Your 6V gauges can operate on a 12 volt system as well, but you’ll want to install a voltage reducer in-line on your gauge’s power circuit. You’ll Need New Lighting and A New Heater Motor When you upgrade you’ll need to replace your 6V seal beams and bulbs with 12V seal beams and bulbs.
Full Answer
What is the difference between 6-volt and 12-volt batteries for golf carts?
6-volt batteries are built with heavier lead plates in each cell and usually have longer lifespans than 12-volt batteries. They can last from four to eight years, depending on maintenance, type, and use of the battery. 6-volt batteries also weigh less than 12-volt batteries, which makes them better for lowering the burden on your golf cart.
Should you convert your car’s 6 volt to 12 volt?
Properly maintained, these systems work just fine decades later. However, many vehicle owners decide to convert from 6 volts to 12 volts in order to be able to use more readily available electrical components.
Can you run a 6 volt gauge on 12 volt?
Incidentally, the engine will turn over much better on 12 volts, so if you’ve got a 6V system that’s slow to start, you might be pleasantly surprised when you convert. Your 6V gauges can operate on a 12 volt system as well, but you’ll want to install a voltage reducer in-line on your gauge’s power circuit.
Can you use 12-volt batteries in a 36-volt cart?
Can you use 12-volt batteries instead of 6-volt batteries in your 36-volt cart? Yes, you can. You must, however, use a deep cycle battery and not automotive batteries. The 12-volt starting battery you have in your car is a shallow discharge type.
Can you convert a golf cart to 12 volt batteries?
The short answer is yes. Standard car batteries are 12-volts, and you could connect three or four of them in series to provide the required 36 or 48 volts to your golf cart motor.
Can I put 6 12 volt batteries in my golf cart?
With many golf cars requiring 48-volt battery packs, one of the most common money-saving assumptions is that purchasing fewer batteries with higher voltages will be a less expensive alternative. For example, a typical 48-volt golf car may use eight 6-volt batteries, six 8-volt batteries, or four 12-volt batteries.
Can I replace my 6-volt batteries to 12 volt batteries?
If the two 6 volt batteries were wired in series to produce 12 volts total then a 12 volt battery would easily work as a replacement for them. If the two batteries were wired in parallel and the output voltage is 6 volts then no.
How do you change a 6 volt to a 12 volt?
1:5910:026 Volt to 12 Volt Conversion. Is It Easy? - YouTubeYouTubeStart of suggested clipEnd of suggested clipSo when converting from 6 volt to 12 volt of course you're going to need a 12 volt battery. Now inMoreSo when converting from 6 volt to 12 volt of course you're going to need a 12 volt battery. Now in order to make this car run on 12 volts really all i would need to do is change the battery.
How do you hook up 12-volt lights to a 48 volt golf cart?
0:061:09How to install golf cart 48 volt converter - YouTubeYouTubeStart of suggested clipEnd of suggested clipNegative goes to your negative side and these your black and yellow will be your positive andMoreNegative goes to your negative side and these your black and yellow will be your positive and negative going out to your lights. Or. Whatever else you're trying to power at 12 volts.
Why do they use 6-volt batteries in golf carts?
Runtime at 56 Amps One of the advantages of 6-volt batteries is their run time. In a study conducted by US Battery. They found that a 6-volt battery was able to run for 154 minutes at 56 amps. As a result, these batteries offer a longer range at this rate than the 8 and 12-volts provide.
Will any 6-volt battery work in a golf cart?
The majority of golf carts driven today use a 6-volt golf cart battery, which is why most online searches for golf cart batteries tend to take you straight to 6v options. Of course, as any golf cart owner familiar with using a 6-volt battery knows, there are reasons why people want to find another option.
Which is better 6-volt or 12 volt?
Because most 6-volt batteries have a higher amp-hour rating for each battery, it makes sense to purchase two 6-volts and wire them in a series. What is this? That gives you 12-volts, meeting your electrical system's needs. The 6-volt batteries last longer than most 12-volt ones, and they are lighter, as well.
Can you mix 6-volt and 12 volt batteries?
The short answer is no, you cannot simply parallel your 12-volt battery with the new 6-volt batteries (in series). You can only parallel batteries that are exactly the same brand and chemistry, including age. Otherwise it will result in unbalanced charging as well as shortened battery life.
Can you use a 12v coil on a 6V system?
You can run a 12v coil on a 6v car if you don't have a Ballast Resistor. It's not possible to use "12volt coils" on a 12volt car because they only read out at 3 ohms. The spark out of this coil is very weak.
Can you use 12 volts on a 6 volt starter?
Your 6 volt starter will also work with the 12 volt system, with the caveat that you want your engine to start up relatively quickly. That will prevent your starter from being engaged too long and overheating.
Will 12 volts burn up a 6 volt coil?
You can run a 1.5 ohm "12 volt coil" on a 6 volt car without a ballast resistor and it will run great.
Will any 6-volt battery work in a golf cart?
The majority of golf carts driven today use a 6-volt golf cart battery, which is why most online searches for golf cart batteries tend to take you straight to 6v options. Of course, as any golf cart owner familiar with using a 6-volt battery knows, there are reasons why people want to find another option.
Can I use 3 12 volt marine batteries in my golf cart?
The Technical Answer: Yes It's possible to use a marine battery in place of electric golf cart batteries. They're both technically gel lead acid batteries designed for deep-cycle purposes, reports It Still Runs. However, this similarity doesn't mean that they should be used interchangeably.
Can I run my golf cart on 5 batteries?
Golf carts can run on 4 or 5 batteries. However, they are typically designed to run on 6 batteries and you need to make sure you have the correct amount of Volts.
How long will a 36 volt golf cart run?
A 36 volt golf cart is adequate for 2 to 4 passenger use when you are primarily using it on flat a flat surface. The average drive time or range for a 36 volt DC system is about 30 miles on a full charge.
How to connect a golf cart battery to a battery?
Connect the positive lead from the golf cart to the positive post on battery number one, and place the negative lead to the negative terminal on battery 3.
What is the difference between a 12 volt and a 6 volt battery?
What Are The Differences Between 12-Volt And 6-Volt Batteries? Other than the obvious difference in voltage, 6-volt flooded lead-acid batteries have an advantage over the 12-volt flooded lead-acid batteries. 6-volt batteries are built with heavier lead plates in each cell and usually have longer lifespans than 12-volt batteries.
How long do 6 volt batteries last?
6-volt batteries are built with heavier lead plates in each cell and usually have longer lifespans than 12-volt batteries. They can last from four to eight years, depending on maintenance, type, and use of the battery. 6-volt batteries also weigh less than 12-volt batteries, which makes them better for lowering the burden on your golf cart.
Why is a 6 volt battery bigger than a 12 volt battery?
They have a larger discharge and recharge capacity – 6-volt batteries can discharge and recharge more often than 12-volt batteries, owing to the larger lead plates. The bigger the Amp-Hour on a 12-volt, the larger it gets – Going for a larger Amp-Hour rating on a 12-volt to compensate for the difference with the 6-volt means ...
What type of batteries are used in golf carts?
There are four battery types available for golf carts: AGM Lead Acid Batteries. Gel-Cell Batteries.
What is a 12 volt battery?
The 12-volt starting battery you have in your car is a shallow discharge type. It is designed to deliver a high amperage burst of power to start a car and not as a long, steady electric source. You will also need to confirm that your speed control and battery charger are compatible with this change.
What is a golf cart?
Golf carts are also known as golf cars. The term "cart", in its purest sense, refers to a vehicle that does not travel under its own power. Golf cars, however, are most commonly referred to as golf... link to Club Car DS Wiring Diagrams 1981 To 2002.
When did 6 volts start?
Between the 1930’s and the mid 1950’s, 6 volt electrical systems were the norm. Properly maintained, these systems work just fine decades later. However, many vehicle owners decide to convert from 6 volts to 12 volts in order to be able to use more readily available electrical components. If you decide to convert your 6V system up to 12V, here’s what you need to know.
Can a 6 volt starter work with a 12 volt starter?
Your 6 volt starter will also work with the 12 volt system, with the caveat that you want your engine to start up relatively quickly. That will prevent your starter from being engaged too long and overheating.
Can a 12V heater motor be replaced?
The heater motor will also need to be replaced. While this is isn’t a hard and fast rule, we have found that any given manufacturer’s first generation 12V heater motor can be interchanged with the same model’s 6V heater motor.
Can a 6V gauge run on 12V?
Incidentally, the engine will turn over much better on 12 volts, so if you’ve got a 6V system that’s slow to start, you might be pleasantly surprised when you convert. Your 6V gauges can operate on a 12 volt system as well, but you’ll want to install a voltage reducer in-line on your gauge’s power circuit.
Can you convert to 12V?
Converting to a 12V system doesn’t mean you’re going to have to invest in a bunch of new components. Your starter, distributor, and even your gauges can be kept. When you convert to 12V you can still use your existing 6V distributor; the only component that has to be changed is the condenser (it must be upgraded to a 12V type).
Can you change the ignition coil to 12V?
The ignition coil must also be changed to a 12V coil. You also want to be sure to use a 12V ignition ballast resistor that’s specific to the brand of vehicle that you’re working on…you don’t want to use a Ford ballast resistor on a GM, or a Chrysler on a Ford, or a GM on Chrysler, etc.
Can you replace a 6 volt bulb with a 12 volt bulb?
When you upgrade you’ll need to replace your 6V seal beams and bulbs with 12V seal beams and bulbs. Many times, 6V bulb sockets will accept a 12V bulb with a little effort. Try removing one of the bulb tangs with a file or grinder, just be sure to go slow and check for fitment. Of course, there are also 12 volt replacement bulbs designed specifically for 6 volt sockets.
How many volts does a golf cart have?
Most golf carts are 36V or 48V. Some larger people movers, and electric vehicles like electric snow mobiles, ATVs, or neighborhood electric vehicles (NEVs) are 72V.
What type of battery does a golf cart use?
Most electric golf carts operate with any deep cycle 36-volt or 48-volt battery system. Most golf carts arrive from the factory with lead acid 6 volt, 8 volt, or 12 volt batteries wired in series * to make a 36V or 48V system. For the longest run time, lowest maintenance costs, and longest lifespan we recommend upgrading to lithium iron phosphate (LiFePO4) batteries. For maximum weight savings we recommend either 12V DL+ 60 Ah batteries wired in series, or a single 48V battery like this one. Here’s 8 reasons why:
How to find the voltage of a battery?
Most batteries should have a voltage rating listed on them. Just multiply the voltage of the batteries by the number of batteries in the bank and you’ll get your rated voltage. Ex: Eight 6V batteries would be a 48V system.
What is the amperage rating on a motor controller?
The amperage rating on the motor controller is the maximum amount of amps it will pull at any given time. This is important to know as lithium batteries can only provide so much power at once.
How much does a Dakota lithium golf cart battery weigh?
The best part is a set of Dakota Lithium weighs 1/4 as much as a set of lead acid golf cart batteries, allowing you to cut 300 lbs or more off your cart. Experience better golf cart handling, less wear & tear, and lower maintenance costs.
Can you upgrade a golf cart battery to lithium?
Your vehicle’s motor is happy with any voltage as long as it is the same. For example if your golf cart has been running on 36V built out of 6 X 6V lead acid golf cart batteries you can replace it with 3 X 12V Dakota Lithium Plus 60Ah batteries to make 36V.
