how to convert a 36 volt golf cart to a 48 volt

With golf carts, when you convert a 36v system to a 48v system, you have to get a new charger. If you go from 4 12v to 6 8v batteries, the total is still 48v, so no change is needed to the charger.

Full Answer

Is there a 36V to 48V conversion kit for golf carts?

Ezgo 36v to 48v Conversion Kit Navitas E-Z-GO is a 36v to 48v conversion kit for golf cart. It has a 5 kW motor with a Speed sensor/motor temperature harness. It has a 600 amp AC Controller with Bluetooth with a Mounting plate and hardware.

How fast will a 36V cart go on 48V?

If the cart is running 17 MPH on 36 volts now you'll definitely get over 20 MPH with 48 volts. Few other questions before the melt down of something. Do I have to Convert Voltage of 16 volts to 12 volts for headlights and ground lights under frame with converter. Not sure how this works after I convert 36 to 48 volts.

Is a 48 volt conversion bad for a V-glide?

I've done the 48 volt conversion on a few resistor coil Club Cars years ago and never had any trouble. As long as your V-Glide is in good condition it should be fine. The V-Glide will be your weak link.

What is the difference between a 36v and a 48V system?

A 48V system will give you more pep in your step and will pick up speed a little faster than a 36V system. Taking about Amps, a 48V system provides a little more range with fewer Amps. It’s a good idea to use a 48V system for terrains where the golf cart will need a little more push on hillier areas or little off roads.

Can a 36V golf cart be converted to 48V?

It all depends on your battery bank used with this 36V to 48V conversion. can only be accomplished through installing a 48V motor capable of higher torque, or installing a 48V controller with a higher current limit (amperage).

How do you upgrade a 36V golf cart?

1:255:54How To Increase Your Golf Cart Speed - Does a 36v to 48v Upgrade ...YouTubeStart of suggested clipEnd of suggested clipThere's several things that you're going to have to upgrade one being your 36 volts of 48 voltMoreThere's several things that you're going to have to upgrade one being your 36 volts of 48 volt charger with your charging port your solenoid diodes. And if you have a battery meter.

Does a 48 volt golf cart have more power than a 36 volt?

More gas (or more amperage) means you can drive further before needing to recharge. When choosing between stock 36v or 48v cart, the 36 volt golf cart will have less power (get-up-and-go). It also will not go as far on a single charge compared to the 48 volt golf cart.

Can you use a 48V charger on a 36V golf cart?

No, should not use a 48 volt charger on a 36 volt golf cart. A 36v cart uses 12 volts for each phase (or leg) of its power system, while the 48v cart uses 24 volts per leg. That means that if you try to charge your vehicle with too high voltage, it can fry the electronics on your golf cart.

What happens if you put 48V to a 36V motor?

It won't hurt it to try it. All the will happen is that the controller will shut down earlier if the cut off voltage is set for the 48v which might be right at 42v which would be peak on the 36v.

Can a 36V controller handle 48V?

Re: Will a 36 volt controller handle a 48 volt battery? Probably already stated and answered but a 36v controller will work on a 48v battery, its just the controller wont kick in for lvc.

How can I make my 36V golf cart go faster?

6 Ways You Can Make a Golf Cart FasterAdd More Torque to Your Golf Cart.Upgrade Your Golf Cart's Motor.Improve the High-Speed Controller of the Cart.Add Better Golf Cart Tires.Use a Higher Powered Golf Cart Battery.Watch the Weight in Your Golf Cart.

How can I make my electric golf cart go faster without upgrading?

How to Make an Electric Golf Cart Faster Without UpgradesWash Your Cart Properly. ... Inspect the Batteries. ... Refill the Battery Water. ... Check the Gas Pedal and Linkage. ... Measure the Tire Pressure. ... Charge Up Your Battery Unit. ... Lighten Up Your Cart's Weight.

How far should a 36V golf cart go?

A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge. The 48 volt golf cart offers many more advantages in all 2, 4 or 6 passenger models.

Can you charge 36V with 48V charger?

Generally speaking, yes, yes it will. No matter what kind of battery you're charging, if you hook up a 36v battery to a 48v charger and let it charge to completion, you're going to ruin your battery.

Can you mix old and new golf cart batteries?

Generally, mixing old and new batteries is not recommended due to possible issues with performance and safety. No matter what type of battery you use and the brand manufacturer, all batteries will eventually lose their electrical capacity as they age.

Can you leave golf cart charger plugged in all the time?

Manufacturers suggest leaving your golf cart plugged in all of the time while using an auto battery charger, as it will keep the batteries fully charged and always available. If batteries are not charged for prolonged storage, they may damage over time and deliver less capacity.