How to tell if your Volkswagen Golf has a water pump problem?
Your Volkswagen Golf’s water pump is one of the most crucial parts of the engine. If it doesn’t pump water through the engine, it’s going to overheat and do a lot of damage. Typical signs of a bad water pump include overheating, white smoke, a bad smell, rough idle, and more.
How to remove the water pump from the engine block?
Remove the 2 hoses that are on the back side of the water pump. Remove the 10mm nut that holds the timing cover to the water pump. Remove the 2 remaining 13mm bolts that hold the water pump body to the block. Wowsers it is out it is far by far the better method.
How do you remove the water pump from a Honda Accord?
Remove the bracket by pivoting it up, then using a pry bar pry it out. Remove the 2 hoses that are on the back side of the water pump. Remove the 10mm nut that holds the timing cover to the water pump. Remove the 2 remaining 13mm bolts that hold the water pump body to the block.
Can you replace the water pump on a GTI mark 4?
Replacing the water or coolant pump on GTI Mark 4 is a doable job for a DIY'er but it is not a quick job. If you thought the thermostat was in an awkward and tight spot to work wait till you see the coolant pump.
How do you drain the coolant on a VW Golf?
0:181:45How to Drain the Antifreeze Coolant on VW JETTA ML4 GOLF MK4 1999YouTubeStart of suggested clipEnd of suggested clipAgain what you need to do next you need to go and remove the cap on the on the coolant reservoir.MoreAgain what you need to do next you need to go and remove the cap on the on the coolant reservoir. Right here because right now there is a wall of vacuum in the system. And it's all going to come out.
How do you change the coolant in a 2003 Volkswagen Golf reservoir?
0:037:40Coolant Tank Replacement 2003 VW GTI - YouTubeYouTubeStart of suggested clipEnd of suggested clipA couple of things that I like to do if you have the ability. And it's not required. I have someMoreA couple of things that I like to do if you have the ability. And it's not required. I have some hose pinch-off pliers that I can simply use to seal. The hoses that run to the tank.
How do you remove the water pump on a golf 4?
0:5114:46vw golf mk4 1.6 sr 8v water pump removal, inspection & replacement ...YouTubeStart of suggested clipEnd of suggested clipThat you remove underneath those plastic lugs you have the bolts to remove and as you can see thisMoreThat you remove underneath those plastic lugs you have the bolts to remove and as you can see this is a 1.6 SR. After the plastic casing you will be all the top of the engine.
How do you change a water pump on a VW?
7:5415:29How To Replace Engine Water Pump 2005-10 Volkswagen Jetta - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd there's three screws you need to remove. So you're gonna have to feel you can't really seeMoreAnd there's three screws you need to remove. So you're gonna have to feel you can't really see what's going on and loosen those up. And slide those out.
What coolant does VW use?
Volkswagen uses a specific Audi/VW G13 or G12 approved antifreeze. The exact kind that your particular model uses should be stamped on the expansion tank, as well as listed in the owner's manual. Volkswagen coolant is always pink or purple in color. Use the same color that your vehicle already has if you're topping up.
How do I add coolant to my mk4 golf?
1:292:26How To Add Coolant To Your Volkswagen - YouTubeYouTubeStart of suggested clipEnd of suggested clipReading to find your coolant tank look for a clear plastic tank you should be able to see theMoreReading to find your coolant tank look for a clear plastic tank you should be able to see the coolant a pink or purple liquid unscrew the cap anti-clockwise. And leave it to one side somewhere.
How do you know if your water pump is bad in your car?
5 Symptoms of a Failing Water PumpCoolant Leaking. One of the first signs of a potentially faulty water pump is a puddle of coolant on the ground where you've parked your car. ... Rust or Deposit Build-Up. ... Noise. ... Overheating. ... Steam.
How much does it cost to replace a water pump on a VW Golf?
Taking all these points into consideration, you can expect to pay anywhere from $375 to $787 (including parts and labor). Of course, shopping around to get a few quotes is your best bet to get the best deal.
How do you remove a golf 1 water pump?
1:206:01Replacing Water Pump, Golf Mk1 [part1] - YouTubeYouTubeStart of suggested clipEnd of suggested clipAnd just let the water just drip off there and just go open it out. And drop all the water. Okay soMoreAnd just let the water just drip off there and just go open it out. And drop all the water. Okay so after a good bit of struggling i did get the pump. Out have a cat.
When should I change my VW water pump?
Water pumps are designed to last at least 100,000 miles, however, if your water pump fails, you should replace it with a high-quality original-equipment level unit. Less expensive replacement pumps are available, but they might only have a service life of 30,000 miles.
How much does it cost to replace a VW water pump?
The Best in Auto Repair The average cost for a Volkswagen Jetta water pump replacement is between $1,021 and $1,178. Labor costs are estimated between $395 and $499 while parts are priced between $626 and $679.
How does a VW water pump fail?
VW water pump usually leaks from the following areas: Age and/or high mileage is the most common cause of internal bearing and seals weakening or failing. Bad water pump bearings and seals usually cause a leak from the water pump shaft. Premature failure is typically due to contaminated antifreeze.
How much coolant does a mk4 Golf need?
Coolant capacity is around 10 litres IIRC, so 3 bottles will give you 50/50 near as dammit.
What is G12 coolant?
Share. Valvoline G12++ Coolant Concentrate is a concentrated product based on monoethylene glycol and contains Si-OAT corrosion inhibitor technology to protect against limescale, corrosion, foaming, etc. As modern engines have high operating temperatures, they can easily reach damaging temperatures.
What is G13 coolant?
What is the G13 ? A long-lasting, ready-to-use coolant made from monoethylene glycol and glycerol. This coolant uses additives including a specific technology, pink/purple color, this coolant has the same cooling and antifreeze performance as G12++ in particular.
How do you change a coolant reservoir on a 2007 Volkswagen Jetta?
1:364:00How to Replace Radiator Overflow Bottle 05-13 Volkswagen JettaYouTubeStart of suggested clipEnd of suggested clipSlide this hose clamp down and off this hose. And then I'm going to pull this hose free. And youMoreSlide this hose clamp down and off this hose. And then I'm going to pull this hose free. And you want to just twist it and it helps to use the pliers to do this.
Why is my golf water pump leaking?
Leaking Water Pump. Water leaking from around your Golf’s water pump is a sure indication that the water pump could be bad. It could be the water pump or the water pump gasket causing the leak. You have to pull the water pump to replace the gasket.
Why does my water pump go bad?
The serpentine belt can cause the water pump to go bad if it’s been improperly installed, or if there’s too much tension on it. Here are some common signs that a serpentine belt is bad.
What does low coolant mean on a golf?
The problem is that low coolant can indicate a lot of different problems. It can indicate a bad radiator, radiator hose, or thermostat housing as well. 4. Overheating and/or Steam. If your Golf has leaked enough radiator fluid, there won’t be enough left to properly cool your engine, and it’ll overheat.
What does it mean when a water pump is noisy?
1. Noise. A noisy water pump can indicate that it has a bearing that is going out. The problem with most engine noises is that they are difficult to hunt down. If your water pump is easy to reach, you can gently place a really long screwdriver tip against it.
How to tell if water pump is bad?
Typical signs of a bad water pump include overheating, white smoke, a bad smell, rough idle, and more. A water pump works by pumping water through the engine. If nothing turns it, it can’t pump any water. Taking a look at the health of the drive belt is always a great place to start if you are trying to figure out if your Golf’s water pump is bad.
Why is my golf running hot?
A water pump that is struggling to function will cause your Golf to run hot. If you have a temperature gauge and you see that your Golf is running hotter than it should be, try parking and revving the engine a bit (in neutral or park).
Duralast Water Pump AWP-9270
Notes: 100% New. Timing Belt Should Be Replaced with Water Pump. Upgraded Composite Impeller PRICE: 62.99 Part: AWP-9270 SKU: 540706 Warranty: Limited-Lifetime Warranty Item Grade: OEM Standard Gaskets Included: Yes Pulley Included: Yes Product Condition: New Material: Aluminum Rotation: Clockwise
Duralast Water Pump 41511E
Notes: Auxiliary, 100% New PRICE: 145.99 Part: 41511E SKU: 163916 Warranty: Limited-Lifetime Warranty Gaskets Included: No Gasket Required Material: Plastic Housing, Plastic Impeller Rotation: Clockwise
Duralast Water Pump AWP-9249
Notes: 100% New. Timing Belt Should Be Replaced with Water Pump. Upgraded Composite Impeller PRICE: 89.99 Part: AWP-9249 SKU: 540703 Warranty: Limited-Lifetime Warranty Pulley Included: Y Product Condition: New Material: Aluminum
How to flush radiator water?
Use a garden hose and place it in the upper radiator outlet (red arrow). Turn on the hose and flush the radiator until the water runs clear out the bottom. Reattach all the hoses and fill with coolant. Do not forget if you are using concentrated coolant to mix it with the appropriate amount of distilled water.
How to cool down a radiator with distilled water?
Use a garden hose and place it in the upper radiator outlet. Turn on the hose and flush the radiator until the water runs clear out the bottom. Reattach all the hoses and fill with coolant. Do not forget if you are using concentrated coolant to mix it with the appropriate amount of distilled water.
How to clean a car with a blower motor?
Fill the car with water (some people will insist that you use distilled water but you are just going to drain it again so I use tap water) close the lid on the coolant reservoir and start the car, get in the car and turn the heat up to full hot and run the blower motor at full. Let this run for a few minutes.
