Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.
Full Answer
Do I need to fully discharge my golf cart battery?
Shallow discharges will result in longer battery life. Lead-acid batteries do not develop a memory like rechargeable NiCads and do not need to be fully discharged before recharging. Use your golf cart and batteries often…avoid long periods of storage. 50% (or less) discharges are recommended. 80% discharge is the maximum safe discharge.
What should a 6 volt battery read on a golf cart?
On a 6-volt battery, you should have slightly over 6 volts, like 6.1 to 6.3. If you get a reading of something like 4.1, then one of the cells in this unit is bad or shorted. How To Test Golf Cart Batteries With A Hydrometer Specific gravity can be measured using a hydrometer.
How do you take the battery out of a golf cart?
The golf cart is used often for long distances and steep hills. Don’t use the cart for distances longer than it’s intended for and on steep surfaces. Open the battery compartment and take out the golf cart battery.
How do you discharge a battery charge?
4:166:30How to Charge and Discharge Batteries with B&K Precision's ...YouTubeStart of suggested clipEnd of suggested clipAnd the stop condition I said as a voltage to protect the battery it'll go down to ten point fourMoreAnd the stop condition I said as a voltage to protect the battery it'll go down to ten point four volts. And then stop then go to the last step which will be charged the battery again.
How do you trickle charge golf cart batteries?
2:186:30How to Charge your Golf Cart Batteries Manually if your charger ...YouTubeStart of suggested clipEnd of suggested clipSo what we're going to do is. Take your first positive. Right there and connect the 12 volt chargerMoreSo what we're going to do is. Take your first positive. Right there and connect the 12 volt charger lead to the first positive. Now we're not going to charge one battery at a time.
How do you discharge golf cart batteries?
1:403:09Battery Discharge Test - Customcarts.ca - YouTubeYouTubeStart of suggested clipEnd of suggested clipWe need to take the 84 minutes that our battery's held up at a 56 amp load and divide it by theMoreWe need to take the 84 minutes that our battery's held up at a 56 amp load and divide it by the hundred and two minute reserve capacity.
How far can you discharge a golf cart battery?
7) Do not discharge golf cart batteries beyond an 80% discharge. We recommended that you discharge your golf cart batteries to between 50-80 percent, do not go beyond 80 percent or to the point where your golf cart batteries are completely dead since this is not beneficial for the battery life.
Can you put a battery maintainer on a golf cart?
36 Volt and 48 Volt Golf Cart Maintainers These units are designed for long term battery maintenance on golf cart or other 36 or 48 volt battery pack systems of 10 to 300 amp hours. They supply a float voltage (see tutorials), and pass whatever current is required up to 2.5 amps to maintain that voltage.
Can a trickle charger ruin a battery?
Leaving an unattended trickle charger on for too long might lead to overheating, causing the battery to boil the electrolyte. The outcome would be a dead battery or a worse case scenario— a possible fire/explosion.
Can you leave batteries in golf cart over winter?
The best place to store any golf-cart batteries is by looking for a cool and dry area. It shouldn't be cold, such as an exposed area to the elements, but cool. Cool temperatures will slow the battery's discharge rate. You want a slow discharge so that the battery maintains its charge.
How long can golf cart batteries sit without being charged?
Still, golf cart batteries should be recharged after four hours of use. Nobody likes to be stranded. It takes several hours to re-charge golf cart batteries that have gone completely dead. To lengthen the lifespan of batteries, make sure they are fully charged before each use.
Should you disconnect golf cart batteries for storage?
It's important to either disconnect the batter- ies from the golf cart while in storage, to re- move any parasitic loads which can discharge the batteries, or based on the type of charger you have, keep the charger plugged into the golf cart.
How long do 6 volt golf cart batteries last?
When you take care of your golf cart's battery, you can expect it to last anywhere between five and ten years.
Should golf cart batteries be charged after every use?
Should you charge new golf cart batteries? Yes. New golf cart batteries should be charged every time they are used as this will extend their lifespan, help them retain their capacity for longer, and prevent discharge. It is vitally important to charge new golf cart batteries, even after their first use.
How often do golf cart batteries need water?
The typical schedule is about once every 30 days, but this may vary by several days depending on your specific situation. When filling the batteries, add just enough water to bring it 1/4 inch to 1/8 inch shy of the indicator ring to prevent overfilling.
How to check if a golf cart battery is dead?
There are four methods of checking whether your golf cart battery is dead. Use a multimeter to check the voltage of each battery in your golf cart. Use a hydrometer to check the gravity of the electrolytes in the batteries. Use the Load Testing method.
How to check the specific gravity of a golf cart battery?
Using a Hydrometer. You can use a hydrometer with a thermometer to check the specific gravity of the electrolyte in the golf cart batteries. If this value lies between 1.1 and 1.2, you must consider recharging the battery. Alternatively, if the value is between 1.225 and 1.265, you can continue testing your battery.
How to charge a 6 volt battery overnight?
Connect the battery to a three-phase charger that can charge 6 volts batteries and let it charge overnight. Check the charger status in the morning. If it indicates a full charge, check the battery cells once again and add some more distilled water to the cells with exposed battery plates.
Why does my golf cart battery keep going dead?
The reason why your golf cart battery keeps going dead may be due to loose connections, incorrect battery wiring, or having a faulty voltage regulator. The voltage regulator is at fault and tends to affect the starter solenoid.
Why does my golf cart battery drain so quickly?
The reason why your golf cart battery keeps losing charge or drains quickly, may be due to loose wires, corroded connectors or an insufficient amount of water in the battery. The battery connections may have become loose or the connectors are corroded.
How many amp hours does a golf cart battery last?
A bigger voltage drop is a sure sign of a failing or faulty battery. A golf cart battery comes with a specific amp hour rating at 20 hours. This is usually mentioned in the battery information sticker.
How much sulfuric acid is in a battery?
It’s worth keeping in mind that the sulfuric acid to water concentration for a fully charged battery is 1.28 while it’s 1.145 for a discharged battery. It’s highly recommended that you wear a pair of safety gloves and safety glasses when you use a hydrometer. Pour the electrolyte into the hydrometer.
How many amps does a golf cart battery take to recharge?
To recharge, the batteries will require 90 ampere-hours + 20% to make up for any charge deficiency.
How to tell if your golf cart battery is bad?
Symptoms of a failing battery or batteries could include the following: 1 You may notice the range decreasing over time. The range should be about 2 rounds of golf. 2 A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage. If this is experienced, your cart may be low on charge, the charger may not be functioning properly or you may have a battery issue. 3 On electric golf carts, the cart refusing to move at all on a charged set of batteries could be the controller not engaging when the voltage falls below a preset value. 4 It takes twice as long to charge your batteries as it did when you first had them installed. As the batteries age, they will not hold a charge as well as they used to. The charger has no way to know this and will continue to charge the batteries trying to get to a full charge – meaning it will take longer to charge the batteries than normal.
How to tell if battery life is nearing?
Draw electrolyte into the hydrometer several times to allow the thermometer to adjust to the temperature of electrolyte and note the reading. Observe also the electrolyte color. A gray or brown coloration shows that the end of your battery life is nearing.
What is a golf cart battery charger?
The battery charger is designed to bring a normally discharged battery back to full or nearly full charge in a given time.
What temperature should a battery be when charging?
This will also initiate the equalizing charge. The batteries should begin gassing and bubbling. Keep the battery temperature between 115 degrees and 125 degrees.
What is a Trojan T-105 battery?
Trojan T-105 batteries are the best-known premium battery and have nearly 100 years of manufacturing experience. Trojan Battery Company was founded in 1925 and developed the golf cart battery for the Autoette in 1952. The distinctive maroon color of the T-105 makes it easy to distinguish from its competitors.
How to tell if your golf cart is low voltage?
You may notice the range decreasing over time. The range should be about 2 rounds of golf. A “Shutter” is when the cart feels like you are running across a corduroy road or someone is tapping the brake in a rapid staccato. This is a classic sign of low voltage.
How many holes does a golf battery pack play?
In other words, a battery pack with a 60-minute discharge rating will usually run two rounds (36 holes) of golf before the pack needs to be re-charged. A pack that is rated at 15 minutes would normally play a 9-hole round; a 105-minute pack would play 3 18’s and a 9 before it would need to be re-charged, etc.
How many minutes of discharge time is a golf round?
The industry standard is that 30 minutes of discharge time = 1 normal, 2-person, 18-hole round of golf.
How many holes can you rent a golf car in one day?
The “30-minute rule” for one 2 person 18-hole round is an average, but it is used by golf courses to judge whether a golf car can be rented twice in one day, and by golf car manufacturers for warranty replacement purposes.
Can a golf car run below the cut off point?
Modern golf cars with electronic speed controllers will normally not allow the car to run below its cut-off point. If voltage in the battery pack drops below its cut-off point the controller will normally shut the car down until the voltage comes back up above the cut-off point.
How to charge a deep cycle golf cart battery?
The following tips give an insight into the effective charging of a deep-cycle battery. Charge the deep-cycle battery fully between two consecutive uses of the golf cart. The battery must complete at least one full cycle before use. Check the water level periodically.
How to choose a golf cart battery charger?
How to Choose the Best golf Cart Battery Charger. You must choose a battery charger according to the voltage of your cart to prevent the possibility of damage to your batteries. Check the charging receptacle of your golf cart and select your charger accordingly.
How many volts should a wet cell battery be charged to?
A typical wet-cell lead-acid battery should be charged to about 14+ volts. Some manufacturers allow their batteries to support a maximum charging voltage of 14.3 volts. A sealed battery like a gel battery must generally not be charged beyond 14.1 volts. You may want to check whether the manufacturer offers a variation.
How many volts does a golf cart charger have?
There are about 8 different types of charger plugs that you can find across various golf cart models. While some of plugs are exclusively for either 36 volts or 48 volts carts, others will work with both voltages.
What is the power of a golf cart generator?
The generator can charge the batteries that supply the power to an electric motor responsible for moving the cart. The 48 volts system in a golf cart usually features an onboard computer (OBC) that controls the battery pack charging process and restricts the charging when the cart is moving.
Why does my golf cart go into tow mode?
Your golf cart usually runs in tow mode when it does not have enough power to get moving on its own. One reason may be that the batteries are old and do not have the same power as new ones. If this happens with new batteries, the most likely reason is that they don’t have enough charge.
How long does it take for a 5 year old battery to charge?
On the other hand, a 5 year old battery may take up to 10 hours to fully charge. With a good charger, you should be able to get your cart on the move with a few hours of charging. The charging time depends on various factors and following the right steps can help you get the best out of your battery.
Why is my golf cart battery undercharging?
Undercharging: Undercharging caused by using a cheap golf cart battery charging system ( One that does not apply enough amperage in the charging cycle) can cause lead sulfate to gradually build up and crystallize on the plates greatly reducing the. battery’s capacity and ability to be recharged.
What is the specific gravity of a battery?
If the specific gravity measures between 1.100 and 1.220, the battery must be. recharged. If the specific gravity is between 1.225 and 1.265, the battery is ok to test. If the hydrometer has a temperature correction chart, be sure to adjust the reading for the battery’s temperature.
How to keep golf cart batteries charged?
Another good thing to have for your golf cart batteries is a watering system. Make sure you check the water level in your golf cart batteries monthly to make sure they are still saturated. ( always do this after your batteries are fully charged because if you check them and fill them before you charge them 100% you could over fill them and acid will leak out the top of the batteries while they charge and get all over your cart and in the garage or where ever you store the golf cart. Which is not good because battery acid will eat away at your concrete floor in the garage. Checkout Pete’s great deals on a new One point golf cart watering system to avoid over filling them and making a mess or getting battery acid on your cart, clothes or garage floor and do it with ease. ( In minutes – not an hour or more… weekends are meant to be spent with the family or watching the game not in the garage filling batteries… so get yours today!)
What to do if your golf cart battery hasn't taken a full charge?
If the battery has taken a charge, replace the cell caps and use your golf cart for a long ride and see how long the charge lasts.
How to clean a battery with acid?
Step 1: Tip the battery on its edge: Allow approximately half the battery acid to run out of each cell and into a plastic container. Clean the battery with your paintbrush dipped in a baking soda solution. Rinse your battery with plain water, making certain none of the water gets into any of the cells.
Can you replace a golf cart battery?
If the ride and power is short lived it is still likely you will need to replace your golf cart battery. It is also quite possible that your golf cart battery charger is not charging properly. You will need a volt meter to check the power output of your battery charger.
