only provide so much power at once.